NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,520 reports136,000 miles · Aug 21, 2015
Power Train
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. WHILE DRIVING APPROXIMATELY 5 MPH, THE TRANSMISSION HESITATED AND THE RPMS INCREASED RAPIDLY. THE ENGINE, VSA, AND TIRE PRESSURE MONITORING SYSTEM WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE …
Read full complaint
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. WHILE DRIVING APPROXIMATELY 5 MPH, THE TRANSMISSION HESITATED AND THE RPMS INCREASED RAPIDLY. THE ENGINE, VSA, AND TIRE PRESSURE MONITORING SYSTEM WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.
NHTSA ODI #10750403
60,000 miles · Aug 17, 2015
Suspension
THE HONDA ACCORD 2008 MODEL STARTED TO CLUNK HEAVILY IN THE FRONT SUSPENSION WHEN THE WEATHER WAS HOT, ANYTHING ABOVE 85 DEGREES. WHEN THE FRONT END WAS LIFTED OR WEATHER COOLED, THE SOUND WENT AWAY. STEERING BECAME SLOPPY AND FELT UNSAFE. THIS SUMMER WHEN WEATHER WAS VERY HOT, THE CLUNK BECAME VERY LOUD AND METAL SCRAPING ON…
Read full complaint
THE HONDA ACCORD 2008 MODEL STARTED TO CLUNK HEAVILY IN THE FRONT SUSPENSION WHEN THE WEATHER WAS HOT, ANYTHING ABOVE 85 DEGREES. WHEN THE FRONT END WAS LIFTED OR WEATHER COOLED, THE SOUND WENT AWAY. STEERING BECAME SLOPPY AND FELT UNSAFE. THIS SUMMER WHEN WEATHER WAS VERY HOT, THE CLUNK BECAME VERY LOUD AND METAL SCRAPING ON METAL WAS APPARENT, ESPECIALLY ON START, STOP AND ANY BUMPS. HONDA ISSUED A SERVICE BULLETIN DATED SEP. 17, 2013, BULLETIN 12-082 THAT DESCRIBES THIS PROBLEM AND ATTRIBUTES IT TO BALL JOINTS THAT BECOME UNLUBRICATED IN HIGH AMBIENT TEMPERATURES. OF COURSE METAL ON METAL CONTACT WITHOUT LUBRICATION IN THE BALL JOINT QUICKLY DESTROYS THE BALL JOINT, AFFECTS STEERING ADVERSELY, FATIGUES THE METAL AND COULD LEAD TO BREAKAGE. I ATTEMPTED TO HAVE HONDA NORTH AMERICA PAY FOR THE REPAIR OF THIS PART THAT THEY ACKNOWLEDGE IS DEFECTIVE IN THEIR SERVICE BULLETIN 12-082, BUT THEY WERE NOT WILLING TO PAY FOR THE COMPLETE REPAIR. I HAD NEW BALL JOINTS PUT ON AND IT STEERS WELL AND CLUNKING IS GONE. WAS NOT WILLING TO LET IT GO ON LONGER AND RISK BREAKAGE AT DETRIMENT TO MYSELF AND FAMILY. THIS IS A PART THAT SHOULD BE RECALLED/REPAIRED AT HONDA'S EXPENSE AND POSES A SAFETY RISK.
NHTSA ODI #10749158
Mileage unknown · Aug 11, 2015
Air BagsSeat Belts
MY AIRBAG LIGHT STAYS ON AND THE ALARM DOESN'T GO OFF WHEN THE SEAT BELT ISN'T PUT ON. I JUST BEGAN TO HAVE TROUBLE STARTING THE VEHICLE. NOW I CAN'T START IT AND I'VE HAD TO HAVE IT TOWED TO MY HOME.
