The vehicles electrical power steering , gearbox worm wheel and improperly set work gear spring caused a car accident where me and my daughter where thankfully only left with bruises and a concussion. Shortly after my accident a recall was sent out for the steering wheel upon further inspection it was determined the cause of the…
Read full complaint
The vehicles electrical power steering , gearbox worm wheel and improperly set work gear spring caused a car accident where me and my daughter where thankfully only left with bruises and a concussion. Shortly after my accident a recall was sent out for the steering wheel upon further inspection it was determined the cause of the accident where it was replaced and I had to cover damages done to the car out of pocket. Dealership did not disclose any malfunctions.
NHTSA ODI #11677694
Mileage unknown · Jul 25, 2025
Steering
What component or system failed or malfunctioned, and is it available for inspection upon request? My steering rack is damaged and needs replacement (confirmed by Honda Dealership). This causes the steering wheel to get stuck into place (mainly left side). To dislodge it you need to jerk it to the other side which causes the veh…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? My steering rack is damaged and needs replacement (confirmed by Honda Dealership). This causes the steering wheel to get stuck into place (mainly left side). To dislodge it you need to jerk it to the other side which causes the vehicle to become unstable. I first noticed this problem on March 20, 2025. I ignored it at first, but the problem got worse with time until last week my steering wheel locked into place and sent me into the left lane. Luckily there were no cars on the road, as this would have caused a major accident. This issue is life threatening to both myself and other drivers on the road. How was your safety or the safety of others put at risk? Yes Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, attached scan below. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes, by Honda Dealership Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, no warnings, the problem just began. This problem was documented in NHTSA campaign #23V704000.
NHTSA ODI #11676296
35,000 miles · Jul 2, 2025
Steering
The contact owns a 2022 Honda Civic. The contact stated while driving at various speeds, the steering wheel was shaking with an abnormal ticking sound coming from the steering. There was no warning light illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was n…
Read full complaint
The contact owns a 2022 Honda Civic. The contact stated while driving at various speeds, the steering wheel was shaking with an abnormal ticking sound coming from the steering. There was no warning light illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.
NHTSA ODI #11670701
Mileage unknown · Jul 1, 2025
Power TrainSteeringStructureCrash
I took my vehicle to the dealer after receiving the first recall notice. They inspected it and informed me that my car was not part of the recall, so they returned it to me. However, I continued to receive recall letters and communications from attorneys regarding the issue. According to the dealer, my car was in good condition.…
Read full complaint
I took my vehicle to the dealer after receiving the first recall notice. They inspected it and informed me that my car was not part of the recall, so they returned it to me. However, I continued to receive recall letters and communications from attorneys regarding the issue. According to the dealer, my car was in good condition. Despite this, I recently noticed unusual movement in the steering wheel, which ultimately caused me to crash into a concrete pole.
NHTSA ODI #11670656
Mileage unknown · Jun 27, 2025
Steering
Sticky Steering & Fluctuating Steering Torque. Car loses control due to this steering problem. There was a recall for this problem (SJS 2022-25 Civic EPS Grbx Greasing Saf Rec). Dealer repaired the recall but the issue came after short period of time. So the the repair was not done properly.
NHTSA ODI #11669737
Mileage unknown · Jun 22, 2025
Steering
There are 2 recalls on this car. A gearbox and power steering rack, the dealer has not replaced either one of them. They greased the power steering rack, and that's it. When steering to the right or left, there's a very large grinding sound and they are stating that it did not come from a power steering rack, faulty, they didn't…
Read full complaint
There are 2 recalls on this car. A gearbox and power steering rack, the dealer has not replaced either one of them. They greased the power steering rack, and that's it. When steering to the right or left, there's a very large grinding sound and they are stating that it did not come from a power steering rack, faulty, they didn't even check the power steering rack or the gearbox, all they did was grease the power steering rack. I want this remedied, my daughter drives this car and there's something going on with the power steering rack, and it is starting to affect other issues in the car, tie rods, bearings etc and that's not fair. The manufacturer should be replacing these items. Steering components are a huge safety issue in this car and the manufacturer at the dealership will not replace these items.
