IllustrationCONSUMER WAS LEANING ON THE AIR CLEANER & PLASTIC PIPE THAT IS CONNECTED TO THE RADIATOR BY A SCREW. THE WEIGHT OF RIGHT HAND LEANING ON THE AIR INLET PIPE CAUSED CRACK IN THE TOP OF THE RADIATOR RESULTING IN ANTI-FREEZE SQUIRTED OUT & BURNED THE CONSUMER .*YH
1991 Honda Civic
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Honda Civic do not stand out strongly from the model-year median of 183.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Civic years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 110 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports4 fire reports13 injury reports
Engine And Engine Cooling complaints
5 reportsENGINE FIRE DUE TO FAILURE OF THE INJECTION SYSTEM. MJS
WHILE DRIVING VEHICLE WILL STALL UNEXPECTEDLY WITHOUT WARNING, WHICH ALMOST MAY RESULT IN AN CRASH. BEEN TO DEALER SEVERAL TIMES. DEALER CANNOT DETERMINE THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION AND VIN#. *AK
THE AIR CONDITIONER FAILED IN 1996. CAROLINA IMPORTS REPLACED IT ($900), AND MENTIONED THAT THEY HAD REPLACED MANY AIR CONDITIONERS FROM 1991 HONDA CIVICS. THE REPLACEMENT AIR CONDITIONER HAS SPRUNG AN UNIDENTIFIED LEAK TWICE, SPILLING OUT ALL FREON (@$250). IT ALSO SPRANG ONE IDENTIFIED LEAK, WHICH WAS FIXED. THE BACK TRUNK…
Read full complaint
THE AIR CONDITIONER FAILED IN 1996. CAROLINA IMPORTS REPLACED IT ($900), AND MENTIONED THAT THEY HAD REPLACED MANY AIR CONDITIONERS FROM 1991 HONDA CIVICS. THE REPLACEMENT AIR CONDITIONER HAS SPRUNG AN UNIDENTIFIED LEAK TWICE, SPILLING OUT ALL FREON (@$250). IT ALSO SPRANG ONE IDENTIFIED LEAK, WHICH WAS FIXED. THE BACK TRUNK HAS BEEN LEAKING FOR YEARS. WHEN THE TRUNK IS RAISED, WATER POURS DOWN IN THE TRUNK FROM THE RAISED SECTION. WATER ALSO LEAKS IN THE TRUNK WHEN IT IS CLOSED. HONDA SPECIALISTS (RTP, NC) SAID THEY HAVE SEEN THIS SEVERAL TIMES IN 1990 AND 1991 CIVIC MODELS, AND THAT IT IS A STRUCTURAL DEFECT WHICH CANNOT BE FIXED. THE DASHBOARD LIGHTINIG FLICKERS AND GOES OFF ABOUT ONCE A MONTH. IT COMES BACK ON IF THE DASHBOARD IS BANGED ON. THE MUFFLER WAS REPLACED DUE TO LARGE HOLES IN THE EARLY 1990'S. THANKFULLY I GOT A LIFETIME WARRANTY ON THE MUFFLER, BECAUSE I HAVE REPLACED IT TWICE. BOTH TIMES DUE TO HOLES. *AK
VEHICLE STALLS WHEN COMING TO STOP. *TW
Official recalls
195V103001 · Seat Belts:front:buckle Assembly
May 24, 1995
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
Consequence & remedy
Consequence: THE SAFETY BELTS WOULD NOT PROVIDE ADEQUATE PROTECTION TO AN OCCUPANT IN A VEHICLE CRASH.
Remedy: OWNERS SHOULD PROMPTLY CHECK THE CONDITION AND OPERATION OF BOTH FRONT SAFETY BELT BUCKLES. CAREFULLY INSPECT THE RED RELEASE BUTTON FOR ANY BREAKS OR CRACKS. CHECK THAT BOTH BUCKLES ARE OPERATING PROPERLY BY INSERTING EACH LATCH PLATE INTO ITS BUCKLE, TUG ON THE BELT TO MAKE SURE THE LATCH IS SECURELY LOCKED, THEN PRESS THE RELEASE BUTTON. THE LATCH PLATE SHOULD POP OUT OF THE BUCKLE WHEN THE BUTTON IS PRESSED. IF EITHER RELEASE BUTTON SHOWS ANY SIGN OF BREAKAGE OR CRACKING, OR IF EITHER BUCKLE FAILS TO OPERATE PROPERLY, PROMPTLY CONTACT YOUR AUTHORIZED HONDA/ACURA DEALER TO SCHEDULE AN APPOINTMENT TO HAVE THE BUCKLE REPLACED OR REPAIRED, FREE OF CHARGE. THE MANUFACTURER IS DEVELOPING A REMEDY DESIGNED TO PREVENT THE FAILURE OF THE BUTTONS THAT ARE NOT CURRENTLY BROKEN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA94035 · Seat Belt Buckle Failure
Opened Oct 27, 1994 · Closed Jul 31, 1995
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE94052 · Seat Belt Buckle Fails
Opened Jul 11, 1994 · Closed Oct 27, 1994
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE93082 · Stalling
Opened Sep 23, 1993 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available