my frame was rusted throughout at 130k miles the car's rear trail arm mount on the frame detached and almost caused me to run into on by traffic numerous times at 25 mph. only once I stopped to pick up my sons from school the car's rear trail arm detached completely from the frame, I had deemed it undrivable and called for someo…
Read full complaint
my frame was rusted throughout at 130k miles the car's rear trail arm mount on the frame detached and almost caused me to run into on by traffic numerous times at 25 mph. only once I stopped to pick up my sons from school the car's rear trail arm detached completely from the frame, I had deemed it undrivable and called for someone to come by and tow it back home. on my own further inspection, I noticed an absurd amount of rust in the rear left side, and holes in the frame. as well as I said the rear trail arm detached from the frame.
NHTSA ODI #11431804
81,400 miles · Dec 26, 2019
Suspension
THE DRIVERS SIDE TRAILING ARM BRACKET BROKE OFF OF THE FRAME DUE TO EXTREME RUST AS I WAS DRIVING.
NHTSA ODI #11291339
225,000 miles · Apr 13, 2019
Suspension
I NOTICED THAT MY 1999 HONDA PASSPORT HAD A RECALL FOR THE SUSPENSION. I CALLED THE DEALER HERE IN LEXINGTON KY DON JACOBS AND SET UP AN APPOINTMENT. THE DAY BEFORE MY APPOINTMENT I CALLED TO VERIFY THAT THEY HAD THE PARTS THAT WAS NEEDED AND WAS TOLD THAT THEY COULD NOT FIX MY VEHICLE BECAUSE THEY COULD NOT GET THE PARTS OR T…
Read full complaint
I NOTICED THAT MY 1999 HONDA PASSPORT HAD A RECALL FOR THE SUSPENSION. I CALLED THE DEALER HERE IN LEXINGTON KY DON JACOBS AND SET UP AN APPOINTMENT. THE DAY BEFORE MY APPOINTMENT I CALLED TO VERIFY THAT THEY HAD THE PARTS THAT WAS NEEDED AND WAS TOLD THAT THEY COULD NOT FIX MY VEHICLE BECAUSE THEY COULD NOT GET THE PARTS OR TOOLS TO REPAIR MY VEHICLE.
NHTSA ODI #11195978
122,000 miles · Apr 13, 2017
Suspension
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE SON WAS DRIVING AND THE REAR DRIVERS SIDE SUSPENSION DETACHED FROM THE FRAME. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED BACK TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMP…
Read full complaint
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE SON WAS DRIVING AND THE REAR DRIVERS SIDE SUSPENSION DETACHED FROM THE FRAME. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED BACK TO THE CONTACTS RESIDENCE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 10V436000 (SUSPENSION) HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT THAT DUE TO THEM NOT BEING THE ORIGINAL OWNER OF THE VEHICLE AND THE RECALL EXPIRING, THERE WAS NO FURTHER ASSISTANCE THAT COULD BE PROVIDED THE FAILURE MILEAGE WAS APPROXIMATELY 122,000. UPDATED 06/02/17*LJ *CN
NHTSA ODI #10972195
220,000 miles · Mar 7, 2017
Suspension
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. WHILE THE VEHICLE WAS STATIONARY, THE REAR SUSPENSION SUPPORT SYSTEM WAS RUSTED AND SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 220,000.
NHTSA ODI #10959072
Mileage unknown · May 31, 2015
Suspension
THE REAR TRAILING ARM HAS BROKEN AWAY FROM SEVERE FRAME RUST. THERE WAS A RECALL FOR THIS EXACT PROBLEM IN 2010 BUT IT ONLY RECALLED CARS FROM THE NORTHEASTERN STATES. THIS CAR WAS NOT RECALLED EVEN THOUGH IT IS AND HAS BEEN IN ALASKA. I BELIEVE THE ENVIRONMENTAL CONDITIONS HERE ARE JUST AS SEVERE AS THE NORTHEASTERN STATES AND …
Read full complaint
THE REAR TRAILING ARM HAS BROKEN AWAY FROM SEVERE FRAME RUST. THERE WAS A RECALL FOR THIS EXACT PROBLEM IN 2010 BUT IT ONLY RECALLED CARS FROM THE NORTHEASTERN STATES. THIS CAR WAS NOT RECALLED EVEN THOUGH IT IS AND HAS BEEN IN ALASKA. I BELIEVE THE ENVIRONMENTAL CONDITIONS HERE ARE JUST AS SEVERE AS THE NORTHEASTERN STATES AND THE RECALL SHOULD EXTEND HERE ALSO.
