TL* THE CONTACT OWNS A 2004 HYUNDAI ELANTRA. THE CONTACT STATED THAT THERE WAS A CLOUDY COVERING OVER THE EXTERIOR LIGHTS, REDUCING THE VISIBILITY OF THE CONTACTS VEHICLE. BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ASSISTANCE WITH REPAIRS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 23,000 AND THE CURRENT M…
Read full complaint
TL* THE CONTACT OWNS A 2004 HYUNDAI ELANTRA. THE CONTACT STATED THAT THERE WAS A CLOUDY COVERING OVER THE EXTERIOR LIGHTS, REDUCING THE VISIBILITY OF THE CONTACTS VEHICLE. BOTH THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ASSISTANCE WITH REPAIRS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 23,000 AND THE CURRENT MILEAGE WAS 45,000. UPDATED 09/27/11 *BF UPDATED 11/07/11
NHTSA ODI #10422404
Mileage unknown · Dec 31, 2004
Exterior Lighting
I PURCHASED A 2004 HYUNDAI ELANTRA IN SEPTEMBER 2004. I HAVE HAD LITTLE TROUBLE WITH THE VEHICLE. I DRIVE TO WORK AT 4:30 AM. ONE MORNING, I TOOK A DIFFERENT ROUTE. THERE WERE BARRIER POLES PLANTED IN THE ROAD. I DID NOT SEE THEM UNTIL THE VERY LAST MINUTE. I SWERVED TO AVOID THEM. AT THE TOLL PLAZA, THE POLICE PULLED ME …
Read full complaint
I PURCHASED A 2004 HYUNDAI ELANTRA IN SEPTEMBER 2004. I HAVE HAD LITTLE TROUBLE WITH THE VEHICLE. I DRIVE TO WORK AT 4:30 AM. ONE MORNING, I TOOK A DIFFERENT ROUTE. THERE WERE BARRIER POLES PLANTED IN THE ROAD. I DID NOT SEE THEM UNTIL THE VERY LAST MINUTE. I SWERVED TO AVOID THEM. AT THE TOLL PLAZA, THE POLICE PULLED ME TO THE SIDE AND TOLD ME MY LIGHTS WERE OFF. THE SWITCH WAS ON, BUT THERE WERE NO HEADLIGHTS. SINCE THEN, A NUMBER OF DRIVERS SIGNALED TO ME THAT MY LIGHTS WERE OFF. I WAS AGAIN STOPPED BY THE POLICE AND TOLD MY LIGHTS WERE OFF. MY LIGHT SWITCH WAS IN THE ON POSITION. I TOOK THE CAR TO THE DEALER FOR SERVICE AND THEY REPLACED THE ALTERNATOR. I STILL DO NOT FEEL THE LOW BEAM LIGHTS ARE BRIGHT ENOUGH. ANY HELP YOU COULD OFFER WOULD BE APPRECIATED. THANK YOU DIANNE C. BURGER. *AK
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence & remedy
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON NOVEMBER 15, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
CERTAIN VEHICLES EQUIPPED WITH AN ADVANCED AIR BAG SYSTEM. THE OCCUPANT CLASSIFICATION SYSTEM (OCS) INSTALLED IN THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY A CHILD RESTRAINT SEAT (CRS) AS AN ADULT. THIS MAY OCCUR IF THE CRS IS INSTALLED AFTER AN ADULT HAS BEEN SEATED IN THE RIGHT FRONT SEAT. IF THERE HAS NOT BEEN A 'KEY ON' ' KEY OFF' CYCLE WITH THE RIGHT FRONT PASSENGER SEAT EMPTY PRIOR TO INSTALLATION OF THE CRS.
