NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
11 reportsClear category filterMileage unknown · Sep 6, 2026
Electrical SystemUnknown Or Other
This is a failure of 2019-2020 Passport Pilot MOST Bus Network Recall of 2021. My Passport was serviced for 23-047 1923 FAKRA Service Cables at MOST Bus Network on October 26, 2023. The system has failed again. The Most system has popping, crackling and then goes out. Takes several minutes to recover. Presents the same safety…
Read full complaint
This is a failure of 2019-2020 Passport Pilot MOST Bus Network Recall of 2021. My Passport was serviced for 23-047 1923 FAKRA Service Cables at MOST Bus Network on October 26, 2023. The system has failed again. The Most system has popping, crackling and then goes out. Takes several minutes to recover. Presents the same safety hazard as the original recall I have video which I will show to the dealer on Thursday September 10, 2026
NHTSA ODI #11762440
Mileage unknown · Jun 26, 2026
Unknown Or Other
I was at a red light and all of a sudden my car switched to neutral. I could not get out of neutral and tried unsuccessfully to get my car into drive. I finally was able to shut the car off (not sure if opening the door helped reset the system) and start it again. I now turn off the idle option
NHTSA ODI #11746675
Mileage unknown · Mar 26, 2026
Unknown Or Other
don’t have the exact locations,date or time but this has happened around 5 times where I am driving and comes to a come a complete stop and my engine wouldn’t start,I had to put on my hazard lights turn off the vehicle then restart it
NHTSA ODI #11727178
Mileage unknown · Nov 12, 2025
Unknown Or Other
Burnt Oil Smell Inside Cabin (When Heater Is on High) I frequently notice a burnt oil smell inside the cabin, especially during the first hour of driving in the morning with the heater set to high. My local Honda dealership inspected the vehicle but did not find a specific cause, attributing it instead to a “Honda smell.” They d…
Read full complaint
Burnt Oil Smell Inside Cabin (When Heater Is on High) I frequently notice a burnt oil smell inside the cabin, especially during the first hour of driving in the morning with the heater set to high. My local Honda dealership inspected the vehicle but did not find a specific cause, attributing it instead to a “Honda smell.” They demonstrated a similar odor on a new Passport and suggested using a charcoal cabin filter. However, I remain concerned about a potential fire risk. Auto Idle Start-Stop Feature Unavailable The Auto Idle Start-Stop system rarely functions properly—it has worked approximately 10% of the time I’ve owned the vehicle. After each service visit, it temporarily resumes operation, then soon displays the message “Auto Idle Start-Stop Feature Not Available.” Blank Center Display / ‘MOST Net Off’ Message The center display intermittently goes blank or reboots repeatedly, showing a “MOST Net Off” message. This makes it difficult and distracting to navigate while driving. I understand a previous recall was intended to resolve this issue, but the problem persists.
NHTSA ODI #11698869
Mileage unknown · Mar 6, 2025
Unknown Or Other
On a cold winter day the vehicle would not start. With dangerous windchills this could have been very bad had the vehicle been further away from home. The battery and all systems in the vehicle were good. The Honda dealership diagnosed it as having a frozen starter (see attached doccument). Upon warming up the vehicle inside the…
Read full complaint
On a cold winter day the vehicle would not start. With dangerous windchills this could have been very bad had the vehicle been further away from home. The battery and all systems in the vehicle were good. The Honda dealership diagnosed it as having a frozen starter (see attached doccument). Upon warming up the vehicle inside the dealership garage, it started without issues. The dealership said the starter had froze due to condensation inside the starter and that a new version of the starter is available that prevents this from happening. The new starter cost $1600. As shown in the photos the starters are exactly the same but the new version is better sealed to prevent condensation. I feel this should be a recall due to the original part being defective and not sealed properly which caused failure. I have contacted Honda and they refuse to pay for any portion of this defect.
NHTSA ODI #11646843
Mileage unknown · Dec 20, 2024
Unknown Or Other
When the auto-start stop feature has stopped the engine at a red light, the engine will not start sometimes. The problem occurs at random and leaves me stalled at a red light and I cannot start the vehicle. Traffic behind me is held up; horns are honking. If I wait a couple of minutes I can start the 2020 Honda Passport that …
Read full complaint
When the auto-start stop feature has stopped the engine at a red light, the engine will not start sometimes. The problem occurs at random and leaves me stalled at a red light and I cannot start the vehicle. Traffic behind me is held up; horns are honking. If I wait a couple of minutes I can start the 2020 Honda Passport that I bought new. This has been a problem since I bought it new. I brought the Honda into the dealership and they can not fix it. It is a safety problem that the manufacturer will have to figure out and recall the vehicles. These Honda Passports are stalling in traffic without any warning.