NHTSA ODI #10722498
129,523 miles · Apr 11, 2014
Suspension
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE REAR OF THE VEHICLE SWAYED TO THE RIGHT. THE BUMPER AND TRAILER HITCH BECAME DETACHED AND CAUSED THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT MENTIONED THAT THE VEHICLE HAD BEEN SWAYING ABNORMALLY FOR QUITE SOME…
Read full complaint
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE REAR OF THE VEHICLE SWAYED TO THE RIGHT. THE BUMPER AND TRAILER HITCH BECAME DETACHED AND CAUSED THE CONTACT TO LOSE CONTROL OF THE VEHICLE. THE CONTACT MENTIONED THAT THE VEHICLE HAD BEEN SWAYING ABNORMALLY FOR QUITE SOME TIME AND THAT THE VEHICLE ALSO SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT ALSO STATED THAT THE REAR AXLE AND BUMPER WERE EXTREMELY RUSTED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBERS 10V436000 (SUSPENSION) AND 00V058000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 129,523.
NHTSA ODI #10579254
116,000 miles · Aug 11, 2013
StructureSuspensionWheels
LAST YEAR I NOTICED RUST THAT HAD BECOME A GAPING HOLE IN THE LOWER PART- REAR AXLE FRAME OF MY HONDA PASSPORT'S . RECENTLY WHEN I WAS DRIVING REAL AXLE FRAME CRACKED WITH A LOUD NOISE. TEMPORARY WELDING IS DONE . I CHECKED WITH HONDA SERVICE, CAR BODY REPAIR AND LOCAL MECHANIC -NO ONE ASSURED THAT IT CAN BE FIXED. AND FINALL…
Read full complaint
LAST YEAR I NOTICED RUST THAT HAD BECOME A GAPING HOLE IN THE LOWER PART- REAR AXLE FRAME OF MY HONDA PASSPORT'S . RECENTLY WHEN I WAS DRIVING REAL AXLE FRAME CRACKED WITH A LOUD NOISE. TEMPORARY WELDING IS DONE . I CHECKED WITH HONDA SERVICE, CAR BODY REPAIR AND LOCAL MECHANIC -NO ONE ASSURED THAT IT CAN BE FIXED. AND FINALLY IT MAKES THE CAR IMPOSSIBLE TO SELL. PLEASE HELP ME ON THIS. I AM THE THIRD OWNER VIN NO: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10534797
148,000 miles · May 21, 2013
Engine And Engine CoolingPower TrainSteering
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION OIL GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION OIL GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 148,000. ..UPDATED 07-17-13 *BF THE BALL JOINTS, EXHAUST, TIE ROD END, ENGINE GASKETS, SWAY BAR LINKS AND TIMING BELT ALL NEEDED TO BE REPLACED.
NHTSA ODI #10513029
154,000 miles · Mar 4, 2013
EnginePower TrainSuspension
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE REAR SUSPENSION LOWER LINK BRACKET WAS FRACTURED DUE TO EXCESSIVE CORROSION. IN ADDI…
Read full complaint
TL* THE CONTACT OWNS A 1999 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE REAR SUSPENSION LOWER LINK BRACKET WAS FRACTURED DUE TO EXCESSIVE CORROSION. IN ADDITION, THE MECHANIC STATED THAT THE VEHICLE WAS NOT REPAIRABLE BECAUSE THE FRAME WAS ALSO CORRODED AND THE BRACKET COULD NOT BE WELDED BACK ONTO THE FRAME. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 154,000. ..UPDATED 04/18/13 *BF THE CONSUMER STATED HE FINALLY FOUND A FRAME RESTORATION SHOP. THEY CUT OUT ALL OF THE RUSTED FRAME AREAS ON THE REAR DRIVER SIDE AND MADE A NEW END FOR THE LOWER LINK BRACKET. THE CONSUMER ALSO STATED THE CATALYTIC CONVERTER BECAME CLOGGED AND RUINED THE ENGINE. THE FRONT AXLES WERE REPLACED TWICE. THE VEHICLE HAD AN OIL LEAK AND TRANSMISSION LEAK. UPDATED 04/23/13
ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.
Consequence & remedy
Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequence & remedy
Consequence: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA09018 · Rear Suspension Lower Link Detachment
Opened Dec 7, 2009 · Closed Oct 15, 2010
Status: closed (inferred from source dates) · Suspension; Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Additional source detail variants (2)
Suspension
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
Suspension:rear
On September 22, 2010, Isuzu Manufacturing Services of America, Inc (Isuzu) submitted a Defect Information Report (NHTSA Recall 10V-436) to the National Highway Traffic Safety Administration affecting approximately 120,000 model year (MY) 1998-2002 Isuzu Rodeo and Honda Passport vehicles and MY 2002 Isuzu Axiom vehicles originally sold, or currently operated, in the following states:Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. All vehicle owners will receive the recall notification.Vehicles 10 years of age or younger will be provided with a free remedy.For vehicles older than 10 years, Isuzu will offer a free remedy provided the vehicle is presented to an Isuzu service facility or a Honda dealer (as applicable) no later than twelve (12) months after the date of mailing of the notification letter to the owner.The report describes a condition where vehicles operated in states using certain road deicing materials may exhibit excessive corrosion which may result in the left or right rear suspension lower link bracket becoming detached from the frame.According to Isuzu a detached lower link may affect vehicle handling and potentially cause a crash.The Office of Defects Investigation (ODI) analyzed complaint data and found that 114 of the 115 (99%) alleged complete lower link separations from the frame occurred in vehicles originally sold or operated in a state covered by the recall. Of these complaints 2 involved alleged crashes and 21 involved alleged loss of control incidents.The alleged crashes and loss of control incidents all occurred in vehicles operated in a state covered by the safety recall.Isuzu's recall instructs dealers to inspect the rear suspension lower link bracket area to determine if corrosion is present.For vehicles in which corrosion has damaged the lower link bracket area and affected its connection to the vehicle frame, a reinforcement bracket will be installed.For vehicles with no visible signs of corrosion, dealers with apply anti-corrosion material to reduce the likelihood of corrosion developing in the future. Based on Isuzu's safety recall, this Engineering Analysis is closed.A copy of the recall may be assessed on NHTSA's website using the reference number above.
PE09030 · Rear Suspension Lower Link Failure
Opened Jun 16, 2009 · Closed Dec 8, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (2)
Suspension
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Suspension:rear
DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE VEHICLE IS STILL CONTROLLABLE AND CAN BE SAFELY STOPPED. THE OFFICE OF DEFECT INVESTIGATION (ODI) ANALYZED COMPLAINT DATA PROVIDED BY ISUZU AND AMERICA HONDA MOTOR COMPANY, INC (HONDA), AS WELL AS VEHICLE OWNER QUESTIONNAIRES SUBMITTED TO ODI FROM CONSUMERS.IN TOTAL, THERE WERE 60 UNIQUE REPORTS OF LOWER LINK SEPARATIONS FROM THE FRAME INCLUDING 1 ALLEGED CRASH AND 7 LOSS OF VEHICLE CONTROL INCIDENTS THAT MAY BE RELATED TO THE ALLEGED DEFECT.MOST OF THESE COMPLAINTS INDICATED THAT THERE WAS NO WARNING PRIOR TO THE LINK SEPARATION.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-018) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA99008 · Braking System/abs
Opened Mar 31, 1999 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
1999 Honda Passport Problems, Complaints & Recalls | Skip That Year
Illustration