IllustrationApparently a VERY common crankshaft angle sensor malfunction caused the engine to stall out at a stoplight, putting me in harm's way
2012 Hyundai Elantra
Owner reports · Recalls · Investigations
More warning signs than most Elantra years
Owner complaints for the 2012 Hyundai Elantra are substantially higher than the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Elantra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
690–25K
9225–50K
9950–75K
7375–100K
78100–150K
17150K+
428 reports with mileage · 224 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 139 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 126 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 124 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports11 fire reports30 injury reports
Electrical System complaints
126 reportsThe contact owns a 2012 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the instrument panel became inoperable and failed to operate as needed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 6…
Read full complaint
The contact owns a 2012 Hyundai Elantra. The contact stated that while driving at an undisclosed speed, the instrument panel became inoperable and failed to operate as needed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 66,000.
Driver side wheel baron was scrubbing together and brake fluid was leaking I lost speed can't go over 35 miles on the speedometer my airbag light is on on the dashboard, abs, the car with 2 lines and tire along with engine sign is on I look up for recall and it listed everything my 2012 Hyundai Elantra is doing I took it to Hyu…
Read full complaint
Driver side wheel baron was scrubbing together and brake fluid was leaking I lost speed can't go over 35 miles on the speedometer my airbag light is on on the dashboard, abs, the car with 2 lines and tire along with engine sign is on I look up for recall and it listed everything my 2012 Hyundai Elantra is doing I took it to Hyundai dealership in Orlando Florida on West colonial drive and 2 hours they called said it was ready they didn't do anything all the the same lights still on on the dashboard still leaking brake fluid and wheel baron and my brakes still scrubbing against each other speed reduction they claim they did the recall would not look at it again said they did it nothing changed I'm taking a risk of fire starting from brake fluid hitting the electrical box and wheel coming of and again All the lights on the dashboard is still on my name email address and everything is wrong on the paperwork except my phone number and I gave him my license with my information on it I'm asking the advisor how can he tell me that the work was done and recall doesn't necessary fix the problem but he knew my car remember everything that's impossible I told him why the lights still on and nothing changed also I asked him how do he know it's repaired he showed me no parts came off my car to say it was replaced nothing was replaced
I went to start my car and it would not turn over. All the lights were on, the vehicle wouldn't move out of park, and the security system kept going off. The last time this happened I had the starter replaced and the neutral safety switch and it was fine for a bit but now it's happened again. This is at least the 3rd time I've …
Read full complaint
I went to start my car and it would not turn over. All the lights were on, the vehicle wouldn't move out of park, and the security system kept going off. The last time this happened I had the starter replaced and the neutral safety switch and it was fine for a bit but now it's happened again. This is at least the 3rd time I've had this issue. Please help! I know I'm not the only one. I had to have AAA come and pick my car up and bring it to a garage.
A while ago the airbag light starting coming on intermittently and I originally thought it was the sensor detecting weight in the passenger seat or not and perhaps the sensor was a little off but did not investigate. Over time the light become on constantly but I didn't notice this shift until the horn stopped working recently t…
Read full complaint
A while ago the airbag light starting coming on intermittently and I originally thought it was the sensor detecting weight in the passenger seat or not and perhaps the sensor was a little off but did not investigate. Over time the light become on constantly but I didn't notice this shift until the horn stopped working recently too. After some troubleshooting of the fuse and relay, an independent shop determined that the clock spring is the issue. After researching online I discovered there is an extended warranty for the clock spring on my vehicle of which I was unaware. I do not recall receiving a letter about this [XXX] ), although the warranty extension was announced years before my vehicle showed signs of an issue. I also saw from other posts that the clock spring is a common issue possibly impacting the reliability of the airbags and horn and dealers have been hesitant to replace the clock spring until the issue reaches a certain degree of severity. Now I wonder if the airbags in my vehicle have not been ready to deploy in case of an accident since the seatbelt light started coming on and driving without a functioning horn adds more risk of an accident. I'm surprised that a recall was not previously issued as both the airbags and horn impact the safety of the vehicle. Apart from the concern of the part reliability itself, the lack of communication around the safety bulletin vs how recalls are communicated seems it could have put many at risk of malfunctioning airbags that would increase the severity of injury in an accident and a malfunctioning horn that would increase the chances of an accident. How is a faulty part that impacts functionality of the airbags and horn not a safety-related defect that merits a recall? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA: #23V651000 I need to know when I can get this major problem fix. This is a safety issue that needs attention. The vehicles anti-lock brake system module could leak brake fluid internally and cause an electrical short. An electrical short could result in significant overcurrent in the ABS module, increasing the risk of an …
Read full complaint
NHTSA: #23V651000 I need to know when I can get this major problem fix. This is a safety issue that needs attention. The vehicles anti-lock brake system module could leak brake fluid internally and cause an electrical short. An electrical short could result in significant overcurrent in the ABS module, increasing the risk of an engine compartment fire while driving or parked. [XXX] I was contacted took my vehicle in and was told a fuse would be ordered and I would be called back in to to get this safety issue fixed. I just spoke with the Service Manager in Terrell and he said the remedy was taken away on [XXX], one day after I was a the dealership and ALL ordered were canceled. Please see my invoice from [XXX] in attachment. This is a BIG problem for me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
It’s been happening recently everyday when going to start the car it doesn’t start and I have to pop the hood, open the fusebox cover and lift the wire attached to the fusebox and then when starting the car it starts. It’s been happening every other day and sometimes a week after.
The contact owns a 2012 Hyundai Elantra. The contact stated that the vehicle was jerking while depressing the brake pedal. The check engine warning light was illuminated during the failure. The vehicle was taken to an independent mechanic and the contact was informed that there was a short circuit in the engine wiring. Additiona…
Read full complaint
The contact owns a 2012 Hyundai Elantra. The contact stated that the vehicle was jerking while depressing the brake pedal. The check engine warning light was illuminated during the failure. The vehicle was taken to an independent mechanic and the contact was informed that there was a short circuit in the engine wiring. Additionally, the contact stated that the steering wheel was shaking while driving above 50 MPH. The contact then received notification of NHTSA Campaign Number: 23V651000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 135,000. VIN tool confirms parts not available.
I complied with Hyundai's voluntary recall of my 2012 Elantra, supposedly designed to deter theft with some sort of software update. Four weeks after this, four teenager rolled up to my house in a stolen Hyundai Sonata. One of them jumped out of the car, smashed my car's back window, and stole my car. This whole process took pl…
Read full complaint
I complied with Hyundai's voluntary recall of my 2012 Elantra, supposedly designed to deter theft with some sort of software update. Four weeks after this, four teenager rolled up to my house in a stolen Hyundai Sonata. One of them jumped out of the car, smashed my car's back window, and stole my car. This whole process took place in broad daylight, in front of multiple witnesses, over approximately 30 seconds. I contend that Hyundai's "voluntary recall" was 1) fraudulent, in that it does not do anything to fix the actual problem; 2) dangerous, in that it led owners to believe their car was safe when it fact it was not; and 3) a waste of taxpayers' time, as it caused me to take several hours off of work. Hyundai should be compelled to 1) ACTUALLY fix these vehicles; 2) compensation any Hyundai owners whose vehicles were stolen. While I have insurance protection on this vehicle, I will almost certainly need to pay more money than that to replace this car with one of comparable utility to me.
Please find below a description of the malfunction in my Hyundai Elantra, as this is the reason I'm requesting inclusion in a recall. Since the week of Thanksgiving 2022, I've had several instances of my vehicle stalling without warning before engaging the transmission; for example, my car once stopped moving completely on the …
Read full complaint
Please find below a description of the malfunction in my Hyundai Elantra, as this is the reason I'm requesting inclusion in a recall. Since the week of Thanksgiving 2022, I've had several instances of my vehicle stalling without warning before engaging the transmission; for example, my car once stopped moving completely on the freeway while entering the onramp at 55 mph. Since then, the problem has only gotten worse, stalling up to seven or nine times per week. Because of the severity of this issue, I’ve had it inspected multiple times and would gladly submit it to another one if requested. Obviously, a defect of this magnitude with no obvious cause not only puts me at risk as the driver, as I can’t prepare for a sudden stop, but all road travelers around me are also subject to this issue. As you know, a sudden halt could lead to collusion involving numerous people. To date, an independent service provider has not been able to identify the issue or recreate the problem, as it occurs randomly with no warning lights or signals to prepare me for what’s about to happen. Should you need further details, I may be reached at [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Official recalls
423V651000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
20V393000 · Equipment:electrical
Jul 2, 2020
Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air compressor to inflate a tire.
Consequence & remedy
Consequence: An overheated accessory outlet increases the risk of fire.
Remedy: Hyundai will notify owners, and dealers will replace the Tire Mobility Kit accessory outlet plug with a direct-to-battery connection wire harness kit, free of charge. The recall began September 28, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 193.
15V871000 · Electronic Stability Control (esc)
Dec 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Elantra vehicles manufactured October 29, 2010, to October 25, 2011. Due to an electronic stability control (ESC) sensor malfunction, the brakes for one or more wheels may be applied unexpectedly and the engine power may be reduced. These symptoms will be accompanied by illumination of the ESC indicator lamp in the instrument cluster.
Consequence & remedy
Consequence: If the one or more of the brakes are inappropriately applied, control of the vehicle may be lost, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will verify the proper operation of the ESC sensors, and update the ESC system's calibration, free of charge. The recall began June 6, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 137.
13V115000 · Air Bags:side/window; Structure
Apr 1, 2013
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence & remedy
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Additional source detail variants (2)
Structure
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Air Bags:side/window
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
EA12008 · Headliner Bracket Detachment
Opened Sep 13, 2012 · Closed Dec 9, 2013
Status: closed (inferred from source dates) · Air Bags:side/window; Structure:body:roof And Pillars; Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (3)
Air Bags:side/window
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Structure:body:roof And Pillars
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
PE12012 · Side Curtain Air Bag Improper Deployment
Opened May 10, 2012 · Closed Sep 17, 2012
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (2)
Air Bags
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Air Bags:side/window
The Office of Defects Investigation (ODI) is aware of one incident of an improper deployment of the driver-side curtain air bag that deployed as a result of a crash involving a model year (MY) 2012 Hyundai Elantra.An inspection of this vehicle showed that a metal bracket (stiffener) in the headliner assembly had detached and was forced downward by the deploying air bag.The metal bracket caused a laceration to the driver's ear and other possible injuries.Approximately 75,000 MY 2012 Hyundai Elantra vehicles, built in Korea and sold in the U.S., have stiffeners in the headliners while the MY 2012 Elantra vehicles built in the U.S. utilize a different headliner that does not use a stiffener. Thus, the latter vehicles are not included in this investigation.Hyundai has inspected the headliner assemblies from eight Elantra vehicles (which were sold in the Korean market) with production dates in the same range as the field incident vehicle.Hyundai reported to ODI that the metal brackets from these vehicles were found to be securely attached to the headliners.Hyundai also has conducted several static deployment tests in attempts to replicate the field incident. In one test, the metal bracket detached from the headliner but the test condition did not replicate or explain the condition observed in the incident vehicle.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-008) to further assess whether incidents like the single field incident could potentially occur with other subject vehicles.In addition to the subject vehicles, ODI also will collect and review information on MY 2011 and 2013 Elantra vehicles that have headliners with stiffeners similar to those in the subject vehicles. To date, there have been no reports on the MY 2011 and 2013 vehicles.The ODI report cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696