NHTSA ODI #11631801
Mileage unknown · Nov 18, 2023
Unknown Or Other
I am constantly hearing a cracking noise through the dash. I thought it was the speaker, but I can hear it even when radio is off. At first it would come and go. Now, it is almost constant. It sounds like there is something rattling against a speaker.
NHTSA ODI #11555861
Mileage unknown · Jun 13, 2023
Unknown Or Other
I currently have a 2020 Honda Passport. When I am driving the radio system begins making loud cracking and popping sounds (almost as small things are hitting the windshield). The sounds can still be heard if I turn the entertainment system off. It doesn't matter if I turn the volume low if it always the same frequency. It will c…
Read full complaint
I currently have a 2020 Honda Passport. When I am driving the radio system begins making loud cracking and popping sounds (almost as small things are hitting the windshield). The sounds can still be heard if I turn the entertainment system off. It doesn't matter if I turn the volume low if it always the same frequency. It will continue on an off while driving for a few minutes and then it frequently make a very loud static sound abruptly before saying the network is no longer working. The sound is so sound and jarring it causes me to jump while driving because I never know when this is going to happen. I found and article online that stated: Common symptoms that Honda drivers have experienced in affected vehicles include popping or crackling sounds from the speakers, loss of sound from the audio system, network loss messages, and errors in the display screen. Also there was a Honda Bulletin in March 2019 - 11536Version 1 that states this exact issue was a problem in an earlier model- After realizing this because it has stated happening more frequently initial time it happened was probably prior to this one however we thought it was bugs hitting the windshield while we were driving at night time in a moral rural area.
NHTSA ODI #11526774
Mileage unknown · Apr 25, 2023
Unknown Or Other
My infotainment system cracks and blanks out often. It makes a very loud noise and seems to be even lounder than the radio is set at the time. It is very distracting. This is a new vehicle to me and when it happens, especially the first time, it scared me tremendously. It has also completely blanked the screen out from time t…
Read full complaint
My infotainment system cracks and blanks out often. It makes a very loud noise and seems to be even lounder than the radio is set at the time. It is very distracting. This is a new vehicle to me and when it happens, especially the first time, it scared me tremendously. It has also completely blanked the screen out from time to time as well. After researching online, this seems to be a common problem but no recall has been issued. I contacted my nearest dealer (Planet Honda, Golden CO) and they said that I could pay to have it checked out, but thats all they could do. the date listed is the first time it happened, a few days after purchased. It happens daily.
NHTSA ODI #11518930
Mileage unknown · May 25, 2021
Unknown Or Other
Not long after buying my car I noticed a popping sound from the speakers. I took it back to Honda in which they added a harness. This did nothing and the popping got louder to the point it became a distraction and even turning the radio panel off did nothing. The speakers would get hot along with a burning smell. I took it in fo…
Read full complaint
Not long after buying my car I noticed a popping sound from the speakers. I took it back to Honda in which they added a harness. This did nothing and the popping got louder to the point it became a distraction and even turning the radio panel off did nothing. The speakers would get hot along with a burning smell. I took it in for a 2nd time in which nothing was done and then the third time the speakers were re-wired. As of today the popping noise is back, I lose connection to all audio (Bluetooth, FM, AM, SirusXM, AndroidAuto, etc.) this makes it impossible to safely use the phone while driving down the road. Along with the popping the main screen continues to cycle through a black screen. Sometimes it comes up immediately sometimes it takes a few minutes. This is an issue when trying to back out of a driveway or parking space. Honda is well aware of the issue as they have sense released a bulletin stating that the problem will be fixed, but with the cavate that Honda be able to duplicate. Outside of hearing the popping sounds there is no warning of when the speakers and or screen with cease to work. These issues do not happen constantly but when they do are an issue at highway speeds. Outside of a harness, re-wiring and constantly re-setting the system there is nothing that Honda seems to be willing to do and drivers should just "deal" with it. The popping has been duplicated along with video evidence, they have also been able to duplicate the system losing connection as that is part of the bulletin and the back up camera issue has a recall but there has been no permanent fix on the speakers. None of the tried methods has seemed to fix many users issues and Honda continues to willfully ignore them.
NHTSA ODI #11418556
Official recalls
10Jun 4, 2026
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence & remedy
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Additional source detail variants (2)
Suspension:rear
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
Structure:frame And Members
American Honda Motor Company (Honda) is recalling certain 2016-2022 Honda Pilot, 2017-2023 Ridgeline, 2019-2023 Passport, and 2014-2020 Acura MDX vehicles that were sold in Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, or Wisconsin. The rear subframe may corrode at the suspension mounting points, which can result in rear suspension component failure.
Consequence: Failure of rear suspension components, such as the rear control arm, can cause a loss of vehicle handling and control, increasing the risk of a crash or injury.
Remedy: Dealers will inspect the rear subframe and install a rear subframe reinforcement kit and, as necessary, repair or replace the rear subframe components, free of charge. Interim letters notifying owners of the safety risk were mailed July 27, 2026. Additional letters will be sent once the final remedy is available, anticipated in the fall of 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are AOU and AOT. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning June 10, 2026.
May 21, 2026
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Feb 1, 2024
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Jun 15, 2023
Honda (American Honda Motor Co.) is recalling certain 2018-2023 Odyssey, 2019-2022 Pilot, and 2019-2023 Passport vehicles. Due to a faulty Media Oriented Systems Transport (MOST) communication coaxial cable connector, the rearview camera image may not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will replace the MOST cable harness and install a straightening cover over the vehicle cable connector, free of charge. Owner notification letters were mailed July 24, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are EEL, ZEM, and SFC.
Mar 16, 2023
Honda (American Honda Motor Co) is recalling certain 2020-2021 Pilot and Ridgeline, and 2020-2022 Passport and Odyssey vehicles. The heating pads behind both side-view mirrors may not be bonded properly, allowing the mirror glass to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: Detached mirror glass can reduce driver visibility, increasing the risk of a crash.
Remedy: Dealers will replace both left and right side-view mirrors, free of charge. Owner letters were mailed January 17, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is FE5.
Mar 11, 2021
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Passport and Pilot vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Overcured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation, which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash or injury.
Remedy: Honda will notify owners, and dealers will inspect all four tires and replace them as necessary, free of charge. The recall began April 22, 2021. Owners may contact American Honda Motor Co. customer service at 1-888-234-2138. Honda's number for this recall is UA2.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence & remedy
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Odyssey, 2019-2020 Passport, and 2019-2021 Pilot vehicles. Incorrect instrument panel control module software can cause the instrument panel to not display critical information, such as engine oil pressure, speedometer, and gear selector position until the next ignition cycle. Additionally, it can prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 111, "Rearview Mirrors."
Consequence: Operating a vehicle without a functioning instrument panel or rearview camera display increases the risk of a crash.
Remedy: Honda will notify owners, and dealers will reprogram the instrument panel control module software, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is T89.
Jul 28, 2020
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Electrical System:software
Honda (American Honda Motor Co.) is recalling certain 2019-2021 Pilot, 2019-2020 Odyssey and 2019-2020 Passport vehicles. Incorrect central network software programming may cause several errors to occur that can delay or prevent the rearview camera image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence: A delayed or inoperative rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Honda will notify owners that updated software is available. Owners have the option to either follow the mailed instructions to download and update the software for free, or visit a dealer to have the software update performed, free of charge. The recall began September 23, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is Y7Y.
Feb 6, 2020
Honda (American Honda Motor Co.) is recalling certain 2020 Passport and Pilot vehicles. The certification label may have been printed with ink that can be wiped away with a solvent, removing the Gross Axle Weight Rating (GAWR) and Gross Vehicle Weight Rating (GVWR) information.
Consequence & remedy
Consequence: If the operator is unable to refer to the label information, the vehicle may be overloaded, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the certification label, free of charge. The recall began March 24, 2020. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is B6T.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25002 · Inadvertent Automatic Emergency Braking
Opened Jan 17, 2025 · No close date supplied
Status: open (inferred from source dates) · Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the investigation is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24008 · Inadvertent Automatic Emergency Braking
Opened Mar 7, 2024 · Closed Jan 17, 2025
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Forward Collision Avoidance
On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration