NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
92 reportsClear category filter114,000 miles · Oct 27, 2018
Engine
I HAD MY CAR FOR A YEAR. WHEN I FIRST GOT MY CAR , THERE WAS A KNOCKING NOISE THAT CAME FROM THE ENGINE , I TOOK IT BACK TO CARMAX TO FIX AND THEY STATED THEY DID. MY CAR RAN GOOD FOR A WHILE AND AROUND AUGUST OR SEPTEMBER AFTER LEAVING FROM WORK THAT SAME NOISE STARTED AGAIN. THIS TIME IT WAS BAD AND I ALMOST GOT INTO A WRECK. …
Read full complaint
I HAD MY CAR FOR A YEAR. WHEN I FIRST GOT MY CAR , THERE WAS A KNOCKING NOISE THAT CAME FROM THE ENGINE , I TOOK IT BACK TO CARMAX TO FIX AND THEY STATED THEY DID. MY CAR RAN GOOD FOR A WHILE AND AROUND AUGUST OR SEPTEMBER AFTER LEAVING FROM WORK THAT SAME NOISE STARTED AGAIN. THIS TIME IT WAS BAD AND I ALMOST GOT INTO A WRECK. I TOOK IT TO A MECHANIC THEY STATED THAT I NEEDED MY ENGINE REPLACED. I HAVE SEEN THAT THIS IS A ONGOING ISSUE WITH THESE MODELS. I ALSO SHOW THAT THERE IS A RECALL ON MY VEHICLE AND MY CAR IS SHOWING THOSE EXACT SIGNS. I HAVE DOCUMENTATION OF INFORMATION FROM THE MECHANIC AND THE COST OF THE LABOR AND NEW ENGINE
NHTSA ODI #11143369
180,000 miles · Oct 17, 2018
Engine
CAR WAS BEING DRIVEN IN THE HIGHWAY WHEN THE CAR STALLED. OIL FLOW IS MALFUNCTIONING IN THE ENGINE CAUSING ROD PROBLEMS. ACCORDING TO DEALERSHIP IT'S A KNOWN PROBLEM FOR THIS MAKE AND MODEL. I AM TOLD THAT THE ENGINE RODS ARE BAD AND THE ENGINE NEEDS TO BE REPLACE. I CONTACTED THE WARRANTY COMPANY HOWEVER THEY REFUSED TO COVER T…
Read full complaint
CAR WAS BEING DRIVEN IN THE HIGHWAY WHEN THE CAR STALLED. OIL FLOW IS MALFUNCTIONING IN THE ENGINE CAUSING ROD PROBLEMS. ACCORDING TO DEALERSHIP IT'S A KNOWN PROBLEM FOR THIS MAKE AND MODEL. I AM TOLD THAT THE ENGINE RODS ARE BAD AND THE ENGINE NEEDS TO BE REPLACE. I CONTACTED THE WARRANTY COMPANY HOWEVER THEY REFUSED TO COVER THE REPAIR DUE TO TIRE ROTATIONS AND SPARK PLUGS PURCHASED AT THE DEALERSHIP AND WAS REPLACED PERSONALLY.
NHTSA ODI #11140799
90,000 miles · Oct 8, 2018
Electrical SystemEngine
POSSIBLE CRANKSHAFT ANGLE SENSOR FAILURE. CAR WILL NOT START PROPERLY OR STALLS AFTER STARTING AND SHIFTING GEARS. NEW BATTERY INSTALLED 9/29/2018. NO SPARK PLUGS OR ALTERNATOR ISSUES NOTED AFTER MECHANICAL TESTING. THERE SHOULD BE A RECALL FOR THIS PROBLEM AS MOST MECHANICS CANNOT LOCATE THE ISSUE IN TESTING.
