1. I WAS RIDING MY 2006 HYOSUNG GV650, A BOLT WHICH ATTACHES THE HANDLE BARS TO THE UPPER TREE HAD SHEARED. THE HANDLE BARS HAD DETACHED FROM THE MOTORCYCLE, RENDERING LOSS OF CONTROL. *TR 2. THE FAILURE RESULTED OF A BROKEN BOLT. THIS FAILURE OCCURRED ONCE AND HAS RENDERED THE MOTORCYCLE INOPERABLE. THE CONSEQUENCES OF THE B…
Read full complaint
1. I WAS RIDING MY 2006 HYOSUNG GV650, A BOLT WHICH ATTACHES THE HANDLE BARS TO THE UPPER TREE HAD SHEARED. THE HANDLE BARS HAD DETACHED FROM THE MOTORCYCLE, RENDERING LOSS OF CONTROL. *TR 2. THE FAILURE RESULTED OF A BROKEN BOLT. THIS FAILURE OCCURRED ONCE AND HAS RENDERED THE MOTORCYCLE INOPERABLE. THE CONSEQUENCES OF THE BOLT FAILURE, RENDERED LOSS OF CONTROL OF THE MOTORCYCLE AND DAMAGE TO THE MOTORCYCLE. DAMAGE WAS SUSTAINED TO THE THROTTLE ASSEMBLY, FURTHER RENDERING IT INOPERABLE, AND HAD COMPOUNDED LOSS OF CONTROL OF THE MOTORCYCLE. DAMAGE HAS ALSO OCCURRED TO THE HANDLE BAR ASSEMBLY AND THE UPPER TREE. 3. I HAVE CONTACTED THE DEALERSHIP FROM WHICH I PURCHASED THE MOTORCYCLE. I HAVE ALSO CONTACTED THE CORPORATE OFFICES OF HYOSUNG USA REGARDING THIS ISSUE. NEITHER PARTY HAS RECTIFIED THE ISSUE, NOR RETURNED MY CALLS/E-MAILS. THE MANUFACTURER HAS DONE TO CORRECT THE FAILURE. NO PARTS HAVE BEEN REPAIRED, OR REPLACED. THE EFFECTED PART (TO THE BEST OF MY KNOWLEDGE) WAS REPLACED UNDER NHTSA CAMPAIGN ID NUMBER: 07V015000. THE BOLT THAT HAD FAILED WAS THE APPROVED REPLACEMENT/REDESIGNED BOLT. THE BOLT WHICH HAD FAILED IS IN MY POSSESSION AND IS AVAILABLE. *TR
HYOSUNG IS RECALLING 3,292 MY 2005-2007 GT650 AND GV650 MOTORCYCLES. THESE MOTORCYCLES WERE BUILT WITH FUEL TANK CAP GASKETS THAT PREVENT PROPER TANK VENTILATION.
Consequence & remedy
Consequence: THIS COULD RESULT IN VEHICLE STALLING WHICH COULD RESULT IN A CRASH AND/OR FUEL LEAKAGE WHICH COULD RESULT IN A FIRE.
Remedy: DEALERS WILL MODIFY THE EXISTING GAS CAP GASKET. THE RECALL BEGAN ON APRIL 1, 2008. OWNERS MAY CONTACT HYOSUNG AT 1-770-447-5571.
ODI RECEIVED A VEHICLE OWNER QUESTIONNAIRE (VOQ) ALLEGING A HYOSUNG GV650 LEAKED FUEL FROM A FUEL TANK SEAM.AFTER A HYOSUNG DEALER REPLACED THE TANK, FUEL AGAIN LEAKED FROM THE MOTORCYCLE AND IT BEGAN TO STALL.SUBSEQUENTLY, HYOSUNG ADVISED THE CUSTOMER THAT THE PROBLEM COULD HAVE BEEN AVOIDED IF THE DEALER HAD FOLLOWED THE INSTRUCTIONS IN ITS APRIL 2007 TSB.THAT TSB ACKNOWLEDGED THE SUBJECT VEHICLES FUEL TANK WAS NOT VENTING PROPERLY DUE TO AN IMPROPERLY FABRICATED GAS CAP GASKET.WITHOUT PROPER VENTING, THE BIKES WOULD STALL OR THE FUEL TANK WOULD COLLAPSE AND LEAK OR BOTH.ON FEBRUARY 12, 2008, AFTER DISCUSSING THE ISSUE WITH ODI STAFF, HYOSUNG AGREED TO CONDUCT A SAFETY RECALL TO MODIFY THE GAS CAP GASKET.WITH THAT RECALL, THIS PE IS CLOSED.
2006 Hyosung GV650 Problems, Complaints & Recalls | Skip That Year
Illustration