NHTSA ODI #11668409
Mileage unknown · Jun 8, 2025
Steering
I BOUGHT MY CAR IN SEPT 2024 THROUGH CARVANA RIGHT AWAY I NOTICED THE STEERING WAS STICKY SO I BROUGHT IT TO A DEALERSHIP IN JAN 2025 AND WHEN I TOLD HIM THERE WAS SOMETHING WRONG W/ MY STEERING THAT IT WOULD KIND OF STICK WHEN TURNING HE SAID IT WAS A RECALL AND THEY WOULD FIX IT FOR FREE SO THEY 'FIXED' IT AND AFTER I PICKED I…
Read full complaint
I BOUGHT MY CAR IN SEPT 2024 THROUGH CARVANA RIGHT AWAY I NOTICED THE STEERING WAS STICKY SO I BROUGHT IT TO A DEALERSHIP IN JAN 2025 AND WHEN I TOLD HIM THERE WAS SOMETHING WRONG W/ MY STEERING THAT IT WOULD KIND OF STICK WHEN TURNING HE SAID IT WAS A RECALL AND THEY WOULD FIX IT FOR FREE SO THEY 'FIXED' IT AND AFTER I PICKED IT UP IT WAS STILL DOING IT, WELL NOW I BRING IT BACK AND THEY TELL ME I NEED A NEW STEERING RACK, ON A 2022 HONDA CIVIC SPORT, ARE YOU SERIOUS? AND THAT IT WILL COST $3700.00. SO THE DEALERSHIP DID CONFIRM I NEED A NEW STEERING RACK, THE STEERING ALWAYS STUCK SINCE I BOUGHT IT I DIDNT NOTICE IT WHEN I FIRST DROVE IT BECAUSE IT STARTS AFTER THE CAR IS WARMED UP LIKE THE FIRST 10 OR 15 MILES ITS OK THEN IT STARTS STICKING. I HAD JUST READ ON A SOCIAL MEDIA PLATFORM THAT QUITE A FEW PEOPLE HAVE HAD THIS SAME PROBLEM AND THEY SAID THEY FILED A COMPLAINT W/NHTSA AND YOU GUYS WERE DOING AN INVESTIGATION SO I THOUGHT I WOULD FILE A COMPLAINT AS WELL
NHTSA ODI #11665565
Mileage unknown · Jun 6, 2025
Lane DepartureSteeringWheels
Found out the my car has a recall last december 2024. I drove to my dealership and told them about it. they said they dont have available parts for the recall in my car and the service advisor I talked to was told me that they have the parts for the recall but they prioritize the newer car so that they can sell it. then I called…
Read full complaint
Found out the my car has a recall last december 2024. I drove to my dealership and told them about it. they said they dont have available parts for the recall in my car and the service advisor I talked to was told me that they have the parts for the recall but they prioritize the newer car so that they can sell it. then I called the manufacturer and let them know what the dealership was told me. 2 days later the manufacturer called me and said that they contacted my dealership and letting me know that they were be able to fix my car about the safety recall. but after I drove my car to my dealership and got it fixed and its all good as they said, but when I drove my car nothing change and its gets more difficult to control the steering wheel until now. most drivers thinks I'm drunk and keep their distance away from my car. then I brought my car back to the dealership and told them about it and they said they already done the repaired and got it fix but the repaired seems unsuccessful.
NHTSA ODI #11665402
Mileage unknown · May 2, 2025
Steering
When driving at any speed above 30mph the steering wheel sticks. This is quite scary and has cause some very close calls when driving down the busy highway. I have taken it to the dealership several times and they have yet to fix this dangerous issue.
NHTSA ODI #11658571
Mileage unknown · Apr 10, 2025
Steering
The steering wheel has a difficult time making small adjustments. The adjustments feel like the steering wheel is stuck and requires additional effort to make small adjustments.
Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.
Consequence & remedy
Consequence: Air bags that deploy unintentionally during a crash increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.
Honda (American Honda Motor Co.) is recalling certain 2023-2025 Acura Integra, Civic Type R, CR-V Hybrid, CR-V, HR-V, 2022-2025 Civic, Civic Hatchback, 2024-2025 Acura Integra Type S, 2025 CR-V Fuel Cell EV, Civic Hybrid, and Civic Hatchback Hybrid vehicles. The steering gearbox assembly may have been manufactured incorrectly, which can cause excessive internal friction and lead to difficulty steering the vehicle.
Consequence & remedy
Consequence: Difficulty steering can increase the risk of a crash.
Remedy: Dealers will replace the worm gear spring and redistribute or add grease as necessary, free of charge. Owner notification letters were mailed November 18, 2024. Owners may contact Honda Customer Service at 1-888-234-2138. Honda's numbers for this recall are SJS, MJU, QJT and VJV.
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Honda (American Honda Motor Co.) is recalling certain 2022-2024 Civic 4-door and Civic 5-door vehicles that received a replacement power steering rack as part of a service repair. The steering rack may have been incorrectly assembled, which can allow the tire to chafe against the lower suspension or tie rod end, possibly resulting in tire damage.
Consequence & remedy
Consequence: A damaged tire can fail and increase the risk of a crash or injury.
Remedy: Dealers will inspect and replace the electric power steering rack, as necessary, free of charge. Owner letters were mailed January 16, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is YFW.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA23003 · Momentary Increased Steering Effort
Opened Nov 29, 2023 · Closed Jan 28, 2025
Status: closed (inferred from source dates) · Steering
On November 29, 2023, the Office of Defects Investigation (ODI) opened this Engineering Analysis (EA23003) to assess allegations of momentary increase in steering effort in model years (MY) 2022-2023 Honda Civic, 2023MY Honda CR-V, and 2023MY Acura Integra vehicles (subject vehicles). The complaints received by ODI alleged that the subject vehicles experienced a momentary increase in required steering effort (described as “sticky steering”) occurring mostly at highway speeds after driving for an extended amount of time; these complaints could not be duplicated during dealer service technicians’ quick test drives. The complaints had been received over the previous two years with most occurring with low vehicle mileage. The steering gear of these vehicles is aided by an electrical power assist unit. This power assist unit inputs force on the steering rack via a worm gear and worm wheel assembly. During PE23005, Honda stated this condition of momentary increase in steering effort occurs due to two factors within this power assist unit. First, during manufacturing, the steering worm wheel goes through annealing and component conditioning processes. These processes cause internal stress and strain within the steering worm wheel. This strain is slowly released over the first few months of the vehicle life. Over time, the released strain causes deformation of the teeth on the worm wheel, causing the worm gear to catch on the worm wheel. This catching results in the driver’s momentary increased steering effort. Second, the manufacturing process did not guarantee consistent grease application and, therefore, some subject vehicles received insufficient grease which contributed to the momentary increase in steering effort. During EA23003, ODI further analyzed the potential safety related consequences of the momentary increase in steering effort. NHTSA’s Vehicle Research and Test Center (VRTC) duplicated the allegations of increased steering effort. In addition, VRTC discovered the steering worm wheel and worm gear tended to push grease out of the meshing area, resulting in large amounts of grease resting on top of the worm wheel. Information Request responses collected and reviewed by ODI showed Honda had also discovered this additional root cause during NHTSA’s EA. In addition, Honda discovered the preload of the worm wheel gear spring was set too high, increasing the gear slide load and resulting in higher friction and increased torque fluctuation when steering. The number of consumer complaints made to ODI continued to increase with the expansion of scope from the PE to the EA. Additionally, during EA23003, ODI received ten complaints alleging a crash, in addition to the 13 complaints ODI had received as of the time it opened EA23003. In total, 23 crashes have been reported to ODI due to this alleged defect. On October 3, 2024, Honda filed NHTSA Recall No. 24V-744 to address this defect. The recall will provide consumers with a new steering worm wheel gear spring with a decreased load. Additionally, dealerships will add additional grease and relocate any grease sitting on top of the worm wheel back into the meshing area. The scope of this recall includes all Honda vehicles that were manufactured with this specific improperly produced steering worm wheel and spring. In view of the recall action being taken by Honda, ODI is closing EA23003. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23005 · Momentary Increased Steering Effort
Opened Mar 17, 2023 · Closed Nov 30, 2023
Status: closed (inferred from source dates) · Steering
On March 17, 2023, The Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE23-005) to access the alleged defect of momentary increase in steering effort in model years (MY) 2022 and 2023 Honda Civic vehicles. The complaints report that the momentary increase in steering effort (described as "sticky steering") occurs mostly at highway speeds after driving for a certain amount of time. The reports have been received over the past 2 years with most occurring with low vehicle mileage. The steering gear contains a unit that includes a worm gear and a worm wheel. Honda stated this condition of momentary increase in steering effort occurs due to two factors within this unit. During manufacturing, the worm wheel goes through annealing and component conditioning processes. These processes caused internal stress and strain within the worm wheel. This strain was slowly released over the first few months of the vehicle life. Over time, the released strain caused the deformation of the teeth on the worm wheel, causing the worm gear to catch on the worm wheel. This results in the consumer’s momentary increased in steering effort. Also, the manufacturing process did not guarantee consistent grease application and therefore, some vehicles within the scope received too little grease which contributes to the momentary increase in steering effort. Analysis of all relevant data indicates that the subject condition occurs early in the vehicle’s life primarily in winter months. Additionally, the subject vehicles need to be driven in a straight line for a period of time, possibly until the vehicle is warmed up, to recreate the condition. The condition does not illuminate a malfunction indicator light (MIL). Some complaints allege Honda dealerships are unable to recreate the condition or state this is a normal vehicle operation. However, Honda released Service Bulletin 23-037 in July of 2023 which accurately describes the condition. To address this issue, Honda directs dealerships to remove the electronic power steering (EPS) gearbox and replace with a new gearbox. Further, Honda stated that the worst case steering effort from all warranty returned parts tested was 2.4 pounds. ODI complaint traffic remains steady. ODI has received 13 crashes to date, 11 of which allege roadway departure due to not being able to overcome the momentary increased steering effort prior to their vehicle leaving the roadway. The remaining 2 incidents claim overcorrection of the steering wheel. PE23-005 has been upgraded to an Engineering Analysis (EA23-003) to further assess the scope, frequency and potential safety related consequences of the momentary increase of steering effort. Further the scope has been expanded to include assessment of the Acura Integra and Honda CR-V models. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration