IllustrationI WAS DRIVING TO WORK AND SUDDENLY WHILE TRYING TO CHANGE LANE THE STEERING FREEZES ON ME, THIS HAPPEN NOW FOR THE SECOND TIME.
2004 Hyundai Elantra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Hyundai Elantra do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Elantra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
1325–50K
2050–75K
1175–100K
13100–150K
4150K+
112 reports with mileage · 70 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
24 crash reports2 fire reports18 injury reports
Steering complaints
5 reportsTL* THE CONTACT OWNED A 2004 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 60 MPH, THE BRAKE PEDAL WAS DEPRESSED AND SEIZED WITHOUT WARNING AND THE STEERING WHEEL SEIZED. AS A RESULT, THE VEHICLE CRASHED INTO ANOTHER VEHICLE, SIDESWIPED A TREE, AND CRASHED INTO A SMALL DITCH. THE DRIVER SUSTAINED LACERATIONS TO THE LIVER. THE FRO…
Read full complaint
TL* THE CONTACT OWNED A 2004 HYUNDAI ELANTRA. WHILE DRIVING APPROXIMATELY 60 MPH, THE BRAKE PEDAL WAS DEPRESSED AND SEIZED WITHOUT WARNING AND THE STEERING WHEEL SEIZED. AS A RESULT, THE VEHICLE CRASHED INTO ANOTHER VEHICLE, SIDESWIPED A TREE, AND CRASHED INTO A SMALL DITCH. THE DRIVER SUSTAINED LACERATIONS TO THE LIVER. THE FRONT SEAT PASSENGER SUFFERED SEVERE INJURIES TO THE LEFT LEG AND SUSTAINED A FRACTURED COLLAR BONE. IN ADDITION, BOTH REAR SEAT OCCUPANTS SUFFERED FROM SEAT BELT BURNS TO THE RIGHT SIDE OF THE NECK AND UNDERNEATH THE STOMACH AREA. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
TL* THE CONTACT OWNS A 2004 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE RUBBER ON THE STEERING WHEEL EXHIBITED VARIOUS HOLES. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE STEERING WHEEL WOULD NEED REPLACING. THERE WERE NO RECALLS FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THE CONTACT TO TAKE THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2004 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE RUBBER ON THE STEERING WHEEL EXHIBITED VARIOUS HOLES. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE STEERING WHEEL WOULD NEED REPLACING. THERE WERE NO RECALLS FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER AND THEY WOULD INSPECT THE STEERING WHEEL. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 40,000.
HYUNDAI ELANTRA GLS 2004 (1) NO EVENTS LED UP TO FAILURES (2) BETWEEN 15000-20000 MILES IGNITION STOPPED WORKING - FIXED BY HYUNDAI AFTER WE SEVERELY NAGGED THEM FOR DAYS - CAR IS LESS THAN 18 MONTHS OLD HAS 32,000 MILES ON IT NOW CLUTCH DISK IS SUPPOSEDLY BURNED OUT- I HAVE NEVER HAD A CLUTCH BURN OUT ON ME OR ANYONE I …
Read full complaint
HYUNDAI ELANTRA GLS 2004 (1) NO EVENTS LED UP TO FAILURES (2) BETWEEN 15000-20000 MILES IGNITION STOPPED WORKING - FIXED BY HYUNDAI AFTER WE SEVERELY NAGGED THEM FOR DAYS - CAR IS LESS THAN 18 MONTHS OLD HAS 32,000 MILES ON IT NOW CLUTCH DISK IS SUPPOSEDLY BURNED OUT- I HAVE NEVER HAD A CLUTCH BURN OUT ON ME OR ANYONE I KNOW MUCH LESS AT A MERE 32,000 MILES WANT TO CHARGE ME 300 TO SEE IF WARRANTY MIGHT COVER IT; HOWEVER IF IT DOESN'T THEY WILL CHARGE ME 800 OR SO TO FIX THIS PROBLEM CAR GRINDS WHEN TURNING- HYUNDAI WILL NOT CHECK IT OUT, SUPPOSEDLY WARRANTY ALSO DOES NOT COVER THIS. STEERING WHEEL IS COMPLETELY FALLING APART VANITY MIRROR COVER FELL OFF YES, ALL THIS HAPPENED WITHIN 3 MONTHS OF EACH OTHER. I AM NOW COMPLETELY AFRAID TO DRIVE MY CAR. THE GEARS DO NOT CATCH WELL AND ARE GETTING PROGRESSIVELY WORSE. THE REASON I BOUGHT THIS CAR WAS FOR ITS AMAZING WARRANTY. COME TO FIND OUT THE WARRANTY DOESN'T COVER ANYTHING AT ALL. HYUNDAI DID REPLACE MY VANITY MIRROR. NOW IF ONLY THE FREAKING CAR WORKED! I WILL NEVER BUY ANOTHER HYUNDAI. *NM
MY NEW ELANTRA HAS CORROSION ON THE WHEEL SPINDLE THREADS AND NUT. THERE IS ALSO CORROSION ON THE WHEEL LUGS AND NUTS. I RETURNED THE CAR TO THE DEALER FOR EVALUATION,K AND WAS TOLD THAT CORROSION WAS NO PROBLEM. I REQUESTED TO SPEAK WITH THE FACTORY REPRESENTATIVE AND HAVE SO FAR BEEN IGNORED.*AK
Official recalls
505V479000 · Air Bags
Oct 17, 2005
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence & remedy
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON NOVEMBER 15, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
05V395000 · Air Bags
Sep 12, 2005
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence & remedy
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
04V370000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Jul 30, 2004
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST, IT WAS DETERMINED THAT FUEL TAN DAMAGE COULD OCCUR. ON CERTAIN PASSENGER VEHICLES, A VAPOR TUBE HOSE CLAMP THAT IS LOCATED NEAR THE FUEL TANK MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP EARS AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
04V208000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
May 3, 2004
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE HOSE CLAMP EAR AND THE FUEL TANK. THE VAPOR TUBE HOSE CLAMP EAR WAS FOUND TO BE MISPOSITIONED AND FACING TOWARD THE FUEL TANK.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, DAMAGE TO THE VEHICLE COULD CAUSE THE MISPOSITIONED CLAMP TO PUNCTURE THE FUEL TANK CAUSING FUEL LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
03V322000 · Air Bags
Aug 26, 2003
ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56.4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. HOWEVER, THE OCCUPANT CLASSIFICATION SENSOR MAY INCORRECTLY INTERPRET THAT A SEATED ADULT IS AN INFANT SEAT AND DEACTIVATE THE PASSENGER AIR BAG IF SOMEONE HEAVIER THAN 56.4 POUNDS WHO IS SEATED WITH ONE LEG RESTING ON THE OUTBOARD OR INBOARD EDGE OF THE SEAT; WITH LEGS SPREAD; OR POSITIONED OFF-CENTER TOWARD THE CENTER CONSOLE AND WITH HIS OR HER ARM LEANING ON THE CONSOLE.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.
Remedy: THE OCCUPANT CLASSIFICATION SENSOR WILL BE REPROGRAMMED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04041 · POST-CRASH Fuel Tank Leak
Opened Apr 16, 2004 · Closed Jul 13, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Fuel System, Gasoline:storage:tank Assembly
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.