2013 Honda Pilot

MY DAUGHTER WAS BACKING OUT OF THE GARAGE ONTO A SLOPED DRIVEWAY, APPLIED THE BRAKE, SHIFTED INTO PARK GEAR SELECTOR, EXITED AUTO TO RETRIEVE SOMETHING FROM GARAGE. NOTICED THE CAR ROLLING , ATTEMPTED TO GET IN THE CAR, AS HER TWO CHILDREN WERE IN THE REAR (AGES 6 &9).CAR ROLLED OVER HER LEG, RESULTING IN MAJOR COMPOUND FRACTURE, RESULTING IN EXTENSIVE SURGERY, METAL ROD AND SCREWS IN HER LEG. CAR ROLLED BACKWARDS CROSSING STREET INTO DITCH. POLICE REPORT INDICATES ENGINE WAS STILL RUNNING WITH GEAR IN REVERSE . HONDA CASE #[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 10/21/2014 *JS

TL* THE CONTACT OWNS A 2013 HONDA PILOT. THE CONTACT STATED THAT A LOUD METAL NOISE EMITTED FROM THE FRONT DRIVER'S SIDE WHEN THE BRAKE PEDAL WAS ENGAGED, WHICH ALSO CAUSED THE VEHICLE TO VIBRATE. THE DEALER REPLACED THE FRONT BRAKES HOWEVER THE FAILURE WAS NOT CORRECTED. THE LOUD METAL NOISE WAS HEARD EACH TIME THE BRAKE WAS ENGAGED. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE DID NOT EXHIBIT A BRAKE FAILURE BECAUSE THEY WERE UNABLE TO HEAR THE NOISE THAT THE CONTACT WAS REFERENCING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000 AND THE CURRENT MILEAGE WAS 10,000. *TR

WHEN APPLYING THE BRAKES AT LOW SPEED DURING AN EMERGENCY STOP, THE BRAKE PEDAL DEPRESSED AND CONTINUED TO DEPRESS FURTHER TO A POINT WHERE THE LOCATION OF THE ACCELERATOR PEDAL WAS HIGHER THAN THE BRAKE PEDAL. THIS POSITION INTERFERES WITH THE PROPER APPLICATION OF THE BRAKE BY ALLOWING A CLOSE PROXIMITY TO THE HIGHER ACCELERATOR PEDAL, THUS THE DRIVER PUSHING BOTH PEDALS AT THE SAME TIME AND FORWARD MOTION WAS NOT STOPPED UNTIL I RELEASED AND REAPPLIED THE BRAKE, PAYING PARTICULAR ATTENTION TO WHERE MY FOOT WAS LOCATED. VERY UNSAFE ! I HAVE A SIZE 10 W MANS SHOE. I CAN'T IMAGINE SOMEONE WITH A LARGER FOOT SIZE BEING SAFE IN THIS VEHICLE. WHEN I RETURNED TO THE HONDA DEALER, I WAS TOLD THAT IT WAS JUST THE NATURE OF THE VEHICLE AND I NEED TO BASICALLY RETRAIN MY BRAIN AS TO THE POSITION OF THE PEDALS. I'VE DRIVEN FOR OVER 55 YEARS AND HAVE NEVER EXPERIENCED SUCH A PROBLEM WITH A VEHICLE. AND TO BE TOLD THAT AN OBVIOUS DEFECT AS BEING ACCEPTABLE AND SAFE BY THE MANUFACTURER, IS UNACCEPTABLE TO ME. *TR

I HAVE A 2013 PILOT AND I'M FINDING MY BRAKE PEDAL GOES TO THE FLOOR WHILE STOPPED AT A LIGHT. I HAVE 5,000 MILES ON THE VEHICLE AND I'M BEING TOLD THIS IS NORMAL BY THE DEALERSHIP. MY THINKING IS HAVING A BRAKE PEDAL GOING TO THE FLOOR IS NOT NORMAL FOR ANY VEHICLE. I BELIEVE THE DEALER IS NOT ADDRESSING THE CONCERN AND PUSHING AWAY FROM THE REAL SOLUTION. *TR

TL* THE CONTACT OWNS A 2013 HONDA PILOT. THE CONTACT STATED THAT THE BRAKES FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE MASTER CYLINDER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 2,000.

TL* THE CONTACT OWNS A 2013 HONDA PILOT. THE CONTACT STATED THAT EVERY TIME THE BRAKES WERE ENGAGED, THAT THE BRAKES WOULD SHUTTER AND THAT THERE WAS A VIBRATION ON THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE ROTORS FAILED AND NEEDED TO BE RE-FINISHED. THE REPAIR WAS MADE HOWEVER, THE REMEDY FAILED TO CORRECT THE PROBLEM. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO THEN REPLACED THE ROTORS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 23,000 AND THE CURRENT MILEAGE WAS 37,000. THE VIN WAS NOT AVAILABLE.

UPON APPLYING THE BRAKE IN AN AVOIDANCE SITUATION, I NOTICED THE SPONGY FEEL TO THE BRAKES. WHAT CONCERNS ME MORE, IS THAT DURING THE PROCESS OF THE EVENT, THE BRAKE PEDAL SETTLES DOWN TO BELOW THE HEIGHT OF THE ACCELERATOR AND IF YOUR FOOT ISN'T SQUARE ON THE BRAKE PEDAL, YOU WIND UP HITTING THE GAS WHILE TRYING TO STOP THE VEHICLE.. I NEED TO TALK WITH SOMEONE. THIS IS MOST CERTAINLY A DEFECT IN DESIGN. *TR

BRAKE PEDAL WAS SPONGY AND SEEMED TO GO DOWN TOO FAR. WHILE STOPPED WITH THE BRAKE PEDAL PRESSED AND MAINTAINING A CONSTANT PRESSURE ON THE PEDAL IT WOULD SLOWLY GO ALL THE WAY TO THE FLOOR. DEALER CHECKED IT OUT AND SAID MASTER CYLINDER WAS DEFECTIVE AND REPLACED SAME. APPROXIMATELY 4 WEEKS LATER WHILE DRIVING AT APPROXIMATELY 65 MPH A LOUD ROARING SOUND WAS NOTICED AND THEN A VERY NOTICEABLE VIBRATION BEGAN. PULLED OVER AND CHECKED TIRES AND NOTICED A SMELL THAT WAS ALMOST LIKE SOMETHING BURNING. THE HONDA DEALER WAS CLOSE BY SO I DROVE IT TO THE DEALER AND LEFT IT THERE AGAIN. AFTER CHECKING THE VEHICLE, THEY DECIDED THE PROBLEM WAS CAUSED BY CALIPER SLIDE PINS NOT RELEASING. THE MASTER CYLINDER WAS ADJUSTED ALONG WITH THE BRAKE PEDAL HEIGHT AND FREE PLAY. IT IS NOW 1 WEEK SINCE THAT WORK WAS PERFORMED AND ONCE AGAIN THE BRAKE PEDAL GOES TO THE FLOOR WITH CONSTANT PRESSURE APPLIED WHILE STOPPED AT A TRAFFIC LIGHT. *TR

PURCHASED NEW 2013 HONDA PILOT APPROXIMATELY 5/15/13. NOTICED OVER NEXT WEEK THAT BRAKE PEDAL HAS EXCESSIVE TRAVEL- REQUIRES PEDAL TO BE PUSHED MUCH FARTHER DOWN THAN SHOULD BE EXPECTED BEFORE THE BRAKES BEGIN TO ENGAGE, RESULTING IN LONGER STOPPING TIME/LENGTH. TOOK IN FOR SERVICE AT DEALERSHIP ON 5/28/13. DEALERSHIP RETURNED ON 5/30/13 STATING THEY WERE UNABLE TO FIND A PROBLEM. VEHICLE HAS NOT BEEN REPAIRED. CALLED ANOTHER DEALERSHIP- SERVICE PERSON STATED THAT THIS IS A KNOWN COMPLAINT FOR RECENT HONDA PILOTS, CAUSED BY BRAKE BOOSTER, AND IS NEITHER ADJUSTABLE NOR FIXABLE. VEHICLE ODOMETER CURRENTLY 600 MILES. *TR

TL* THE CONTACT OWNS A 2013 HONDA PILOT. THE CONTACT STATED THAT THE BRAKE FAILED TO ENGAGE AT NORMAL STOPPING DISTANCE AND THE BRAKE PEDAL FELT SOFT. WHEN DEPRESSED, THE BRAKE PEDAL WOULD TRAVEL PARTIALLY TO THE FLOORBOARD ACCOMPANIED BY AN ABNORMAL VIBRATION OCCURRED WHEN DRIVING 65 MPH. THE FAILURE WOULD OCCUR WHEN TRAVELING OVER A FLAT SURFACE OR WHEN THE CYLINDER WAS IN THIRD. THE VEHICLE WAS TAKEN TO THE DEALER AND A DIAGNOSTIC WAS PERFORMED THAT WAS UNABLE TO LOCATE A FAILURE CODE FOR THE VIBRATION OR THE BRAKE FAILURE. THE DEALER LOOSENED THE ENGINE AND THE TRANSMISSION BOLTS HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3 AND THE CURRENT MILEAGE WAS 2,400.