NHTSA ODI #10747850
82,000 miles · Aug 5, 2015
Engine
THE OUTER RACE OF THE SECONDARY SHAFT BEARING IS BROKEN ACCORDING TO MY MECHANIC AND IS CAUSING ABNORMAL NOISE, THE MALFUNCTION INDICATOR LIGHT IS TURN ON AND THE CAR HAS STALLED ON ME. AND ONCE WHEN I HAVE PLACED THE CAR IN THE PARK POSITION IT HAS ROLLED ON ME... UPDATED 09/30/15*BF
NHTSA ODI #10746620
Mileage unknown · Jul 31, 2015
Air Bags
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBERS: 15V320000 (AIR BAGS) AND 15V370000 (AIR BAGS) WERE RECEIVED IN JULY OF 2015. AFTER CONTACTING THE DEALER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED T…
Read full complaint
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBERS: 15V320000 (AIR BAGS) AND 15V370000 (AIR BAGS) WERE RECEIVED IN JULY OF 2015. AFTER CONTACTING THE DEALER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10745213
Mileage unknown · Jul 25, 2015
Air BagsEngineWheelsCrashInjury
FIRST INCIDENT WAS ON 6/14/2015. I WAS DRIVING ON THE HIGHWAY AS MY ENGINE LIGHT CAME ON AND THE CAR STARTED SHAKING. I PULLED OVER AND TURNED THE CAR OFF BECAUSE IT SMELLED LIKE SMOKE. AS I TRIED TO TURN THE VEHICLE BACK ON IT WOULD NOT CUT BACK ON. THE CAR HAD TO GET TOWED AND REPAIRS HAD TO BE DONE TO THE TUNE OF $1,500.00. T…
Read full complaint
FIRST INCIDENT WAS ON 6/14/2015. I WAS DRIVING ON THE HIGHWAY AS MY ENGINE LIGHT CAME ON AND THE CAR STARTED SHAKING. I PULLED OVER AND TURNED THE CAR OFF BECAUSE IT SMELLED LIKE SMOKE. AS I TRIED TO TURN THE VEHICLE BACK ON IT WOULD NOT CUT BACK ON. THE CAR HAD TO GET TOWED AND REPAIRS HAD TO BE DONE TO THE TUNE OF $1,500.00. THE BATTERY, GASKET, PLUGS & ALTERNATOR HAD TO BE REPLACED. SECOND INCIDENT WAS ON 7/17/2015. AS I WAS MAKING A LEFT HAND TURN THE CAR STALLED & I WAS HIT BY ANOTHER VEHICLE. ALL AIR BAGS DEPLOYED AND BURST. THE RIGHT FRONT WHEEL WAS PUSHED IN.
NHTSA ODI #10743479
82,000 miles · Jul 22, 2015
Air Bags
THE AIR BAG SENSOR (DRIVER SIDE) LIGHT IS ON AND HONDA REFUSES TO DETERMINE THE CAUSE AT THEIR EXPENSE. CLAIMS THE CAR IS NOT COVERED BY THE MASSIVE AIRBAG RECALL. ALTHOUGH FROM US DOT INVESTIGATION THEY PREVIOUSLY HIDE WARRANTY ISSUES FROM THE PUBLIC.
NHTSA ODI #10735806
110,000 miles · Jul 22, 2015
Engine
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. WHILE STARTING THE VEHICLE, AN ABNORMAL KNOCKING SOUND EMITTED FROM THE ENGINE. THE FAILURE RECURRED MULTIPLE TIMES INTERMITTENTLY. ALSO, WHILE DRIVING AT APPROXIMATELY 60 MPH, THE KNOCKING SOUND COULD BE HEARD FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. TH…
Read full complaint
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. WHILE STARTING THE VEHICLE, AN ABNORMAL KNOCKING SOUND EMITTED FROM THE ENGINE. THE FAILURE RECURRED MULTIPLE TIMES INTERMITTENTLY. ALSO, WHILE DRIVING AT APPROXIMATELY 60 MPH, THE KNOCKING SOUND COULD BE HEARD FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN OIL CHANGE WHICH STOPPED THE KNOCKING SOUND. AFTER 2000 MILES THE FAILURE RECURRED, AND THE OIL WARNING LIGHT ILLUMINATED. THE CONTACT REPLENISHED THE VEHICLE WITH 2 QUARTS OF OIL, AND THE KNOCKING SOUND STOPPED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
NHTSA ODI #10735752
46,000 miles · Jul 19, 2015
SuspensionUnknown Or OtherWheels
I PURCHASED NEW TIRES ABOUT A YEAR AGO. TIRES HAD LESS THAN 30,000 ON THEM. BACK TIRES STILL HAD 90% TREAD BUT GETTING A VIBRATION. TOOK CAR TO THE BODY SHOP AND WAS TOLD THAT THE REAR END OF MY VEHICLE WAS BADLY OUT OF ALIGNMENT.. I COULD SEE IT WITH MY NAKED EYES. THE PROBLEM IS THAT THE REAR TIRES CAN NOT BE ALIGNED. THE…
Read full complaint
I PURCHASED NEW TIRES ABOUT A YEAR AGO. TIRES HAD LESS THAN 30,000 ON THEM. BACK TIRES STILL HAD 90% TREAD BUT GETTING A VIBRATION. TOOK CAR TO THE BODY SHOP AND WAS TOLD THAT THE REAR END OF MY VEHICLE WAS BADLY OUT OF ALIGNMENT.. I COULD SEE IT WITH MY NAKED EYES. THE PROBLEM IS THAT THE REAR TIRES CAN NOT BE ALIGNED. THERE IS NO WAY TO ADJUST THE CAMBER ON THE BACK TIRES, SO NO MATTER WHAT YOU WILL ALWAYS HAVE VIBRATION AND ALWAY UNEVENLY WHERE YOUR TIRES. ONLY WAY I CAN SEE TO FIX THIS, IS TO INSTALL ADJUSTABLE CAMBERS, BUT IF THIS IS A DESIG FLAW AND HONDA ALREADY ACKNOWLEDGED IT WITH A SERVICE BULLETIN ADDRESSING THERE HONDA CIVICS, THEN WHY SHOULD I HAVE TO PAY FOR THE FIX. I AM TOTALLY DISGUSTED WITH HONDA.
NHTSA ODI #10735012
Mileage unknown · Jul 18, 2015
EngineUnknown Or Other
OIL LOW AT OIL CHANGE.
NHTSA ODI #10734926
Official recalls
8Jun 27, 2019
Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2014 TSX Sport Wagon, 2010-2013 ZDX, 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic and Civic Hybrid, 2008-2010 Civic GX NGV, 2012-2015 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2014 Fit EV, 2010-2014 Insight, and 2009-2015 Pilot vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are F5F and Q5E.
May 16, 2019
Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2013 TSX Sport Wagon, and 2010-2012 ZDX and 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic, Civic Hybrid and Civic NGV, 2012-2014 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2010-2013 Insight, and 2009-2015 Pilot vehicles. The front passenger air bag inflator may have been installed incorrectly during replacement.
Consequence & remedy
Consequence: An incorrectly installed air bag inflator may not properly deploy the passenger frontal air bag in the event of a crash, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect the inflator installation and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began July 5, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are M4O, P4R, T4Q, and W4P.
Apr 26, 2018
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.
Consequence & remedy
Consequence: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.
Aug 31, 2017
Honda (American Honda Motor Co.) is recalling certain 2008-2012 Accord, 2010-2012 Accord Crosstour, 2006-2011 Civic, 2007-2011 CR-V, 2009-2012 Fit and Pilot, 2010-2012 Insight, and 2009-2012 Acura TSX vehicles that received replacement passenger frontal air bag inflators. One dealership may have incorrectly installed the replacement air bag inflators.
Consequence & remedy
Consequence: In the event of a crash, an incorrectly installed passenger frontal air bag inflator may deploy the air bag improperly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag module assembly, free of charge. The recall began October 30, 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are O07, Y0A, N06, G05, M04, Y01, and O09.
Jan 10, 2017
Honda (American Honda Motor Co.) is recalling certain 2009-2012 Acura TSX, 2011-2012 Acura TSX Wagon, 2010-2012 Acura ZDX, 2008-2012 Honda Accord, 2010-2012 Honda Accord Crosstour and Honda Insight, 2009-2012 Honda Fit, 2009-2012 Pilot, 2007-2011 Honda CR-V, 2012 Honda FCX Clarity and 2006-2011 Honda Civic, Civic Hybrid, Civic NGV vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2009 Acura TSX, Honda Fit and Pilot, 2008-2009 Honda Accord, 2006-2009 Civic, Civic Hybrid and Civic NGV, and 2007-2009 Honda CR-V vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone B" above, Honda is recalling certain 2008 Honda Accord, 2006-2008 Honda Civic, Civic Hybrid and Civic NGV and 2007-2008 Honda CR-V vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the front passenger side air bag inflator, free of charge. The manufacturer has mailed an interim notification, and will send a second notification when parts are available. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KE1 and KE2.
May 24, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2009-2011 Acura TSX, 2011 TSX Wagon, 2010-2011 Acura ZDX, 2008-2011 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic, Civic Hybrid, and Civic GX, 2007-2011 CR-V, 2010-2011 FCX Clarity and Insight, and 2009-2011 Fit, and Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless already included in "Zone A" above, Honda is recalling certain model year 2008 Honda Accord, 2006-2008 Civic, Civic Hybrid and Civic GX, and 2007-2008 CR-V vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the inflator, free of charge. The recall began March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall is KA4, KA5, KA6, and KA7.
Feb 2, 2016
American Honda Motor Company, Inc. (Honda) is recalling certain model year 2008-2010 Accord vehicles. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury.
Remedy: Honda will notify owners, and dealers will replace the air bag control units, free of charge. Parts are expected to be available in Fall 2016. Interim notifications have been mailed to owners on March 15, 2016, and a second notice will be mailed when remedy parts are available. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JW9. Note: This recall supersedes Recall 15V665.
Aug 4, 2011
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2010 ACCORD, 2007-2010 CR-V, AND 2005-2008 ELEMENT PASSENGER CARS MANUFACTURED FROM JULY 1, 2004, THROUGH SEPTEMBER 3, 2010. THE OUTER RACE OF THE SECONDARY SHAFT BEARING MAY BE BROKEN DURING CERTAIN DRIVING STYLES. A BROKEN OUTER RACE MAY CAUSE ABNORMAL NOISE, THE MALFUNCTION INDICATOR LIGHT TO TURN ON, AND ALLOW CONTACT BETWEEN THE TRANSMISSION IDLE GEAR AND AN ELECTRONIC SENSOR HOUSING WITHIN THE TRANSMISSION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SHORT CIRCUIT CAUSING THE ENGINE TO STALL. ADDITIONALLY, BROKEN PIECES OF THE OUTER RACE OR BALL BEARING FROM THE SECONDARY SHAFT MAY BECOME LODGED IN THE PARKING PAWL RESULTING IN THE VEHICLE ROLLING AFTER THE DRIVER HAS PLACED THE GEAR SELECTOR IN THE PARK POSITION. ENGINE STALL AND UNEXPECTED VEHICLE MOVEMENT INCREASES THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS WITHIN THE PATH OF A ROLLING VEHICLE.
Remedy: HONDA WILL NOTIFY OWNERS AND DEALERS WILL UPDATE THE AUTOMATIC TRANSMISSION CONTROL MODULE SOFTWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE15029 · Srs Control Module Failure
Opened Aug 18, 2015 · Closed Jun 17, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Additional source detail variants (4)
Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
EA14004 · Inadvertent Side Air Bag Deployment
Opened Jul 29, 2014 · Closed Jan 4, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
Additional source detail variants (2)
Air Bags
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
Air Bags:side/window
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
PE14004 · Inadvertent Side Air Bag Deployment
Opened Jan 31, 2014 · Closed Jul 29, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Additional source detail variants (2)
Air Bags
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Air Bags:side/window
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Illustration