IN FEBRUARY 2014 A FRIEND TRIED TO ENTER THE CAR AND THE DOOR HANDLE PULLED OFF IN HER HAND. THE DOOR WAS NOT LOCKED WHILE SHE WAS TRYING TO OPEN IT. THE CAR HAD APPROX. 31,000 MILES ON IT. THIS WAS A FRONT DOOR HANDLE. ON APRIL 20, 2015 (THE CAR HAS LESS THAN 45,000 MILES ON IT) MY DAUGHTER WENT TO REMOVE HER CHILD FROM TH…
Read full complaint
IN FEBRUARY 2014 A FRIEND TRIED TO ENTER THE CAR AND THE DOOR HANDLE PULLED OFF IN HER HAND. THE DOOR WAS NOT LOCKED WHILE SHE WAS TRYING TO OPEN IT. THE CAR HAD APPROX. 31,000 MILES ON IT. THIS WAS A FRONT DOOR HANDLE. ON APRIL 20, 2015 (THE CAR HAS LESS THAN 45,000 MILES ON IT) MY DAUGHTER WENT TO REMOVE HER CHILD FROM THE REAR CAR SEAT. THE DOOR WAS NOT LOCKED AND THE REAR DOOR HANDLE PULLED OFF IN HER HAND. I HAVE BEEN WATCHING THE NEWS WERE SOMEONE IS PULLING A PASSENGER OUT OF A BURNING CAR AFTER AN ACCIDENT OFTEN. IF THE DOOR HANDLE WOULD HAVE PULLED OFF DURING THESE INCIDENTS, THE DRIVER OR PASSENGERS WOULD HAVE BEEN BURNT ALIVE. *TR
NHTSA ODI #10711884
27,445 miles · Dec 17, 2014
StructureInjury
THE PLASTIC CHROME ON THE INSIDE PASSENGER DOOR HANDLE IS "DELAMINATED" AND A RAZOR SHARP EDGE IS EXPOSED. WHEN I REACHED ACROSS THE SEAT (FROM THE DRIVERS SIDE) TO OPEN TO PASSENGER DOOR, THE SHARP EDGE DEEPLY CUT MY FINGER WHICH HAD TO HAVE PRESSURE FOR ABOUT THREE HOURS BEFORE IT WOULD STOP BLEEDING. THIS CAR ONLY HAS 27K…
Read full complaint
THE PLASTIC CHROME ON THE INSIDE PASSENGER DOOR HANDLE IS "DELAMINATED" AND A RAZOR SHARP EDGE IS EXPOSED. WHEN I REACHED ACROSS THE SEAT (FROM THE DRIVERS SIDE) TO OPEN TO PASSENGER DOOR, THE SHARP EDGE DEEPLY CUT MY FINGER WHICH HAD TO HAVE PRESSURE FOR ABOUT THREE HOURS BEFORE IT WOULD STOP BLEEDING. THIS CAR ONLY HAS 27K MILES AND RARELY SEES SOMEONE IN THE PASSENGER SEAT SO THIS IS NOT DUE TO EXTENSIVE USE AS STATED IN PREVIOUS RECALLS FOR THIS PROBLEM. IF THE PROBLEM WAS IDENTIFIED AND RECALLED IN 2009 THEN WHY IS IT STILL A PROBLEM IN 2014? THIS CAR WAS IN FOR SERVICE AND A NON-RELATED WARRANTY FIX LAST MONTH AND NOTHING WAS SAID ABOUT THIS PROBLEM (AND SUBSEQUENTLY, THE DEALER WAS NOT INSPECTING FOR THIS PROBLEM). *TR
NHTSA ODI #10664774
Mileage unknown · Aug 1, 2014
StructureInjury
THE METALLIC COVERING ON BOTH FRONT INNER DOOR HANDLES HAS RIPPLED AND STARTED PEELING. THE METALLIC SHEET COVERING BOTH HANDLES IS VERY SHARP AND HAS CAUSED ME TO SLICE MY HANDS/FINGERS MULTIPLE TIMES AS I ATTEMPT TO OPEN THE DOOR. IT'S STURDY ENOUGH THAT IT IS DIFFICULT TO JUST PEEL OFF, SO I AM CONSTANTLY BEING CUT BY MY HAND…
Read full complaint
THE METALLIC COVERING ON BOTH FRONT INNER DOOR HANDLES HAS RIPPLED AND STARTED PEELING. THE METALLIC SHEET COVERING BOTH HANDLES IS VERY SHARP AND HAS CAUSED ME TO SLICE MY HANDS/FINGERS MULTIPLE TIMES AS I ATTEMPT TO OPEN THE DOOR. IT'S STURDY ENOUGH THAT IT IS DIFFICULT TO JUST PEEL OFF, SO I AM CONSTANTLY BEING CUT BY MY HANDLES AND AM WORRIED THIS MAY SOON HAPPEN TO MY PASSENGER(S) AND/OR CHILDREN. *TR
NHTSA ODI #10618120
80,000 miles · Dec 23, 2013
Structure
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE FRONT INTERIOR DOOR HANDLES WERE FRACTURED AND BECAME INOPERATIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIM…
Read full complaint
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE FRONT INTERIOR DOOR HANDLES WERE FRACTURED AND BECAME INOPERATIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10557110
75,000 miles · Oct 1, 2013
StructureInjury
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE EXITING THE VEHICLE, SHE SUSTAINED LACERATIONS TO THE FINGERS FROM THE DRIVER'S SIDE DOOR HANDLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WA…
Read full complaint
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE EXITING THE VEHICLE, SHE SUSTAINED LACERATIONS TO THE FINGERS FROM THE DRIVER'S SIDE DOOR HANDLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 75,000.
NHTSA ODI #10546408
119 miles · Jun 26, 2013
Structure
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE TRUNK POPPED OPEN SUDDENLY AND INDEPENDENTLY. THE FAILURE RECURRED OVER FIFTEEN TIMES. THE CONTACT TOOK THE VEHICLE TO THE DEALER SEVERAL TIMES AND EACH TIME THE DEALER STATED THAT THEY COULD NOT DETERMINE A PROBLEM WITH THE LATCH. IN ADDITION, THE CONTACT …
Read full complaint
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE TRUNK POPPED OPEN SUDDENLY AND INDEPENDENTLY. THE FAILURE RECURRED OVER FIFTEEN TIMES. THE CONTACT TOOK THE VEHICLE TO THE DEALER SEVERAL TIMES AND EACH TIME THE DEALER STATED THAT THEY COULD NOT DETERMINE A PROBLEM WITH THE LATCH. IN ADDITION, THE CONTACT STATED THAT THE BATTERY FAILED TWICE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 119 AND THE CURRENT MILEAGE WAS 13,500. *TR
NHTSA ODI #10521927
2,500 miles · May 10, 2013
Structure
REAR PASSENGER SIDE DOOR CANNOT BE OPENED FROM THE OUTSIDE OR INSIDE WHEN EXTERIOR TEMPERATURES SOAR. A DOOR COMPONENT SEEMS TO SWELL. *TR
NHTSA ODI #10511441
53,000 miles · Apr 23, 2013
StructureInjury
THE DOOR HANDLE CUTS MY FINGER WHEN OPENING MY DOOR, FROM THE DRIVER'S SEAT. *TR
NHTSA ODI #10509219
64,659 miles · Mar 21, 2013
Air BagsElectrical SystemStructure
WHEN I PURCHASED THE CAR ON THE 23 OF FEBRUARY THE SALESMAN ASSURED ME NOTHING WAS WRONG WITH THIS CAR HAD ONLY HAD ONE OWNER NOTICED THAT IN THE INTERIOR OF THE CAR THERE WERE WATER RINGS AND A MOLD SUBSTANCE SALESMAN ASSURED IT WAS NOT MOLD TOOK IT BACK 2 DAYS LATER THEY REPLACED STRUTS AND AGAIN VOICED MY CONCERN ABOUT MOLD W…
Read full complaint
WHEN I PURCHASED THE CAR ON THE 23 OF FEBRUARY THE SALESMAN ASSURED ME NOTHING WAS WRONG WITH THIS CAR HAD ONLY HAD ONE OWNER NOTICED THAT IN THE INTERIOR OF THE CAR THERE WERE WATER RINGS AND A MOLD SUBSTANCE SALESMAN ASSURED IT WAS NOT MOLD TOOK IT BACK 2 DAYS LATER THEY REPLACED STRUTS AND AGAIN VOICED MY CONCERN ABOUT MOLD WAS ASSURED AGAIN IT WAS NOT TOOK IT BACK ON 13 OF MARCH THE OWNER CALLED AND ADVISED ME TO PICK UP CAR STATED THEY HAD SOME ONE COME OUT AND INSPECT THE CAR AND THEY DETERMINED IT WAS NOT MOLD WHEN ASK FOR A COPY OF DOCUMENT WAS TOLD INSPECTOR REFUSED TO LEAVE ONE. ESC LIGHT KEPT COMING ON SALES MANAGER INSTRUCTED SERVICE DEPT NOT TO TOUCH MY CAR GOT TEST RUN TO CHECK FOR REPORTS ON ESC IT CAME BACK WITH 2 CODE C1260(STEERING SENSOR)THE OTHER B1322(AIRBAG CONTROL)WAS TOLD IF IT CAME BACK ON TO BRING IT BACK.I HAVE TRIED TO GET THESE ISSUES CORRECTED ON MORE THAT 4 OCCASIONS THE OWNER DIDN'T SEE A PROBLEM WITH THE WAY I WAS TREATED .MOLD IS A HEALTH HAZARD I USE MY CAR FOR WORK. I AM IN HOME HEALTH AND DRIVE THE ELDERLY AROUND THIS IS VERY UNHEALTHY AND I THINK THE DEALERSHIP SHOULD CORRECT THIS AT THEIR COST. *TR
NHTSA ODI #10503997
Mileage unknown · Apr 25, 2011
SteeringStructure
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE WOULD PULL VIOLENTLY TO THE LEFT OR RIGHT WHILE DRIVING. IN ADDITION, THE CONTACT STATED THAT HE WOULD GET SHOCKED WHENEVER HE WOULD OPEN THE DOORS. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE BUT DECIDED TO PERFORMED …
