SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2017 Honda Pilot

Owner reports · Recalls · Investigations

More warning signs than most Pilot years

Owner complaints for the 2017 Honda Pilot are substantially higher than the model-year median of 239.5.

About this comparison →
920Owner complaints

Model-year median: 239.5

4Recall campaigns

View recall details →

4Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
116
2014109
20151,699
2016920
2017439
2018903
2019485
2020
Compare all Pilot years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Engine
465Electrical System
264Unknown Or Other
134Fuel/propulsion System
122Power Train
122
All reported categories
Vehicle Speed Control
30Service Brakes
26Forward Collision Avoidance
22Fuel System, Gasoline
19Structure
15Seat Belts
14Lane Departure
13Visibility/wiper
13Engine And Engine Cooling
12Exterior Lighting
10Electronic Stability Control (esc)
8Steering
8Suspension
8Latches/locks/linkages
5Visibility
4Air Bags
3Back Over Prevention
3Seats
3Child Seat
1Service Brakes, Hydraulic
1Traction Control System
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

252 reports with mileage · 668 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 465 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 264 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports5 fire reports3 injury reports

What owners actually said

920 reports
Mileage unknown · Aug 8, 2023
Engine

When I come to a stop (like a red light) the auto idle kicks in. When I move my foot from the brake to the gas pedal, the engine shuts off completely. It then takes a couple times before I can get the starter to start again. Therefore I am sitting at an intersection with an engine that is dead while other cars are coming up behi…

Read full complaint

When I come to a stop (like a red light) the auto idle kicks in. When I move my foot from the brake to the gas pedal, the engine shuts off completely. It then takes a couple times before I can get the starter to start again. Therefore I am sitting at an intersection with an engine that is dead while other cars are coming up behind me, either from a stop, or coming up behind me at full speed. I am concerned I will be rear ended. I have taken it in and they replaced the battery which helped for awhile. I then got a notice from Honda, took the car in and they did an "update" on the computer system. Again the other day, while at a light, the engine cut off when I moved my foot from the brake to the gas pedal. No warning lights, no other symptoms that give me warning as to the problem.

NHTSA ODI #11537295

Mileage unknown · Aug 8, 2023
Power Train

The transmission temperature to high light came on as I was driving from NY to NC, I had to pull over because I was afraid the car might catch fire as I have never seen or heard of a transmission being to hot. I was on the side of the NJ turnpike and a vehicle could of crashed into me. The light went off and I continued on my jo…

Read full complaint

The transmission temperature to high light came on as I was driving from NY to NC, I had to pull over because I was afraid the car might catch fire as I have never seen or heard of a transmission being to hot. I was on the side of the NJ turnpike and a vehicle could of crashed into me. The light went off and I continued on my journey. Then about another hour or 2 later a transmission system problem light came on. I stopped in VA and went to a Valvoline where they told me I needed transmission fluid. (I had just had an inspection done, so thought maybe there was a leak.) I continued on my way to NC as the light went off after they put fluid in the car. I was about 2 hours away from my destination in NC when the temperature to high transmission light went on again and I had to pull over on 795 again becasue I was scared. I shut the car off for a half hour on the side of the road praying no one would hit into me. I turned the car on, and the light went off and a few minutes later the transmission system problem light came on. I was afraid to get off an exit as I was unfamiliar with the area, so I drove at 55 mph in a 70-mph speed limit. I made it to Wilmington and called the Stevenson Hendrick Honda Dealership there and they could not see the car until Tuesday 7/18 the light was going on 7/15. When I brought it to the dealer the light was off. They told me my Honda Pilot that had only 49,000 miles on it needed a new transmission to the tune of $11,000. I find this to be absurd. I was able to talk them down in price and was without a car for the entire week I was in NC. I opened a case with corporate, but they won't return my phone calls. I could of died pulling off to the side of major highways with the speed the cars were traveling at. This car was just in for a recall with the hood and they did a diagnostics test and nothing showed anything about a transmission problem. It had just had an inspection. This should not have happened with only 49,000 miles.

NHTSA ODI #11537159

Mileage unknown · Aug 1, 2023
Electrical SystemEngine

For the past two years, I have been taking my Honda pilot to a Honda dealership, complaining of the auto shut off feature. I will come to a stop at a stop sign or stop light. The car would do the auto shut off and when I lift my foot from the break for the car to start again, it won’t. The car will have its lights lit up, but I …

Read full complaint

For the past two years, I have been taking my Honda pilot to a Honda dealership, complaining of the auto shut off feature. I will come to a stop at a stop sign or stop light. The car would do the auto shut off and when I lift my foot from the break for the car to start again, it won’t. The car will have its lights lit up, but I won’t be unable to turn the vehicle on. I will then have to turn the car off and then start it all over again. All while cars are honking and I’m in the middle of the road. Holler Honda never fixed this problem. I took in videos and photos and I explained it to them and they said they could not replicate the problem and therefore could not fix anything. I continued to drive the vehicle like that. In January 2023 a service bulletin was released where Honda described this exact issue that were happening amongst other 2017 Honda pilot. I took my car in and I said this is exactly what’s happening. My service advisor told me that he needed to do the software update first per the service bulletin. He said if it doesn’t work then to bring the car back and they will do the remainder of the repairs, such as replacing the starter and the assembly. I asked him if we could skip the software update since we’ve been having this issue for over two years and he said no. Six months later I am driving down the interstate and come to a complete stop and the entire car shuts off and never restarts again. I was stranded on the interstate for over four hours, waiting for a tow truck. I had to have the police come because it was at 6 PM and soon after got dark. It’s a huge safety issue especially considering that I have two kids. Something could’ve happened to me. I have the police report number and receipt for the tow truck ($281.00)

NHTSA ODI #11535671

Mileage unknown · Jul 26, 2023
Power Train

I have the automatic start and stop (idle) feature and it cuts out on me in the middle of intersections and won't allow the car to restart. I took to dealer to have software updated and they charged me and now it is starting again. Someone almost blindsided me in the intersection and I don't want someone to get killed.

NHTSA ODI #11534518

Mileage unknown · Jul 26, 2023
Electrical SystemEngineFuel/propulsion System

I had been driving for over an hour at 70 when I crossed into Pennsylvania and encountered crawl speed traffic. I exited the highway at exit 1. At the top of the ramp there is a traffic signal. I stopped at the red and the vehicle shut down. The light turned to green and the vehicle immediately in front of me proceeded into the …

Read full complaint

I had been driving for over an hour at 70 when I crossed into Pennsylvania and encountered crawl speed traffic. I exited the highway at exit 1. At the top of the ramp there is a traffic signal. I stopped at the red and the vehicle shut down. The light turned to green and the vehicle immediately in front of me proceeded into the intersection. I removed my foot from the brake and attempted to go. The engine auto stop-start kicked the engine but then the engine immediately cut off and the chimes went off. The car behind be stopped abruptly to avoid contact. Attempting to understand what occurred i looked at screen. The screen indicated to shift the vehicle into park. I did. The vehicle did nothing. Since there is no way to to start the engine without it, I was forced to turn the vehicle off using the On/Start/Off button. Hitting the button turned the car off, a second press would normally start the vehicle but it did not. I cycled the button 2 more times and the engine started. This system is flawed.

NHTSA ODI #11534493

Mileage unknown · Jul 24, 2023
Unknown Or Other

The car had 49,400 miles on it when I decided to take a trip to see a friend in NC from NY about 3 hours into my trip a transmission temperature to high light came on. I pulled over turned the car off for a half hour and restarted it and the light disappeared after another hour a light came on that said transmission problems. I …

Read full complaint

The car had 49,400 miles on it when I decided to take a trip to see a friend in NC from NY about 3 hours into my trip a transmission temperature to high light came on. I pulled over turned the car off for a half hour and restarted it and the light disappeared after another hour a light came on that said transmission problems. I stopped in VA and brought it to a Valvoline where they flushed the fluid and said it was running low on transmission fluid. I continued on my journey and no light came on and 2 hours into driving the transmission temperature light came back on. When I arrived in NC I brought it to a Honda dealership where I was told I needed a new transmission on a car that only had 49,000 miles and was a $65,000 car. I also had to pull over on major highways because I was scared the car would catch fire. (Pulled over on NJ turnpike and I-95)

NHTSA ODI #11534069

Mileage unknown · Jul 4, 2023
Electrical SystemEngine

While Stopped at a stoplight the Auto Start/Stop feature stalled the engine. This has happened to us multiple times.

