NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
652 reports25,910 miles · Jun 12, 2017
Engine
MY CHECK ENGINE LIGHT CAME ON @ 25900 MILES & MANUAL STATES BRING INTO DEALER RIGHT AWAY, THIS WAS ALSO CONFIRMED WITH A CALL TO THE DEALER.. WORK ORDER STATES"TECHNICAL SERVICE BULLETIN" STATES TECHNICIAN UPDATED ELECTRICAL CONTROL UNIT, & CHECK ENGINE LIGHT WENT OFF. MY CONCERN WHY IS THIS NOT A RECALL ITEM. SINCE THERE IS A …
Read full complaint
MY CHECK ENGINE LIGHT CAME ON @ 25900 MILES & MANUAL STATES BRING INTO DEALER RIGHT AWAY, THIS WAS ALSO CONFIRMED WITH A CALL TO THE DEALER.. WORK ORDER STATES"TECHNICAL SERVICE BULLETIN" STATES TECHNICIAN UPDATED ELECTRICAL CONTROL UNIT, & CHECK ENGINE LIGHT WENT OFF. MY CONCERN WHY IS THIS NOT A RECALL ITEM. SINCE THERE IS A SERVICE BULLETIN PUT OUR IN THIS ISSUE.
NHTSA ODI #10994406
95,000 miles · Jun 4, 2017
Air Bags
IN MY ELANTRA 2012 THE LIGHT OF THE AIRBAG IS ON, THE VEHICLE HAS NOT SUFFERED ACCIDENTS OR STRONG BLOWS, AND HAS FOLLOWED THE MAINTENANCE RECOMMENDED BY THE MANUFACTURER (FOLLOWING THE MANUAL), (95K MILES). THE DEALER SAYS THAT THE AIRBAG LIGHT MAY COME ON BECAUSE SOME OF THE SENSORS ARE DAMAGED; THE COST OF THE REPAIR CAN RANG…
Read full complaint
IN MY ELANTRA 2012 THE LIGHT OF THE AIRBAG IS ON, THE VEHICLE HAS NOT SUFFERED ACCIDENTS OR STRONG BLOWS, AND HAS FOLLOWED THE MAINTENANCE RECOMMENDED BY THE MANUFACTURER (FOLLOWING THE MANUAL), (95K MILES). THE DEALER SAYS THAT THE AIRBAG LIGHT MAY COME ON BECAUSE SOME OF THE SENSORS ARE DAMAGED; THE COST OF THE REPAIR CAN RANGE FROM $ 250 UP TO $ 3000. WITH THIS LIGHT ON, THE AIRBAGS WILL NOT DEPLOY. HYUNDAI HAS A GOOD REPUTATION, AND SAFETY SHOULD BE INCLUDED IN THE WARRANTY, ESPECIALLY SINCE THE VAST MAJORITY OF ELANTRA OWNERS COMPLAIN ABOUT THE SAME PROBLEM. (GOOGLING). THE SOLUTION SHOULD BE INCLUDED AS A RECALL.
NHTSA ODI #10993042
104,000 miles · May 30, 2017
Steering
CLICKING NOISE WHEN MOVING STEERING WHEEL IN EITHER DIRECTION. BOTH STOPPED AND WHILE DRIVING. NO RECALL YET BUT WITH THE NUMBER OF SIMILAR COMPLAINTS ONLINE, IT SHOULD BE. REPAIR ESTIMATE 425.00.
NHTSA ODI #10992158
55,900 miles · May 29, 2017
Air BagsElectrical System
THE CLOCK SPRING HAS WORN AFTER ROUGHLY 55K MILES AND JUST BEING OUT OF WARRANTY. DEALER REPLACEMENT IS $300 AND AIRBAGS WILL NOT DEPLOY WITHOUT REPAIR. THIS BEGAN AFTER GOING OVER ROUGH BRICK PAVERS AND THE LIGHT IS INTERMITTENTLY ON, PROBABLY ABOUT 80-90% OF THE TIME. AS I UNDERSTAND IT THE VERACRUZ AND SANTA FE MODELS HAD A S…
Read full complaint
THE CLOCK SPRING HAS WORN AFTER ROUGHLY 55K MILES AND JUST BEING OUT OF WARRANTY. DEALER REPLACEMENT IS $300 AND AIRBAGS WILL NOT DEPLOY WITHOUT REPAIR. THIS BEGAN AFTER GOING OVER ROUGH BRICK PAVERS AND THE LIGHT IS INTERMITTENTLY ON, PROBABLY ABOUT 80-90% OF THE TIME. AS I UNDERSTAND IT THE VERACRUZ AND SANTA FE MODELS HAD A SIMILAR ISSUE A FEW YEAR PRIOR (11-01-052) AND ONLINE SEARCHES SHOW THIS IS A COMMON ISSUE WITH (AT LEAST) EARLY PRODUCTION ELANTAS. WHILE OWNER DIY REPLACEMENT IS POSSIBLE, IT IS NOT RECOMMENDED DUE TO SRS SYSTEM IMPORTANCE AS WELL AS LACK OF ABILITY TO RECALIBRATE SOFTWARE.
NHTSA ODI #10992030
Mileage unknown · May 24, 2017
Air Bags
THE AIRBAG LIGHT IS ON. CLAY COOLEY HYUNDAI DEALER IN ROCKWALL, TEXAS DIAGNOSIS WAS THE CLOCK SPRING NEEDING REPLACEMENT. HYUNDAI TOLD ME "NO DEALER IN THE COUNTRY HAS THIS PART RIGHT NOW BECAUSE OF A DEFECT IN THE PART. THE MANUFACTURER MUST MAKE NEW PARTS THAT WILL NOT BE AVAILABLE UNTIL JUNE 2017." I WAS SENT AWAY AND TOLD T…
Read full complaint
THE AIRBAG LIGHT IS ON. CLAY COOLEY HYUNDAI DEALER IN ROCKWALL, TEXAS DIAGNOSIS WAS THE CLOCK SPRING NEEDING REPLACEMENT. HYUNDAI TOLD ME "NO DEALER IN THE COUNTRY HAS THIS PART RIGHT NOW BECAUSE OF A DEFECT IN THE PART. THE MANUFACTURER MUST MAKE NEW PARTS THAT WILL NOT BE AVAILABLE UNTIL JUNE 2017." I WAS SENT AWAY AND TOLD THEY WOULD CALL ME WHEN PARTS ARE AVAILABLE. MEANWHILE, MY AIRBAGS ARE DEACTIVATED AND MAY NOT DEPLOY IN A CRASH
NHTSA ODI #10991508
114,000 miles · May 15, 2017
Electronic Stability Control (esc)Exterior Lighting
TL* THE CONTACT OWNS A 2012 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 35 MPH AND DEPRESSING THE BRAKE PEDAL, THE EXTERIOR BRAKE LIGHTS FAILED TO ILLUMINATE. THE CONTACT DROVE THE VEHICLE TO AN AUTO PART STORE, BUT THE EMPLOYEE COULD NOT DETERMINE WHAT FUSE THE VEHICLE NEEDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN…
Read full complaint
TL* THE CONTACT OWNS A 2012 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 35 MPH AND DEPRESSING THE BRAKE PEDAL, THE EXTERIOR BRAKE LIGHTS FAILED TO ILLUMINATE. THE CONTACT DROVE THE VEHICLE TO AN AUTO PART STORE, BUT THE EMPLOYEE COULD NOT DETERMINE WHAT FUSE THE VEHICLE NEEDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V871000 (ELECTRONIC STABILITY CONTROL). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.
NHTSA ODI #10985859
70,000 miles · May 10, 2017
Engine
ENGINE TICKING. BROUGHT IT IN AND THEY INFORMED ME I NEED AN ENGINE REPLACEMENT. THEY ALSO INFORMED ME IF I DO NOT GET THE ENGINE FIXED AND CONTINUE TO DRIVE IT, IT COULD STALL AND OR POTENTIALLY BLOW UP. VEHICLE IS UNDER 100K MILES, HOWEVER I AM SECOND OWNER, SO IT IS NOT COVERED UNDER WARRANTY. I DO HAVE ALL OF MY SERVICE REC…
Read full complaint
ENGINE TICKING. BROUGHT IT IN AND THEY INFORMED ME I NEED AN ENGINE REPLACEMENT. THEY ALSO INFORMED ME IF I DO NOT GET THE ENGINE FIXED AND CONTINUE TO DRIVE IT, IT COULD STALL AND OR POTENTIALLY BLOW UP. VEHICLE IS UNDER 100K MILES, HOWEVER I AM SECOND OWNER, SO IT IS NOT COVERED UNDER WARRANTY. I DO HAVE ALL OF MY SERVICE RECORDS, I DEFINITELY MAINTAINED THE VEHICLE SO THERE IS NO REASON TO HAVE TO REPLACE THE ENGINE ON MY BEHALF. HAVE NOT GOTTEN IT FIXED YET AS I DO NOT HAVE 8K LAYING AROUND TO DO SO. HYUNDAI NEEDS TO RECALL THEIR 2012 ELANTRA ENGINES AS IT IS A MANUFACTURER PROBLEM.
NHTSA ODI #10984687
100,312 miles · May 3, 2017
Steering
THERE IS A LOT OF GIVE AND PLAY IN THE STEERING WHEEL WHEN YOU TURN IT THAT IT DOES NOT ACTUALLY TURN YOUR WHEELS.
NHTSA ODI #10983331
64,945 miles · Apr 27, 2017
Engine
ELANTRA WITH 1.8L ENGINE DEVELOPED AN ENGINE "TICKING" NOISE AT 60K MILES THAT DEVELOPED INTO A "KNOCKING" NOISE SHORTLY THERE AFTER. MAIN ROD BEARING FAILURE. HAD TO HAVE ENGINE SHORT BLOCK REPLACED. VEHICLE HAD SCHEDULED MAINTENANCE THAT INCLUDED OIL CHANGES MORE FREQUENTLY THAN REQUIRED. ENGINE WOULD HAVE DESTROYED ITSELF …
Read full complaint
ELANTRA WITH 1.8L ENGINE DEVELOPED AN ENGINE "TICKING" NOISE AT 60K MILES THAT DEVELOPED INTO A "KNOCKING" NOISE SHORTLY THERE AFTER. MAIN ROD BEARING FAILURE. HAD TO HAVE ENGINE SHORT BLOCK REPLACED. VEHICLE HAD SCHEDULED MAINTENANCE THAT INCLUDED OIL CHANGES MORE FREQUENTLY THAN REQUIRED. ENGINE WOULD HAVE DESTROYED ITSELF AND STALLED IF CONTINUED WITHOUT REPAIR. LIMITED SEARCH ON INTERNET SHOWED MANY OTHER SIMILAR COMPLAINTS. SOUNDS VERY SIMILAR TO NHTSA RECALL NHTSA REFERENCE #15V568000 ON HYUNDAI SONATA WITH 2.0L AND 2.4L ENGINES.
NHTSA ODI #10981005
97,000 miles · Apr 10, 2017
Engine
THE ENGINE IS MAKING A TICKING NOISE. WAS TOLD THAT THE LIFTERS NEED TO BE REPLACED AND THERE IS TOO MUCH BACK PRESSURE. I WILL NEED A NEW ENGINE. SEVERAL OTHER MODELS ARE UNDER A RECALL BUT NOT THIS BRAND.
NHTSA ODI #10971680
Official recalls
4Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Jul 2, 2020
Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air compressor to inflate a tire.
Consequence & remedy
Consequence: An overheated accessory outlet increases the risk of fire.
Remedy: Hyundai will notify owners, and dealers will replace the Tire Mobility Kit accessory outlet plug with a direct-to-battery connection wire harness kit, free of charge. The recall began September 28, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 193.
Dec 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Elantra vehicles manufactured October 29, 2010, to October 25, 2011. Due to an electronic stability control (ESC) sensor malfunction, the brakes for one or more wheels may be applied unexpectedly and the engine power may be reduced. These symptoms will be accompanied by illumination of the ESC indicator lamp in the instrument cluster.
Consequence & remedy
Consequence: If the one or more of the brakes are inappropriately applied, control of the vehicle may be lost, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will verify the proper operation of the ESC sensors, and update the ESC system's calibration, free of charge. The recall began June 6, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 137.
Apr 1, 2013
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence & remedy
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Additional source detail variants (2)
Structure
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Air Bags:side/window
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
EA12008 · Headliner Bracket Detachment
Opened Sep 13, 2012 · Closed Dec 9, 2013
Status: closed (inferred from source dates) · Air Bags:side/window; Structure:body:roof And Pillars; Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (3)
Air Bags:side/window
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Structure:body:roof And Pillars
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
PE12012 · Side Curtain Air Bag Improper Deployment
Opened May 10, 2012 · Closed Sep 17, 2012
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (2)
Air Bags
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Air Bags:side/window
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Illustration