Read full complaint
TL* THE CONTACT OWNS A 2010 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE VEHICLE WOULD PULL VIOLENTLY TO THE LEFT OR RIGHT WHILE DRIVING. IN ADDITION, THE CONTACT STATED THAT HE WOULD GET SHOCKED WHENEVER HE WOULD OPEN THE DOORS. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE BUT DECIDED TO PERFORMED AN ALIGNMENT TO TEMPORARILY REMEDY THE PROBLEM. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 0 AND THE CURRENT MILEAGE WAS 14,000.
Hyundai Motor America (Hyundai) is recalling certain 2007-2010 Elantra and 2009-2011 Elantra Touring vehicles. On February 21, 2020 Hyundai expanded the recall to include 46,425 model year 2007-2008 Entourage and 2007 Santa Fe vehicles. Moisture may enter the Anti-lock Brake (ABS) Module and result in an electrical short.
Consequence & remedy
Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.
Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began April 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 188.
Hyundai Motor America (Hyundai) is recalling certain model year 2008-2010 Elantra vehicles manufactured June 1, 2008, to April 30, 2010, and 2009-2010 Elantra Touring vehicles manufactured November 1, 2008, to April 30, 2010. The electronic power steering (EPS) electronic control unit (ECU) may sense a discrepancy in the steering input signals and, as a result, disable the steering power assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Hyundai will verify the proper operation of the Electronic Power Steering (EPS) and update the EPS control unit, free of charge. The recall began April 14, 2015. Owners may contact Hyundai customer service at 1-855-671-3059. Hyundai's number for this recall is 127.
Hyundai Motor Company (Hyundai) is recalling certain model year 2006-2009 Accent, model year 2007-2011 Azera, Sonata and Sante Fe,2006-2011 Tucson, 2009-2011 Elantra Touring, 2007-2010 Elantra, 2008-2011 Veracruz, 2009-2011 Genesis, 2010-2011 Genesis Coupe, 2007-2008 Entourage, and 2006-2008 Tiburon vehicles. Originally, in April 2013, Hyundai recalled 1,059,824 model year 2007-2009 Accent and Tucson, model year 2007-2010 Elantra, model year 2007-2011 Santa Fe, model year 2008-2009 Veracruz, model year 2010-2011 Genesis Coupe, and model year 2011 Sonata vehicles. In September 2013, Hyundai informed the agency that it was adding more vehicles to this campaign, representing an additional 652,512 units. The total number of vehicles being recalled is now 1,712,336. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake transmission shift interlock feature, preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
Consequence & remedy
Consequence: Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of Park without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.
Remedy: Hyundai will notify owners, and dealers will replace the stop lamp switch, free of charge. The safety recall began on April 22, 2013. Owners may contact Hyundai at 1-800-633-5151. Hyundai's recall campaign number is 110.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
Illustration