Air Bags. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports4 fire reports6 injury reports

Exterior Lighting complaints

47 reports

Clear category filter

6,100 miles · Apr 13, 2007

Exterior Lighting

Read full complaint

TL*- THE CONTACT OWNS A 2006 HYUNDAI AZERA. WHILE DRIVING THE VEHICLE DOWN A HILL AT NIGHT WITH THE LOW BEAMS ON, THERE WAS NO VISIBILITY ABOVE LIGHTED AREA. THE DEALER STATED THAT THE HEAD LIGHT'S LOW BEAM WAS DIRECTED TOO LOW. THE DEALER ADJUSTED THE HEAD LIGHTS. THE HEAD LIGHT ADJUSTMENT DID NOT SOLVE THE PROBLEM. THE DEALER INSPECTED THE VEHICLE A SECOND TIME AND STATED THE LOW BEAMS WERE POINTED IN THE RIGHT DIRECTION, AND DID NOT MAKE ANY REPAIRS. THE VEHICLE CURRENTLY HAD 61,000 MILES.

NHTSA ODI #10187783

1,800 miles · Feb 18, 2007

Electrical SystemExterior Lighting

Read full complaint

HEADLIGHTS DO NOT PROPERLY ILLUMINATE THE ROADWAY. THIS IS A SAFETY HAZARD. I ALMOST HIT A PEDESTRIAN WHILE DRIVING ON A DIMLY LIT ROAD. I COMPLAINED TO MY DEALER AND WAS ADVISED THAT THERE WAS NOTHING THEY COULD DO. THE DEALER CLAIMS THAT THE LIGHTS ARE WORKING IN ACCORDANCE WITH THE MANUFACTURES SPECIFICATIONS. IF THIS IS TRUE...THE MANUFACTURER SHOULD BE FORCED TO ADJUST THESE STANDARDS BEFORE A TRAGEDY OCCURS. THERE HAVE BEEN TWO OTHER INSTANCES WHERE THIS CONDITION NEARLY CAUSED ME TO HAVE AN ACCIDENT. *JB

NHTSA ODI #10182912

Mileage unknown · Feb 13, 2007

Exterior Lighting

Read full complaint

MY 1006 HYUNDAI AZERA HAS A DARK SHADOW COVERING PART OF THE LEFT HEADLAMP. IN NIGHT DRIVING, THIS RESULTS IN LIMITED VISION ON THE LEFT SIDE OF THE ROAD. DEALER TOLD ME THERE'S A BLACK DOT ON THE LEFT HEADLAMP WHICH IS SUPPOSED TO REDUCE GLARE OF MY HEADLIGHTS FOR ONCOMING VEHICLES. HOWEVER, THIS LIMITED VISION MAY ACTUALLY RESULT IN A COLLISION WITH A PEDESTRIAN OR VEHICLE. DEALER TOLD ME HEADLAMPS ARE SET TO SPEC AND CANNOT BE ADJUSTED. IT SEEMS TO ME, THAT MY SAFETY SHOULD SUPERSEDE THE COMFORT OF ONCOMING VEHICLES. *JB

NHTSA ODI #10182454

100 miles · Oct 25, 2006

Exterior Lighting

HEADLIGHTS ON LOW BEAM PROVIDE LESS THAN ACCEPTABLE VISIBILITY ON UNEVEN SURFACE CONDITIONS-12-30 FEET. VERY DANGEROUS. *NM

NHTSA ODI #10171773

3,200 miles · Oct 19, 2006

Engine And Engine CoolingEquipmentExterior Lighting

DT*: THE CONTACT STATED WHILE TRAVELING OVER BUMPS THERE WAS A RATTLE UNDER THE VEHICLE. ALTHOUGH THE VEHICLE WAS INSPECTED BY THE DEALERSHIP MULTIPLE TIMES, THE PROBLEM WAS NOT DETERMINED. THE CONSUMER STATED HESITATION WHILE PULLING ONTO THE HIGHWAY AND HEADLIGHTS ON VEHICLE HAVE DARK SPOTS HARD TO SEE. THE DEALER STATED LOO…