Consequence & remedy
Consequence: THE POSSIBILITY OF MISCLASSIFICATION OF A CRS AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG OR SIDE IMPACT AIRBAG TO DEPLOY IN A CRASH AND COULD RESULT IN INJURY TO THE RIGHT FRONT OCCUPANT.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT (ECU) TO REMOVE THE FEATURE THAT MAY CAUSE THE CRS TO BE RECOGNIZED AS AN ADULT. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST, IT WAS DETERMINED THAT FUEL TAN DAMAGE COULD OCCUR. ON CERTAIN PASSENGER VEHICLES, A VAPOR TUBE HOSE CLAMP THAT IS LOCATED NEAR THE FUEL TANK MAY NOT BE POSITIONED PROPERLY AND COULD CAUSE FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP EARS AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) OFFSET FRONTAL BARRIER IMPACT TEST ON CERTAIN PASSENGER VEHICLES, FUEL SPILLAGE OCCURRED AS A RESULT OF FUEL TANK DAMAGE CAUSED BY CONTACT BETWEEN A VAPOR TUBE HOSE CLAMP EAR AND THE FUEL TANK. THE VAPOR TUBE HOSE CLAMP EAR WAS FOUND TO BE MISPOSITIONED AND FACING TOWARD THE FUEL TANK.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, DAMAGE TO THE VEHICLE COULD CAUSE THE MISPOSITIONED CLAMP TO PUNCTURE THE FUEL TANK CAUSING FUEL LEAKAGE. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE POSITION OF THE VAPOR TUBE HOSE CLAMP AND CORRECTLY POSITION THE CLAMP, IF NECESSARY. OWNER NOTIFICATION BEGAN ON MAY 24, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
ON CERTAIN VEHICLES, IF THE FRONT PASSENGER SEAT IS UNOCCUPIED OR IS OCCUPIED BY SOMEONE LIGHTER THAN 56.4 POUNDS, THE PASSENGER AIR BAG IS DEACTIVATED AND WILL NOT DEPLOY IF A CRASH OCCURS. HOWEVER, THE OCCUPANT CLASSIFICATION SENSOR MAY INCORRECTLY INTERPRET THAT A SEATED ADULT IS AN INFANT SEAT AND DEACTIVATE THE PASSENGER AIR BAG IF SOMEONE HEAVIER THAN 56.4 POUNDS WHO IS SEATED WITH ONE LEG RESTING ON THE OUTBOARD OR INBOARD EDGE OF THE SEAT; WITH LEGS SPREAD; OR POSITIONED OFF-CENTER TOWARD THE CENTER CONSOLE AND WITH HIS OR HER ARM LEANING ON THE CONSOLE.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE AIR BAG MAY NOT DEPLOY, POSSIBLY RESULTING IN SERIOUS INJURY TO THE RIGHT FRONT PASSENGER.
Remedy: THE OCCUPANT CLASSIFICATION SENSOR WILL BE REPROGRAMMED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Fuel System, Gasoline:storage:tank Assembly
PE04-041 WAS OPENED TO INVESTIGATE A FUEL LEAK INCIDENT THAT OCCURRED DURING AN INSURANCE INSTITUTE FOR HIGHWAY SAFETY (IIHS) FRONTAL CRASH OFFSET TEST ON THE SUBJECT VEHICLE.THIS INVESTIGATION REVEALED THAT THE VAPOR TUBE HOSE CLAMP EAR WAS MISPOSITIONED AND FACING TOWARD THE FUEL TANK, WHICH ENABLED THE VAPOR TUBE HOSE CLAMP EAR TO PUNCTURE THE FUEL TANK AND THE FUEL TANK TO LEAK STODDARD FLUID DURING THE IIHS CRASH TEST.ON APRIL 30, 2004, HYUNDAI MOTOR COMPANY (HYUNDAI) NOTIFIED NHTSA OF A SAFETY DEFECT IN CERTAIN MY 2004 ELANTRA VEHICLES PRODUCED FROM SEPTEMBER 1, 2003 THROUGH APRIL 14, 2004.THE NOTIFICATION IDENTIFIED THE MISPOSITIONING OF THE VAPOR TUBE HOSE CLAMP, WHICH RESULTED FROM AN EARLY SEPTEMBER MANUFACTURING CHANGE AT THE SUPPLIER THAT INSTALLED THE HOSE CLAMP ON THE VAPOR TUBE HOSE, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.IF THE VAPOR TUBE HOSE CLAMP IS MISPOSITIONED SO THAT ONE OF ITS EARS IS FACING THE FUEL TANK AND THAT VEHICLE IS INVOLVED IN HIGH SPEED CRASH, THE CLAMP MAY PUNCTURE THE FUEL TANK RESULTING IN FUEL LEAKAGE.FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.HYUNDAI WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POSITION OF THE VAPOR TUBE HOSE CLAMP INSPECTED AND CORRECTLY REPOSITIONED, IF NECESSARY.
Illustration