NHTSA ODI #11139063
68,000 miles · Sep 13, 2018
Electrical SystemEngineUnknown Or Other
VEHICLE RANDOMLY DOES NOT START. WHEN KEY IS TURNED TO POSITION ONE LIGHTS, RADIO, WINDOWS, INDICATOR LIGHTS ALL WORK AS EXPECTED. WHEN KEY IS TURNED TO START THE ENGINE NOTHING HAPPENS. THE ENGINE DOES NOT TURNOVER OR EVEN ATTEMPT TO TURNOVER. THE BATTERY WAS REPLACED THE FIRST TIME THIS HAPPENED IN APRIL 2018. AT THAT TIME I H…
Read full complaint
VEHICLE RANDOMLY DOES NOT START. WHEN KEY IS TURNED TO POSITION ONE LIGHTS, RADIO, WINDOWS, INDICATOR LIGHTS ALL WORK AS EXPECTED. WHEN KEY IS TURNED TO START THE ENGINE NOTHING HAPPENS. THE ENGINE DOES NOT TURNOVER OR EVEN ATTEMPT TO TURNOVER. THE BATTERY WAS REPLACED THE FIRST TIME THIS HAPPENED IN APRIL 2018. AT THAT TIME I HAD THE ALTERNATOR AND STARTER CHECKED BOTH WERE FUNCTIONING PROPERLY. AFTER REPEATED ATTEMPTS TO START THE VEHICLE IT HAS ALWAYS STARTED, EVENTUALLY; IT CAN TAKE ANYWHERE FROM 2 MINUTES TO 30+ MINUTES FOR THE ENGINE TO ENGAGE. WHEN IT FIRST STARTED OCCURRING IT HAPPENED PRETTY OFTEN. PRIOR TO LAST FRIDAY IT HAD BEEN A COUPLE MONTHS SINCE IT TOOK MORE THAN 30 MINUTES TO START. I TOOK THE VEHICLE TO ANOTHER MECHANIC YESTERDAY. AGAIN STARTER, BATTERY, ALTERNATOR ARE ALL FUNCTIONING PROPERLY. THE MECHANIC MENTIONED THAT THIS MODEL IS KNOWN TO HAVE ISSUES WITH THE IGNITION AND THAT I SHOULD CONTACT THE DEALERSHIP, THEY MAY KNOW WHAT IT IS EXACTLY. I'VE CALLED TWO DEALERSHIPS TODAY, BOTH SAY THEY KNOW NOTHING ABOUT IGNITION PROBLEMS IN THE VEHICLE.
NHTSA ODI #11129291
Mileage unknown · Sep 8, 2018
Engine
THE CAR MAKES A REALLY BAD TICKING NOISE IN WHEN I CAME TO AN COMPLETE STOP THE ENGINE STALLED IN IT KINDA JUMPED LIKE IT DIDN'T WANT TO GO I'M SO AFRAID OF THE CAR JUS COMPLETELY NOT WORKING ANYMORE IN I DRIVE EVERYDAY WITH MY KIDS THIS IS REALLY A SAD THING HYUNDAI HAS TO KNOW THESE ENGINES ARE BAD.
NHTSA ODI #11128284
96,866 miles · Aug 13, 2018
Electrical SystemEngineService Brakes
TL* THE CONTACT OWNS A 2011 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE ENGINE STALLED WHILE DRIVING VARIOUS SPEEDS. ALSO, THE FRONT AND REAR BRAKES FAILED INTERMITTENTLY. FURTHERMORE, THE ELECTRICAL SYSTEM WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2011 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE ENGINE STALLED WHILE DRIVING VARIOUS SPEEDS. ALSO, THE FRONT AND REAR BRAKES FAILED INTERMITTENTLY. FURTHERMORE, THE ELECTRICAL SYSTEM WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 96,866.
NHTSA ODI #11119576
39,000 miles · Jul 18, 2018
Engine
BOUGHT THIS CAR USED IN 2014 WITH APPROX 24,000 MILES. RAN GREAT FIRST 2 YEARS BUT AT APPROX 39,000 MILES A VERY LOUD ENGINE KNOCK DEVELOPED AND HAS EFFECTED THE ENGINE PERFORMANCE. THIS ISSUE IS PRESENT AT START UP, IDLE, IN MOTION, EACH TIME THE CAR IS RUNNING. HYUNDAI SERVICE MYSTERIOUSLY COULD NOT HEAR OR DIAGNOSE THE PROB…
Read full complaint