Read full complaint

NHTSA ODI #10171319

5,500 miles · Aug 15, 2006

Exterior Lighting

DT*: THE CONTACT STATED WHILE DRIVING AT ANY SPEED DURING THE NIGHT, THE HEADLIGHTS ONLY PROVIDED 30 FEET OF ILLUMINATION. AFTER THE 30 FOOT DISTANCE, THERE WAS A DISTINCT SHADOW. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER ADJUSTED THE ALIGNMENT OF THE HEADLIGHTS BUT THE PROBLEM PERSISTED. UPDATED 09/13/06. …

Read full complaint

NHTSA ODI #10165524

5,000 miles · Jul 11, 2006

Exterior Lighting

Read full complaint

DT: THE CONTACT STATED 30 FEET AHEAD OF THE VEHICLE THE HIGHLIGHTS ARE BRIGHT HOWEVER THERE IS A DISTINCT SHADOW BEYOND THAT DISTANCE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADJUSTED THE HEADLIGHTS ACCORDING TO THE SPECIIFICATIONS AND DETERMINED THE VEHICLE WAS OPERATING NORMALLY. THE MANUFACTURER WAS ALERTED. THE CONTACT OBSERVED IN A CONSUMER'S GUIDE THAT THE PERFORMANCE OF THE HIGHLIGHTS OF THE VEHICLE'S YEAR, MAKE AND MODEL IS GOOD BUT THE LOW BEAMS HAVE A DISTINCT LIGHT CUT OFF AT THE TOP.

NHTSA ODI #10162106

Official recalls

18V026000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Jan 9, 2018

Hyundai Motor America (Hyundai) is recalling certain 2006-2011 Hyundai Azera and 2006 Hyundai Sonata vehicles. Water may enter the Anti-lock Brake (ABS) Module and result in an electrical short .

Consequence & remedy

Consequence: An electrical short within the ABS Module may cause an engine compartment fire, even when the car is turned off, increasing the risk of an injury.

Remedy: Hyundai will notify owners, and dealers will install a relay in the vehicle's main junction box to prevent the risk of an ABS short-circuit while the car is turned off, free of charge. The recall began on February 19, 2018. Owners may call Hyundai at 1-800-633-5151. Hyundai's number for this recall is 172.

13V354000 · Suspension:rear

Aug 12, 2013

Hyundai is recalling certain model year 2006-2010 Sonata vehicles manufactured March 1, 2005, through January 21, 2010; and model year 2006-2011 Azera vehicles manufactured September 27, 2005, through November 22, 2010 originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Road salt and water can enter portions of the rear crossmember, leading to corrosion of the crossmember steel. This may lead to detachment of one of the rear control arms.

Consequence & remedy

Consequence: Control arm separation may suddenly change the rear wheel alignment, affecting the handling of the vehicle, increasing the risk of a crash.

Remedy: Hyundai will notify owners, and dealers will repair or replace the crossmember assembly. The recall began on October 8, 2013. Owners may contact Hyundai Customer Care Center at 1-800-633-5151. Hyundai's recall number is 113.

10V007000 · Air Bags:frontal; Seat Belts:front

Jan 8, 2010

HYUNDAI DE PUERTO RICO IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 AZERA VEHICLES MANUFACTURED FROM SEPTEMBER 27, 2005, THROUGH OCTOBER 1, 2008. THE WIRING HARNESS FOR THE RIGHT FRONT SEAT BELT TENSION SENSOR MAY SUSTAIN DAMAGE AFTER REPEATED USE OF THE SEAT BELT. IF THE SEAT BELT TENSION SENSOR WIRING BECOMES DAMAGED THE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH NECESSITATING FRONT AIR BAG DEPLOYMENT.

Consequence & remedy

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL INSPECT AND REPLACE THE RIGHT FRONT SEAT BELT AND INSTALL A NEW SEAT BELT TENSION SENSOR WIRING HARNESS CLIP, IF NECESSARY, AND REROUTE THE RIGHT FRONT SEAT BELT TENSION SENSOR WIRING AND SECURE THE WIRING WITH A NEW HARNESS CLIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 8, 2010. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO 1-787-999-3333.

