BRAKE SYSTEM WAS GRINDING. WHEN CONSUMER APPLIED THE BRAKES PEDAL WENT ALL THE WAY TO THE FLOOR. VEHICLE HAS HAD FORTY WORK ORDERS. ALSO, RADIO MALFUNCTIONED. WHEN TURNING THE VOLUME UP THE STATION CHANGED. SEAT BELTS AND SUNVISORS DON'T WORK PROPERLY, TRANSMISSION PROBLEMS, WINDOWS GO DOWN ABOUT 1/4 IN WHILE DRIVING. …
Read full complaint
BRAKE SYSTEM WAS GRINDING. WHEN CONSUMER APPLIED THE BRAKES PEDAL WENT ALL THE WAY TO THE FLOOR. VEHICLE HAS HAD FORTY WORK ORDERS. ALSO, RADIO MALFUNCTIONED. WHEN TURNING THE VOLUME UP THE STATION CHANGED. SEAT BELTS AND SUNVISORS DON'T WORK PROPERLY, TRANSMISSION PROBLEMS, WINDOWS GO DOWN ABOUT 1/4 IN WHILE DRIVING. *AK *ML
NHTSA ODI #857431
Mileage unknown · Nov 3, 1999
Service Brakes, Hydraulic
WHILE DRIVING ON THE HWY ON RAINY NIGHT HEARD A GRINDING NOISE IN THE BRAKES. TRIED TO SLOW DOWN, APPLIED BRAKES AND WENT INTO A DITCH. CONTACTED DEALER MAY THE NECESSARY REPAIR FOR A RECALL. *AK
NHTSA ODI #852513
Mileage unknown · Dec 3, 1998
Service Brakes, HydraulicSuspension
WHILE DRIVING AT 40 MPH THERE WAS A LOUD CRACKING NOISE COMING FROM THE LEFT SIDE OF THE VEHICLE, AND THE VEHICLE VIBRATED WHEN DRIVING AT ANY SPEED. ALSO, WHEN APPLYING THE BRAKES THE VEHICLE WILL PULL TO THE RIGHT. *AK
NHTSA ODI #831684
Mileage unknown · Feb 27, 1998
Service Brakes, Hydraulic
CONSUMEREXPERIENCING EXCESSIVE WEAR OF THE FRONT BRAKES SHOES AND PADS. CONSUMER HAS REPLACED THE BRAKES ON TWO OCCASIONS WITHIN NINE MONTHS. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #821723
Mileage unknown · Nov 22, 1996
Engine And Engine CoolingEquipmentPower Train
ENGINE NOISE.
NHTSA ODI #511621
Mileage unknown · Date not reported
Electrical SystemFuel System, GasolinePower Train
VEHICLE HAS HAD MULTIPLE PROBLEMS INCLUDING: FUEL LINE MALFUNCTION, GEARS SHIFT AT WILL, IGNITION LOCKED WITH KEY IN, AND BRAKE MALFUNCITON.
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. DURING WINTER MONTHS, LARGE QUANTITIES OF SALT ARE USED TO DE-ICE ROADS. THIS ROAD SALT COULD RESULT IN CORROSION OF THE FRONT LOWER CONTROL ARMS.
Consequence & remedy
Consequence: SEVERE CORROSION COULD RESULT IN PERFORATION AND POTENTIAL FRACTURE OF THE FRONT LOWER CONTROL ARM. IF THIS FRACTURE OCCURS, THE TIRE AND WHEEL ASSEMBLY REMAINS CONNECTED TO THE CHASSIS THROUGH THE FORWARD LOWER CONTROL ARM PIVOT POINT AND THROUGH THE STRUT ATTACHMENT TO THE UPPER WHEELHOUSE. REDUCED CONTROL OF THE FRONT WHEEL LOCATION INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS AND, IF NECESSARY, WILL REPLACE ONE OR BOTH FRONT LOWER CONTROL ARMS IF STRUCTURAL DAMAGE HAS OCCURRED. OWNER NOTIFICATION WILL BEGIN ON JUNE 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DURING WINTER MONTHS, THE ROAD SALT USED TO DE-ICE ROADS CAN RESULT IN CORROSION THAT CAUSES PITS TO FORM ON THE LOWER COIL OF THE FRONT SPRINGS ALLOWING CRACKS TO DEVELOP. THIS CAN RESULT IN BREAKAGE OF THE LOWER SPRING COIL.
Consequence & remedy
Consequence: IF THE FRONT COIL SPRING BREAKS, IT CAN BECOME DISPLACED FROM ITS SEATED POSITION, AND CAN CONTACT A TIRE. TIRE DAMAGE CAN RESULT.
