TL*THE CONTACT OWNS A 1996 HYUNDAI ELANTRA. THE VALVE STEMS ON THE VEHICLE CONSTANTLY FAIL AND CAUSE THE TIRES TO FLATTEN. WHILE DRIVING 40 MPH, THE VALVE STEM FAILED AND FLATTENED THE TIRE. ON MAY 22, 2008, WHILE DRIVING 65 MPH, THE VALVE STEM FAILED AGAIN, THE TIRE LOST AIR, AND THE REAR OF THE VEHICLE BEGAN WOBBLING. WHEN…
Read full complaint
TL*THE CONTACT OWNS A 1996 HYUNDAI ELANTRA. THE VALVE STEMS ON THE VEHICLE CONSTANTLY FAIL AND CAUSE THE TIRES TO FLATTEN. WHILE DRIVING 40 MPH, THE VALVE STEM FAILED AND FLATTENED THE TIRE. ON MAY 22, 2008, WHILE DRIVING 65 MPH, THE VALVE STEM FAILED AGAIN, THE TIRE LOST AIR, AND THE REAR OF THE VEHICLE BEGAN WOBBLING. WHEN THE CONTACT INSPECTED THE TIRES, THEY WERE FINE WITH THE EXCEPTION OF THE VALVE STEM. THE STORE FROM WHERE THE TIRES WERE PURCHASED STATED THAT THE RIM WAS BENT AND THE TIRE WAS HIS RESPONSIBILITY. FOUR VALVE STEMS WERE LOST IN FIVE WEEKS. THE CONTACT WANTED TO MAKE IT CLEAR THAT THERE IS NOTHING WRONG WITH THE TIRES, ONLY THE VALVE STEMS. THE FAILURE MILEAGE WAS 98,000. UPDATED 07/22/08 *BF UPDATED 07/29/08 *BF
NHTSA ODI #10232398
Mileage unknown · Sep 28, 2000
Tires
VEHICLE HAD BEEN PARKED, AND TIRE JUST EXPLODED. COOPER TIRE WONT DO ANYTHING.*AK (DOT NUMBER: UT8JFE7327 TIRESIZE: P175/65R14)
NHTSA ODI #732745
Mileage unknown · Jan 6, 1999
Tires
AIR IN THE TIRES KEEPS COMING OUT, CAUSING THE CONSUMER TO KEEP STOPPING AND PUTTING AIR IN THE TIRES. AIR IS COMING OUT OF THE TIRES FROM THE METAL PART ON THE RIMS. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE EVAPORATIVE EMISSION CONTROL SYSTEMS CAN APPLY EXCESSIVE VACUUM TO THE FUEL TANKS DURING THE CANISTER PURGE CYCLE. IF EXCESSIVE VACUUM IS APPLIED, MINOR FUEL TANK DISTORTION CAN RESULT. A SMALL CRACK COULD DEVELOP ON THE UPPER FUEL TANK SURFACE. THE "CHECK ENGINE" LIGHT WOULD THEN ILLUMINATE AND, IN SOME CASES, THE VEHICLE DRIVER MAY NOTICE A GASOLINE ODOR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL PRESSURE CHECK THE VEHICLE'S FUEL TANK TO DETERMINE IF IT HAS CRACKED. IF THE FUEL TANK HAS CRACKED, IT WILL BE REPLACED.
THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.
Consequence & remedy
Consequence: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
SQ00003 · Fuel Cap Replacement Campaign 36
Opened Feb 2, 2000 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
There is no summary currently available
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
There is no summary currently available
Fuel System, Gasoline:storage:tank Assembly
There is no summary currently available
PE97002 · Windshield Wiper Failure
Opened Jan 17, 1997 · Closed Feb 27, 1997
Status: closed (inferred from source dates) · Visibility
IN ITS LETTER DATED FEBRUARY 14, 1997, HYUNDAI STATED THAT APPROXIMATELY 75,000 HYUNDAI VEHICLES (CERTAIN MODEL YEAR 1996-97 ELANTRA, ACCENT, SONATA AND TIBURON MODELS BUILT THROUGH OCTOBER 18, 1996 -- SEE NHTSA RECALL NO. 97V-026 FOR DETAILS) WILL BE RECALLED FOR A DEFECT IN THE WINDSHIELD WIPER MOTOR.HYUNDAI STATED THAT THE WINDSHIELD WIPER MOTOR MAY NOT OPERATE IN COLD WEATHER CONDITIONS DUE TO CONTAMINATION OF THE MOTOR'S CIRCUIT BREAKER ELECTRICAL CONTACTS WITH SOLDERING FLUX DURING MANUFACTURING PROCESS.HYUNDAI WILL REMEDY THE DEFECT BY CLEANING THE ELECTRICAL CONTACTS TO REMOVE THE CONTAMINANTS.
Illustration