Additional source detail variants (2)

Seat Belts:front

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL INSPECT AND REPLACE THE RIGHT FRONT SEAT BELT AND INSTALL A NEW SEAT BELT TENSION SENSOR WIRING HARNESS CLIP, IF NECESSARY, AND REROUTE THE RIGHT FRONT SEAT BELT TENSION SENSOR WIRING AND SECURE THE WIRING WITH A NEW HARNESS CLIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 8, 2010. OWNERS MAY CONTACT HYUNDAI DE PUERTO RICO 1-787-999-3333.

Air Bags:frontal

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

09V497000 · Air Bags:frontal; Seat Belts:front

Dec 28, 2009

HYUNDAI IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 AZERA VEHICLES MANUFACTURED FROM SEPTEMBER 27, 2005, THROUGH OCTOBER 1, 2008. THE WIRING HARNESS FOR THE RIGHT FRONT SEAT BELT TENSION SENSOR MAY SUSTAIN DAMAGE AFTER REPEATED USE OF THE SEAT BELT. IF THE SEAT BELT TENSION SENSOR WIRING BECOMES DAMAGED THE AIR BAG WILL NOT DEPLOY IN THE EVENT OF A CRASH NECESSITATING FRONT AIR BAG DEPLOYMENT.

Consequence & remedy

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Additional source detail variants (2)

Seat Belts:front

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

Air Bags:frontal

Consequence: THE SEAT OCCUPANT IS AT AN INCREASED RISK OF INJURY SHOULD THE AIR BAG NOT DEPLOY AS INTENDED.

Remedy: HYUNDAI WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2010. OWNERS MAY CONTACT HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.

09V280000 · Exterior Lighting

Jul 21, 2009

HYUNDAI IS RECALLING 3,011 MODEL YEAR 2005-2007 ELANTRA, TUCSON, SONATA, AZERA AND ACCENT VEHICLES. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A DEFECTIVE STOP LAMP SWITCH MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION WOULD NOT BE ABLE TO BE SHIFT OUT OF THE "PARK" POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.

Consequence & remedy

Consequence: ANY OF THESE MALFUNCTIONS COULD LEAD TO A CRASH.

Remedy: DEALERS WILL REPLACE THE STOP LAMP SWITCH FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 2, 2009. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO CUSTOMER SERVICE AT 1-787-999-4310.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE13007 · Rear Control Arm Failure

Opened Mar 25, 2013 · Closed Aug 20, 2013

Status: closed (inferred from source dates) · Suspension:rear

In a letter dated August 9, 2013, Hyundai-Kia America Technical Center, Inc. (Hyundai) notified NHTSA that Hyundaiis conducting a safety recall (13V-354) involving approximately 239,000 vehicles involving model year (MY) 2006 through 2010 Hyundai Sonata vehicles (approximately 215,000)produced beginning on March 1, 2005 through January 21, 2010 and model year (MY) 2006 through 2011 Hyundai Azera vehicles (approximately 24,000) produced beginning on September 27, 2005 through November 22, 2010 that are registered in and operated or originally sold in the following 20 salt belt states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin.Hyundai will also inform dealers to inspect/repair vehicles that were previously registered in salt belt states but are currently registered elsewhere. Hyundai is conducting the recall to remedy a defect involving internal corrosion of the rear sub frame that may lead to separation of the rear upper/lower control arm(s) at their respective mounting points and/or separation of the axle from the transaxle where they meet.This could result in a loss of vehicle control and/or vehicle disablement which may increase the risk of a vehicle crash.In response to NHTSA?s Information Request (IR) letter, Hyundai stated the Azera vehicles utilizes the identical cross member and upper/lower rear control arm components as the subject (Sonata) vehicles.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Hyundai, ODI identified 19 non-duplicative reports alleging excessive corrosion of the rear sub frame. All of the complaint vehicles were either originally sold or registered at the time of the incident in one of the salt belt states.Of these 19 reports, 9 alleged either a suspension component separation or a fracture of the vehicle's rear cross member assembly.Similarly, ODI identified 8 warranty claims of rear sub frame replacement in data submitted by Hyundai due to excessive corrosion, all of which involved vehicles originally sold or operated in a salt belt state. Based on Hyundai's decision to conduct a safety recall, (13V-354) this investigation is closed.The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10535115, 10534110, 10525976, 10524726, 10521520, 10508368, 10505463, 10490073, 10486752, 10486435, 1048354, 10473922, and 10437887.