BOUGHT THIS CAR USED IN 2014 WITH APPROX 24,000 MILES. RAN GREAT FIRST 2 YEARS BUT AT APPROX 39,000 MILES A VERY LOUD ENGINE KNOCK DEVELOPED AND HAS EFFECTED THE ENGINE PERFORMANCE. THIS ISSUE IS PRESENT AT START UP, IDLE, IN MOTION, EACH TIME THE CAR IS RUNNING. HYUNDAI SERVICE MYSTERIOUSLY COULD NOT HEAR OR DIAGNOSE THE PROBLEM. ENGINE KNOCK HAS CONTINUED GET WORSE AND POWER HAS DIMINISHED. THE ENGINE HAS NOT YET FAILED BUT MOST CERTAINLY WILL VERY SOON. MY FAMILY IS AT RISK EACH AND EVERY TIME WE USE THIS CAR. THE ENGINE PROBLEMS ARE SIMILAR TO THE SONATA'S AND SANTA FE'S AS WELL AS THE KIA OPTIMA MODELS FROM 2011 THRU 2014 WHICH WERE PART OF A CLASS ACTION LAWSUIT AFTER WHICH THERE WAS A ENGINE RECALL. MY UNDERSTANDING IS THAT HYUNDAI HAS EXTENDED WARRANTY TO USED ELANTRA MODELS TO 5 YEARS AND 60,000 MILES. AT THIS POINT WE HAVE ONLY 56,000 MILES BUT THE CAR IS 7 YEARS OLD. THEY HAVE A KNOWN MANUFACTURING PROBLEM AND ARE NOT OWNING IT FOR ALL AFFECTED AND THAT'S CATASTROPHIC FOR THOSE OF US NOT COVERED. DEALER HAS TOLD ME IF I HAVE ENGINE FAILURE THE COST OF A NEW ENGINE WILL BE NEAR $5000. HYUNDAI MAKES ATTRACTIVE CARS BUT THEIR LACK OF COMPASSION TO THE VICTIMS OF THEIR POOR MANUFACTURING PROCESS MAKES HYUNDAI A POOR CHOICE. THERE HAVE BEEN CLASS ACTION SUITS FOR THE SONATA AND OPTIMA BUT NO JUDGEMENT FOR THE BENEFIT OF ELANTRA MOTORS WHO'S ENGINES SUFFER THE EXACT SAME ISSUES. THERE WAS A WHISTLE BLOWER WHO OPENED THIS ALL UP AND SAID THE JUDGEMENT WAS NOT FAR REACHING ENOUGH TO COVER ALL VICTIMS. HTTPS://WWW.REUTERS.COM/ARTICLE/US-HYUNDAI-WHISTLEBLOWER/BLOWING-THE-WHISTLE-IN-SOUTH-KOREA-HYUNDAI-MAN-TAKES-ON-CHAEBOL-CULTURE-IDUSKCN18B0J5 SOMEONE LIKE THE NHTSA HAS TO STEP UP AND PROTECT THE CONSUMERS WHO HAVE FALLEN VICTIM TO THIS CORPORATE MALFEASANCE.
NHTSA ODI #11112136
120,000 miles · Jun 7, 2018
EngineSuspensionUnknown Or Other
MY CAR HAS MAKING NOISE FOR A WHILE. EMAILED HYUNDAI AND WAS TOLD IT IS NOT UNDER WARRANTY AND NO RECALL FOR ENGINE. SEVERAL COMPLAINTS HA E BEEN MADE ONLINE FOR THIS CAR REGARDING THE ENGINE WHICH NEEDS TO BE REPLACED. I'M AFRAID TO DRIVE IT'S MY ONLY CAR AND I CAN'T AFFORD TO PAY $5000 FOR A NEW ENGINE. I WAS STUCK IN THE MI…
Read full complaint
MY CAR HAS MAKING NOISE FOR A WHILE. EMAILED HYUNDAI AND WAS TOLD IT IS NOT UNDER WARRANTY AND NO RECALL FOR ENGINE. SEVERAL COMPLAINTS HA E BEEN MADE ONLINE FOR THIS CAR REGARDING THE ENGINE WHICH NEEDS TO BE REPLACED. I'M AFRAID TO DRIVE IT'S MY ONLY CAR AND I CAN'T AFFORD TO PAY $5000 FOR A NEW ENGINE. I WAS STUCK IN THE MIDDLE OF A BUSY INTERSECTION WHEN THE CAR STALLED AND SOUNDED LIKE IT WAS GOING TO GRIND THE ENGINE UP.
NHTSA ODI #11100444
82,000 miles · May 11, 2018
Engine
TL* THE CONTACT OWNED A 2011 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE MADE AN ABNORMAL TAPPING NOISE. THE VEHICLE WAS TAKEN TO WINNER HYUNDAI (591 S DUPONT HWY, DOVER, DE 19901) WHERE IT WAS DIAGNOSED THAT A NEW ENGINE WAS NEEDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT …
Read full complaint
TL* THE CONTACT OWNED A 2011 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE MADE AN ABNORMAL TAPPING NOISE. THE VEHICLE WAS TAKEN TO WINNER HYUNDAI (591 S DUPONT HWY, DOVER, DE 19901) WHERE IT WAS DIAGNOSED THAT A NEW ENGINE WAS NEEDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TRADED IN; THEREFORE, THE CONTACT NO LONGER OWNS THE VEHICLE. THE FAILURE MILEAGE WAS 82,000.
