The contact owns a 2005 Hummer H2. The contact stated that while parking in the mountains, the vehicle was in the park position, and it unexpectedly rolled and stopped at a boulder. There were no warning lights illuminated. The door hit the driver and knocked him to the ground, and he sustained an injury to his head, but medical…
Read full complaint
The contact owns a 2005 Hummer H2. The contact stated that while parking in the mountains, the vehicle was in the park position, and it unexpectedly rolled and stopped at a boulder. There were no warning lights illuminated. The door hit the driver and knocked him to the ground, and he sustained an injury to his head, but medical attention was not provided. Another person on an ATV provided a jump start, but the vehicle failed to restart. The contact walked several miles to get assistance. The contact was able to view YouTube and replace the part. The contact stated that the transmission shifter cable had failed. There was a hole in the shaft connected to the transmission to the C clip. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 111,400.
NHTSA ODI #11676916
160,000 miles · Mar 4, 2020
Electrical SystemEngineVisibility/wiper
THE COMPUTER IN THE H2 HUMMER MALFUNCTION. WIPERS WILL NOT TURN OFF. 4 WHEEL DRIVE WILL NOT ENGAGE. ENGINE LIGHT COMES ON. EVERYTHING THE COMPUTER CONTROLS IS FAILING.
NHTSA ODI #11316038
99,000 miles · Dec 5, 2019
EngineUnknown Or Other
CHECK ENGINE LIGHT KEEPS COMING ON AND LIGHT BLINKS THAN STAYS ON UNTIL I TAKE IT IN FOR SERVICE. THE SHOP CAN'T FIGURE OUT WHY IT IS DOING THIS HAD IT SHOP ABOUT 7-8 TIMES FOR SERVICE. ALSO CODE STATES CAN CAUSE A POSSIBLE FIRE
NHTSA ODI #11287186
133,000 miles · Jul 18, 2018
Engine
VEHICLE HAS 133,000 MILES. IT HAS NOW EXPERIENCED AN EXHAUST MANIFOLD GASKET LEAK DUE TO BROKEN BOLTS. THIS IS CAUSING NOISE FROM THE ENGINE AREA, AND IS UNSAFE DUE TO THE LEAK OF HOT GASES BEING RELEASED FROM THE ENGINE AT THE POINTS OF FAILURE (BROKEN BOLTS). THIS MAY BE AN EPA CONCERN AS WELL, AND COULD ALSO LEAD TO FAILUR…
Read full complaint
VEHICLE HAS 133,000 MILES. IT HAS NOW EXPERIENCED AN EXHAUST MANIFOLD GASKET LEAK DUE TO BROKEN BOLTS. THIS IS CAUSING NOISE FROM THE ENGINE AREA, AND IS UNSAFE DUE TO THE LEAK OF HOT GASES BEING RELEASED FROM THE ENGINE AT THE POINTS OF FAILURE (BROKEN BOLTS). THIS MAY BE AN EPA CONCERN AS WELL, AND COULD ALSO LEAD TO FAILURE OF CATALYTIC CONVERTER. REPAIR ESTIMATE IS $1,300. AN ONLINE SEARCH YIELDS HUNDREDS OF OTHER RESULTS WITH SAME FAILURE AND COMPLAINT ON ALL GM V8 ENGINES FOR YEARS 1999-2007. THIS AFFECTS THE 4.8L, 5.3L, AND 6.0L MODELS. THIS IS A DESIGN FAILURE AND THE AFFECTED VEHICLES WITH THESE ENGINES SHOULD BE RECALLED.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ODI UPGRADED THIS INVESTIGATION AT THE CONCLUSION OF PE04-080.THE ALLEGED DEFECT INVOLVES THE FAILURE OF THE STEERING KNUCKLE AT THE LOWER BALL JOINT BOSS, RESULTING IN A SEPARATION OF THE LOWER BALL JOINT FROM THE KNUCKLE.A LOWER BALL JOINT SEPARATION COULD RESULT IN A LOSS OF STEERING AND/OR A DISABLED VEHICLE. IT APPEARS THAT THE FRACTURES OF H2 STEERING KNUCKLES CAN BE ATTRIBUTED TO WHEEL/TIRE COLLISION FORCES BEING TRANSFERRED DIRECTLY TO THE STEERING KNUCKLE.THE ORIGINAL KNUCKLE DESIGN APPEARS TO BE SUFFICIENT FOR THE H2 APPLICATION.EVIDENCE FROM INSPECTED VEHICLES, PHOTOGRAPHS, POLICE REPORTS AND EDR DATA INDICATES COLLISION IMPACT EVENTS PLACED STRESS ON THE STEERING KNUCKLE CAUSING IT TO FRACTURE.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH REGARD TO THE SUBJECT COMPONENT.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THIS ISSUE IF WARRANTED.
2005 Hummer H2 Problems, Complaints & Recalls | Skip That Year
Illustration