2001 Hyundai Accent

APPROXIMATELY 3000 MILES AFTER HAVING A 60,000 MILE SERVICE INVOLVING REPLACEMENT OF ALL BELTS, INCLUDING TIMING BELT USING HIGH QUALITY BELTS OF KNOWN QUALITY, A HIGH VOLTAGE ARCHING CONDITION IS OBSERVED ON THE FACE OF THE HARMONIC BALANCER (HB). ARCH IS APPROX. .250-.500 INCH IN LENGTH AND PROJECTS FROM THE OUTERMOST EDGE OF THE HB TOWARD THE CENTER OF SAME. USING A JUMPER CABLE CONNECTED TO THE NEGATIVE BATTERY TERMINAL, ARCH CAN BE PULLED FROM THE OUTER EDGE OF HARMONIC BALANCER, BUT NO OTHER PULLEY SURFACE NOR BELT SURFACE. CONDITION IS INTERMITTENT AND FORCED REPRODUCTION HAS NOT BEEN POSSIBLE, BUT OCCURS WITH SUFFICIENT FREQUENCY TO PERMIT TROUBLESHOOTING. CONDITION HAS NOT BEEN PREVIOUSLY OBSERVED. AFTER EXTENSIVE DIAGNOSIS, IT APPEARS THE INSULATOR RUBBER BETWEEN MATING PARTS OF THE HB HAS DEGRADED RESULTING IN EXCESSIVE INTERNAL RESISTANCE WHICH RESULTS IN STATIC CHARGE GENERATED BY BELTS TO ESCAPE PULLEY INTERIOR, DISCHARGING OVER THE EXTERIOR SURFACE. UNDER THE RIGHT CONDITIONS, THIS COULD RESULT IN AN EXPLOSIVE EVENT SHOULD A COMBUSTION FUEL BE PRESENT; THEREFORE THIS SHOULD BE INVESTIGATED AS A SAFETY ISSUE. DEALER STATES NO KNOWLEDGE OF THIS BEING AN ISSUE. REPLACEMENT HB ON ORDER AND IS EXPECTED IN ABOUT ONE WEEK. *TR

THE CONSUMER HAD TO BE PULLED FROM THE VEHICLE AFTER IT CAUGHT FIRE. *PH THE ENGINE LIGHT HAD COME ON AND THE BRAKES WERE SQUEAKY. THE VEHICLE WAS NOT PLACED IN GEAR. THE COLLISION EXPERTS CONCLUDED THAT THE MUFFLER HAD OVERHEATED AND PERHAPS FAULTY HEAT SHIELDS HAD CAUSED AN IGNITION IN THE INTERIOR OF THE VEHICLE WHICH HAD OBVIOUSLY BEEN ACCELERATED WHEN THE VEHICLE'S DOOR WAS OPENED. (THE INTERIOR WAS COMPLETELY BURNT DOWN TO THE METAL SEAT FRAMES) *SC

ALL WERE WARRANTY REPAIRS. THE IGNITION COIL WENT OUT FIRST. THEN THE CATALYTIC CONVERTER. THE BODY WAS JUST A MINOR THING, A RAIN RAIL CAME LOOSE, AND IT HAD TO BE REPLACED. FINALLY, THE CAR CAUGHT FIRE ON 09-02-03 AND IT IS TOTALLY. I ONLY HAD IT TWO YRS. AND IT ONLY HAD 31,000 MILES ON IT. IT HAS A HISTORY OF STALLING OUT ON TRIPS OF 30 MILES OR MORE, IT WOULD RESTART SOON THOUGH. CAR IS A TOTAL LOSS.

I HAVE A 2001 HYUNDAI ACCENT GL 1.6L ENGINE THE PULSE GENERATOR SWITCH HAS BROKEN 4 TIMES ALREADY EACH TIME I TAKE IT TO THE DEALERSHIP THEY TELL ME THAT THEY DON'T KNOW WHY IT KEEPS BREAKING AND THAT THERE ISN'T ANYTHING WRONG ONE TIME THE TRANSMISSION SWITCH BROKE, THE ENGINE LIGHT COMES ON AND GOES OUT, THE CAR HAS BEEN POORLY ACCELERATING AND SLOWING DOWN WHILE I AM ON THE HIGH WAY, ACCELERATING CRAZILY AND USING UP MORE GAS THAN NORMAL, IT HAS MADE SUDDEN JERKS WHEN I ACCELERATE AT TRAFFIC LIGHTS OR HAS STALLED FOR A FEW SECONDS WHEN I PRESS THE ACCELERATOR PEDAL THE CAR DOESN'T SEEM TO HAVE ENOUGH POWER AND THE PROBLEM IS SOLVED FOR ABOUT 24 HOURS AFTER I TAKE IT INTO THE DEALER THEN ITS BACK TO THE SAME ROUTINE. LATELY I HAVE BEEN HEARING A TICKING COMING FROM THE ENGINE. *LA

VEHICLE'S HAD A HIGH IDLE, WHICH CAUSED UNEXPECTED ACCELERATION. DEALER HAS REPAIRED THE DEFECTIVE PART, BUT PROBLEM STILL EXISTS. *AK AFTER THE REPAIR, BOTH THE THROTTLE POSITION SENSOR AND THE PULSE GENERATOR HAD GONE BAD. DEALERSHIP REFUSED TO COVER PARTS BECAUSE THEY WERE OUT OF WARRANTY. FINALLY THEY AGREED TO REPLACE THE THROTTLE POSITION SENSOR FREE OF CHARGE. THE CONSUMER HAD TO PAY FOR THE PULSE GENERATOR TO BE REPLACED. CONSUMER FEELS THE PRESCRIPTION OUTLINED IN THE RECALL WASN'T SUFFICIENT TO CORRECT THE EMISSIONS DEFECT. *PH *JB