Remedy: DEALERS WILL INSTALL A SPRING GUIDE TO PREVENT A BROKEN COIL SPRING FROM CONTACTING AND DAMAGING A TIRE.
THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER ELECTRICAL CONTACTS WERE CONTAMINATED DURING ASSEMBLY.
Consequence & remedy
Consequence: THIS CONTAMINATION INTERFERES WITH THE ELECTRICAL CIRCUIT CONTINUITY AND PREVENTS THE WINDSHIELD WIPER MOTOR FROM OPERATING. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REMOVE THE CONTAMINANTS FROM THE WINDSHIELD WIPER MOTOR CIRCUIT BREAKER CONTACTS.
THROUGH CONTACT WITH ROAD HAZARDS AND CURBS, THE LOWER CONTROL ARM ASSEMBLY CAN SHIFT FROM ITS ORIGINAL POSITION.
Consequence & remedy
Consequence: THE SHIFTED LOCATION CAN RESULT IN IMPROPER WHEEL ALIGNMENT AND INCREASED STEERING EFFORT INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REINFORCE THE LOWER CONTROL ARM MEMBER ASSEMBLY ATTACHMENT TO THE UNDERBODY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE02055 · Front Suspension Lower Control Arm
Opened Jul 2, 2002 · Closed Dec 20, 2002
Status: closed (inferred from source dates) · Suspension; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
ON DECEMBER 18TH, 2002 HYUNDAI AMERICA TECHNICAL CENTER, INC. (HYUNDAI) SUBMITTED A DEFECT INFORMATION REPORT REGARDING APPROXIMATELY 47,000 1995 AND 1996 HYUNDAI ACCENT VEHICLES REGISTERED IN SALT BELT STATES.ACCORDING TO HYUNDAI, THESE VEHICLES WERE MANUFACTURED WITH FRONT SUSPENSION LOWER CONTROL ARMS WITH AN INTERIOR PARTITION WALL.THE PARTITION WALL RESTRICTS THE COVERAGE OF PAINT TO THE INTERIOR SURFACES OF THE CONTROL ARM.WHEN OPERATED IN AREAS OF THE COUNTRY THAT USE ROAD SALT FOR DE-ICING, THE LOWER CONTROL ARM CAN CORRODE OVER TIME.THIS CORROSION CAN LEAD TO PERFORATION AND CAN POSSIBLY FRACTURE BETWEEN THE FRONT AND REAR PIVOT POINTS OF THE ARM.SUCH A FRACTURE LIMITS THE FRONT SUSPENSION'S ABILITY TO CONTROL FRONT TO BACK MOVEMENT OF THE WHEEL.UNDER BRAKING, THE FRONT WHEEL CAN CONTACT THE WHEELHOUSE.ALL KNOWN FAILURES HAVE OCCURRED IN SALT BELT STATES.VEHICLES WILL BE INSPECTED FOR LOWER CONTROL ARM CORROSION DAMAGE AND, IF DAMAGED, THE ARMS WILL BE REPLACED.
Additional source detail variants (3)
Suspension:front:control Arm
ON DECEMBER 18TH, 2002 HYUNDAI AMERICA TECHNICAL CENTER, INC. (HYUNDAI) SUBMITTED A DEFECT INFORMATION REPORT REGARDING APPROXIMATELY 47,000 1995 AND 1996 HYUNDAI ACCENT VEHICLES REGISTERED IN SALT BELT STATES.ACCORDING TO HYUNDAI, THESE VEHICLES WERE MANUFACTURED WITH FRONT SUSPENSION LOWER CONTROL ARMS WITH AN INTERIOR PARTITION WALL.THE PARTITION WALL RESTRICTS THE COVERAGE OF PAINT TO THE INTERIOR SURFACES OF THE CONTROL ARM.WHEN OPERATED IN AREAS OF THE COUNTRY THAT USE ROAD SALT FOR DE-ICING, THE LOWER CONTROL ARM CAN CORRODE OVER TIME.THIS CORROSION CAN LEAD TO PERFORATION AND CAN POSSIBLY FRACTURE BETWEEN THE FRONT AND REAR PIVOT POINTS OF THE ARM.SUCH A FRACTURE LIMITS THE FRONT SUSPENSION'S ABILITY TO CONTROL FRONT TO BACK MOVEMENT OF THE WHEEL.UNDER BRAKING, THE FRONT WHEEL CAN CONTACT THE WHEELHOUSE.ALL KNOWN FAILURES HAVE OCCURRED IN SALT BELT STATES.VEHICLES WILL BE INSPECTED FOR LOWER CONTROL ARM CORROSION DAMAGE AND, IF DAMAGED, THE ARMS WILL BE REPLACED.
Suspension:front:control Arm:lower Arm
ON DECEMBER 18TH, 2002 HYUNDAI AMERICA TECHNICAL CENTER, INC. (HYUNDAI) SUBMITTED A DEFECT INFORMATION REPORT REGARDING APPROXIMATELY 47,000 1995 AND 1996 HYUNDAI ACCENT VEHICLES REGISTERED IN SALT BELT STATES.ACCORDING TO HYUNDAI, THESE VEHICLES WERE MANUFACTURED WITH FRONT SUSPENSION LOWER CONTROL ARMS WITH AN INTERIOR PARTITION WALL.THE PARTITION WALL RESTRICTS THE COVERAGE OF PAINT TO THE INTERIOR SURFACES OF THE CONTROL ARM.WHEN OPERATED IN AREAS OF THE COUNTRY THAT USE ROAD SALT FOR DE-ICING, THE LOWER CONTROL ARM CAN CORRODE OVER TIME.THIS CORROSION CAN LEAD TO PERFORATION AND CAN POSSIBLY FRACTURE BETWEEN THE FRONT AND REAR PIVOT POINTS OF THE ARM.SUCH A FRACTURE LIMITS THE FRONT SUSPENSION'S ABILITY TO CONTROL FRONT TO BACK MOVEMENT OF THE WHEEL.UNDER BRAKING, THE FRONT WHEEL CAN CONTACT THE WHEELHOUSE.ALL KNOWN FAILURES HAVE OCCURRED IN SALT BELT STATES.VEHICLES WILL BE INSPECTED FOR LOWER CONTROL ARM CORROSION DAMAGE AND, IF DAMAGED, THE ARMS WILL BE REPLACED.
Suspension
ON DECEMBER 18TH, 2002 HYUNDAI AMERICA TECHNICAL CENTER, INC. (HYUNDAI) SUBMITTED A DEFECT INFORMATION REPORT REGARDING APPROXIMATELY 47,000 1995 AND 1996 HYUNDAI ACCENT VEHICLES REGISTERED IN SALT BELT STATES.ACCORDING TO HYUNDAI, THESE VEHICLES WERE MANUFACTURED WITH FRONT SUSPENSION LOWER CONTROL ARMS WITH AN INTERIOR PARTITION WALL.THE PARTITION WALL RESTRICTS THE COVERAGE OF PAINT TO THE INTERIOR SURFACES OF THE CONTROL ARM.WHEN OPERATED IN AREAS OF THE COUNTRY THAT USE ROAD SALT FOR DE-ICING, THE LOWER CONTROL ARM CAN CORRODE OVER TIME.THIS CORROSION CAN LEAD TO PERFORATION AND CAN POSSIBLY FRACTURE BETWEEN THE FRONT AND REAR PIVOT POINTS OF THE ARM.SUCH A FRACTURE LIMITS THE FRONT SUSPENSION'S ABILITY TO CONTROL FRONT TO BACK MOVEMENT OF THE WHEEL.UNDER BRAKING, THE FRONT WHEEL CAN CONTACT THE WHEELHOUSE.ALL KNOWN FAILURES HAVE OCCURRED IN SALT BELT STATES.VEHICLES WILL BE INSPECTED FOR LOWER CONTROL ARM CORROSION DAMAGE AND, IF DAMAGED, THE ARMS WILL BE REPLACED.
EA00001 · Passenger Air Bag Related
Opened Jan 5, 2000 · Closed Mar 9, 2001
Status: closed (inferred from source dates) · Air Bags:frontal
There is no summary currently available
PE99046 · Passenger Air Bag Related Fatalities
Opened Jul 7, 1999 · Closed Jan 5, 2000
Status: closed (inferred from source dates) · Air Bags:frontal
ODI IS AWARE OF SEVEN FATALITIES OF CHILDREN (EXCLUDING CHILDREN IN REAR FACING CHILD SAFETY SEATS)THAT WERE CAUSED BY THE DEPLOYMENT OF THE FRONT PASSENGER AIR BAGS IN MINOR OR MODERATE SEVERITY CRASHES INVOLVING MODEL YEAR 1995 THROUGH 1997 HYUNDAI ACCENT VEHICLES.TWO OF THE SEVEN FATALITIES OCCURRED IN PUERTO RICO.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS FORFURTHER INVESTIGATION.
1996 Hyundai Accent Problems, Complaints & Recalls | Skip That Year
Illustration