NHTSA ODI #11093355
85,000 miles · Apr 24, 2018
EngineFire
TL* THE CONTACT OWNS A 2011 HYUNDAI ELANTRA. THE CONTACT NOTICED AN ODOR OF ANTIFREEZE COMING THROUGH THE AIR CONDITIONING VENTS WHILE DRIVING AT AN UNKNOWN SPEED. THE CONTACT PULLED THE VEHICLE OVER AFTER NOTICING SMOKE COMING FROM THE ENGINE. THE VEHICLE WAS TOWED TO PIAZZA HYUNDAI OF POTTSTOWN (84 AUTOPARK BLVD, LIMERICK, PA …
Read full complaint
TL* THE CONTACT OWNS A 2011 HYUNDAI ELANTRA. THE CONTACT NOTICED AN ODOR OF ANTIFREEZE COMING THROUGH THE AIR CONDITIONING VENTS WHILE DRIVING AT AN UNKNOWN SPEED. THE CONTACT PULLED THE VEHICLE OVER AFTER NOTICING SMOKE COMING FROM THE ENGINE. THE VEHICLE WAS TOWED TO PIAZZA HYUNDAI OF POTTSTOWN (84 AUTOPARK BLVD, LIMERICK, PA 19468 (484) 933-4074) WHERE THE CONTACT WAS ADVISED THAT THE ENGINE BLOCK NEEDED TO BE REPLACED; HOWEVER, THE LONG ENGINE BLOCK WAS NO LONGER BEING MADE BY HYUNDAI AND THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE CONTACT INQUIRED ABOUT HYUNDAI BUYING BACK THE VEHICLE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 85,000.
NHTSA ODI #11089856
Official recalls
5Sep 22, 2023
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Consequence & remedy
Consequence: An engine compartment fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the ABS fuse, free of charge. Owner notification letters were mailed April 10, 2024 through October 11, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 251.
Jul 2, 2020
Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air compressor to inflate a tire.
Consequence & remedy
Consequence: An overheated accessory outlet increases the risk of fire.
Remedy: Hyundai will notify owners, and dealers will replace the Tire Mobility Kit accessory outlet plug with a direct-to-battery connection wire harness kit, free of charge. The recall began September 28, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 193.
Dec 23, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011-2012 Elantra vehicles manufactured October 29, 2010, to October 25, 2011. Due to an electronic stability control (ESC) sensor malfunction, the brakes for one or more wheels may be applied unexpectedly and the engine power may be reduced. These symptoms will be accompanied by illumination of the ESC indicator lamp in the instrument cluster.
Consequence & remedy
Consequence: If the one or more of the brakes are inappropriately applied, control of the vehicle may be lost, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will verify the proper operation of the ESC sensors, and update the ESC system's calibration, free of charge. The recall began June 6, 2016. Owners may contact Hyundai customer service at 1-800-633-5151. Hyundai's number for this recall is 137.
Oct 7, 2015
Hyundai Motor America (Hyundai) is recalling certain model year 2011 Elantra vehicles manufactured November 12, 2010, to March 31, 2011, and Sonata vehicles manufactured December 11, 2009, to February 28, 2010, originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt may corrode the front coil springs, possibly resulting in the coil springs fracturing.
Consequence & remedy
Consequence: If a front coil spring fractures, it may contact the tire, possibly puncturing it, increasing the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the front coil springs, free of charge. Interim notifications were mailed on November 17, 2015. The recall began on January 6, 2016. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 133. Note: Vehicles that were previously registered in salt belt states but are currently registered elsewhere are eligible to be inspected and repaired.
Apr 1, 2013
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence & remedy
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Additional source detail variants (2)
Structure
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Air Bags:side/window
Hyundai Motor Company is recalling certain model year 2011-2013 Elantra vehicles manufactured from November 12, 2010, through March 5, 2013. A support bracket attached to the headliner may become displaced during a side curtain airbag deployment.
Consequence: If the headliner support bracket makes contact with an occupant during a crash, it may cause a laceration injury.
Remedy: Hyundai will notify owners, and dealers will apply adhesive strips to the headliner, free of charge. The safety recall began during April 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 109.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
EA12008 · Headliner Bracket Detachment
Opened Sep 13, 2012 · Closed Dec 9, 2013
Status: closed (inferred from source dates) · Air Bags:side/window; Structure:body:roof And Pillars; Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Additional source detail variants (3)
Air Bags:side/window
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Structure:body:roof And Pillars
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Unknown Or Other
In March 2013, Hyundai issued a safety recall to reinforce the attachment of the metal support brackets to the headliner assembly in approximately 186,254 model year 2011-2013 Hyundai Elantra vehicles built in Korea and sold in the U.S. (see NHTSA recall 13V-115 for more information).The recall covers vehicles built up to March 5, 2013.After that date, Hyundai began using headliners with reinforced bracket attachments in the Korea-built Elantra vehicles.ODI has opened a Recall Query (RQ13-004) to investigate model year 2009-2012 Hyundai Elantra Touring vehicles.During EA12-008, ODI found these vehicles are equipped with a support bracket design and layout similar to that in the above-mentioned Elantra vehicles.Also, the headliner manufacturing processes used were similar for both models.Like the Elantra vehicles built before the recall, the Elantra Touring model headliner does not contain reinforced bracket attachments.This Engineering Analysis is closed.See attached report for additional information.The ODI report cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification number: 10457696
Illustration