NHTSA ODI #11530279

Mileage unknown · Jun 28, 2023
Electrical SystemEngineVehicle Speed Control

A few months ago, car started alarming randomly. Upon entering vehicle all lights on dashboard were going on and off, screen was going through each system followed by "problem" and repeated clicking heard in steering column and captured on video for 1 minute. This continued for several days but car drove okay. Alarming bouts cam…

Read full complaint

A few months ago, car started alarming randomly. Upon entering vehicle all lights on dashboard were going on and off, screen was going through each system followed by "problem" and repeated clicking heard in steering column and captured on video for 1 minute. This continued for several days but car drove okay. Alarming bouts came and went for a few days. I researched and found that it was probably the Keyless Access Control Unit based on other owners of similar years/models. Took to dealer and showed my video. After inspecting they came back saying that they called Honda and it was a different part (unknown) but described as more of the control computer for the car. They placed the part on order, but said that another customer had the part on order for over 4 months at that time with no ETA. Six weeks later, without an incident, the car started alarming again on a hot day. Dashboard lights lighting up, clicking in steering wheel, etc. I drove the car for a few errands just fine, until I went to pull out onto a US Hwy and the clicking began, lights flashed, and the car felt as if it stalled as I was entering the road. Suddenly, it couldn't go more than 2 or 3 MPH, although speedometer wasn't working. I was able to stop it and reverse back (2-3 MPH) into the driveway quickly just before oncoming traffic hit me. When the clicking and flashing stopped, the info screen went through every car system alphabetically and listed "Problem" afterwards. I couldn't get the car to drive normally after turning it on/off several times. I disconnected the battery and that stopped the problem. Two weeks later, dealer said part was in so I scheduled replacement. Dealer replaced "Keyless Access Control Unit" despite telling me 2 months beforehand that it was something different. Car has been problem free since replacement, but it has not been long. Additionally, my neighbor has Pilot of similar year, and has the same exact problem of alarming/clicking, etc.

NHTSA ODI #11529279

Mileage unknown · Jun 16, 2023
Power Train

Torque Converter clutch slipping due to Honda 3.6L V6 VSC Vibration. Received a "Transmission System Error" warning multiple times while driving at 65MPH highway. Vehicle has less than 47,000 miles but is out of warranty due to the age of the vehicle. Dealership stated the Torque Converter needs to be replaced even though reg…

Read full complaint

Torque Converter clutch slipping due to Honda 3.6L V6 VSC Vibration. Received a "Transmission System Error" warning multiple times while driving at 65MPH highway. Vehicle has less than 47,000 miles but is out of warranty due to the age of the vehicle. Dealership stated the Torque Converter needs to be replaced even though regular maintenance was performed previously. Dealership stated that the Torque Converter could go bad at any time and cause transmission issues requiring the entire thing to require replacement and is charging a lot of money for the replacement. Research shows many 3rd Generation Honda PIlot owners experiencing the same exact issue due to the VSC built into the engine and others are getting hit with costs at around the same mileage. We should not be penalized for a poorly designed or manufactured powertrain component that apparently requires replacement just after the powertrain warranty expires.

NHTSA ODI #11527410

Mileage unknown · Jun 6, 2023
Electrical System

When the vehicle has been shut off, there is an electrical system problem that attempts to re-start the vehicle. the alarm goes off, headlights turn on, the dashboard lights up. This cycles over and over unless you open the hood or a door to "fool" the system. If you don't do this, then often the headlights and dash light wi…

Read full complaint

When the vehicle has been shut off, there is an electrical system problem that attempts to re-start the vehicle. the alarm goes off, headlights turn on, the dashboard lights up. This cycles over and over unless you open the hood or a door to "fool" the system. If you don't do this, then often the headlights and dash light will remain on overnight and the battery is dead the next morning. This prblem has been occurring for two years, but the dealr has not diagnosed it becasue it is intermittand and doesn't throw a code.

NHTSA ODI #11525588

Official recalls

4

26V365000 · Structure:frame And Members; Suspension:rear

Jun 4, 2026

American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.

Consequence & remedy

Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.

Additional source detail variants (2)

Structure:frame And Members

American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.

Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.

Suspension:rear

American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.

Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.

26V332000 · Air Bags:sensor:occupant Classification:front Passenger

May 21, 2026

Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.

Consequence & remedy

Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.

Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.

23V858000 · Fuel System, Gasoline:delivery:fuel Pump

Dec 18, 2023

Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.

Consequence & remedy

Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.

Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.

21V932000 · Latches/locks/linkages:hood:latch; Structure:body:hood

Nov 29, 2021

Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.

Consequence & remedy

Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.

Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.

Additional source detail variants (2)

Latches/locks/linkages:hood:latch

Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.

Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.

Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.

Structure:body:hood

Honda (American Honda Motor Co.) is recalling certain 2019 Passport, 2016-2019 Pilot, and 2017-2020 Ridgeline vehicles. The hood latch striker may become damaged and separate from the hood, which can result in the hood opening while driving.

Consequence: A hood that opens while driving can obstruct the driver's view and increase the risk of a crash.

Remedy: Dealers will either repair the hood latch striker, or replace the hood if necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is PBV.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

PE25008 · Engine Failure

Opened Aug 20, 2025 · No close date supplied

Status: open (inferred from source dates) · Engine

The Office of Defects Investigation (ODI) has received 414 reports of connecting rod bearing failures in the 3.5L V6 engine used in the following vehicles: Model Years (MY) 2018-2020 Acura TLX, MY2016-2020 Acura MDX, MY2016-2020 Honda Pilot, MY2018-2020 Honda Odyssey, and MY2017-2019 Honda Ridgeline.  The subject engine failures were analyzed as part of a Recall Query (RQ24013).  It was determined that these engine failures are outside the scope of Honda Recall 23V-751. Further, evidence gathered in conjunction with RQ24013 does not suggest this failure is caused by the same crankshaft manufacturing defect that is addressed by Honda in Recall 23V-751.  Based on analysis of data from RQ24013, NHTSA has closed that investigation. The significant number of reports of engine failure in vehicles outside the scope of RQ24013 presents a potential safety risk that warrants further investigation.  ODI is opening this Preliminary Evaluation (PE) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues.  To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

EA25004 · No Restart After Auto Start/stop Engages

Opened Mar 26, 2025 · No close date supplied

Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (4)

Engine And Engine Cooling:engine:crank/camshaft Position Sensor

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine And Engine Cooling:engine

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ24013 · Engine Failure

Opened Nov 8, 2024 · Closed Aug 20, 2025

Status: closed (inferred from source dates) · Engine

On November 8, 2024, the Office of Defects Investigation (ODI) opened Recall Query RQ24013 to assess the scope of Honda recall 23V-751 after receiving complaints that alleged connecting rod bearing failures in vehicles that were not within the scope of recall 23V-751. In November 2023, Honda recalled 248,999 various Model Year (MY)2016–2020 Honda and Acura vehicles equipped with the 3.5L V6 engine. Honda recalled these vehicles due to a crankshaft manufacturing defect that caused premature connecting rod bearing wear and engine seizure. While the out-of-scope failures involved in these complaints appear to have a very similar failure mechanism as the recalled engines, a thorough analysis of all available data from Honda has not indicated that the same manufacturing defect exists in the out-of-scope engines as the engines recalled by 23V-751. Based on this analysis ODI has determined that Honda has properly defined the scope of recall 23V-751. Consequently, ODI will close this RQ investigation.  NHTSA will continue to investigate these complaints of engine failure as part of a new Preliminary Evaluation Investigation (PE25008). The Agency reserves the right to take additional action if warranted by new circumstances.

PE22005 · No Restart After Auto Start/stop Engages

Opened Jun 3, 2022 · Closed Mar 26, 2025

Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (4)

Engine And Engine Cooling:engine:crank/camshaft Position Sensor

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Engine And Engine Cooling:engine

On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Preliminary Evaluation is being upgraded to an Engineering Analysis, EA25004, to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope for the Engineering Analysis to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaigns. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.