NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
451 reportsClear category filter27,500 miles · Sep 16, 2009
Service Brakes, Hydraulic
2008 HONDA ACCORD EX: AT 27,500 MILES, THE REAR BRAKE PADS WERE WORN COMPLETELY DOWN TO THE METAL BACKING PLATE. THE FRONT PADS SHOWED NORMAL WEAR, WHEN INSPECTED DURING A TIRE REPLACEMENT. THE CAR IS USED FOR COMMUTING TO WORK DAILY, 25 MILES EACH WAY, OVER A MIX OF IN TOWN STREETS AND FREEWAY DRIVING. THIS WEAR IN THE REAR BRA…
Read full complaint
2008 HONDA ACCORD EX: AT 27,500 MILES, THE REAR BRAKE PADS WERE WORN COMPLETELY DOWN TO THE METAL BACKING PLATE. THE FRONT PADS SHOWED NORMAL WEAR, WHEN INSPECTED DURING A TIRE REPLACEMENT. THE CAR IS USED FOR COMMUTING TO WORK DAILY, 25 MILES EACH WAY, OVER A MIX OF IN TOWN STREETS AND FREEWAY DRIVING. THIS WEAR IN THE REAR BRAKES IS EXCESSIVE AND REQUIRED REPLACEMENT, BUT WAS NOT COVERED UNDER WARRANTY. A REAR BRAKE FAILURE COULD CAUSE AN ACCIDENT BY CAUSING AN INCREASE IN STOPPING DISTANCE. *TR
NHTSA ODI #10284179
14,000 miles · Sep 16, 2009
Service Brakes, Hydraulic
BRAKE SYSTEM WEAR PREMATURE AT 14,000 MILES. FRONT ROTORS WARPED AND REAR BRAKE PADS DEPLETED. *TR
NHTSA ODI #10284171
22,000 miles · Sep 16, 2009
Service Brakes, Hydraulic
I BOUGHT 2008 HONDA 2008 IN FEB 2008, REPLACED REAR PADS IN OCT 2008 AT 22,000 MILES. I SPOKE W/ SERVICE DEPARTMENT WHERE I BOUGHT MY CAR. HE TOLD ME THEY ARE HAVING ALOT OF PROBLEMS W/ THE 2008 ACCORD'S REAR BRAKES AND THAT IT WAS NOT COVERED UNDER WARRANTY. HAD TO BUY NEW PADS FROM DEALER (B/C NO AFTERMARKETS WERE AVAILABLE…
Read full complaint
I BOUGHT 2008 HONDA 2008 IN FEB 2008, REPLACED REAR PADS IN OCT 2008 AT 22,000 MILES. I SPOKE W/ SERVICE DEPARTMENT WHERE I BOUGHT MY CAR. HE TOLD ME THEY ARE HAVING ALOT OF PROBLEMS W/ THE 2008 ACCORD'S REAR BRAKES AND THAT IT WAS NOT COVERED UNDER WARRANTY. HAD TO BUY NEW PADS FROM DEALER (B/C NO AFTERMARKETS WERE AVAILABLE). IN SEP 2009, SQUEAKING FROM THE REAR BRAKES AGAIN, REAR PADS NEEDED TO BE REPLACED AT 41,000 MILES. WENT TO DEALERSHIP AGAIN TO COMPLAIN, SERVICE MANAGER SAID THAT THEY WERE AN INDEPENDENT FRANCHISE AND THAT HONDA WOULD HAVE TO TAKE CARE OF MY PROBLEM. HE ALSO STATED THAT HONDA WAS AWARE OF THE PROBLEM AND THEY WERE RESEARCHING THE PROBLEM. CALLED HONDA CORPORATION AND THE CASE INVESTIGATOR SAID THE EXACT SAME THING AS THE SERVICE MANAGER. I WENT TO THE NHTSA WEB SITE AND SAW THAT I AM NOT ALONE. IT APPEARS THAT HONDA AND ITS EMPLOYEES ARE TOWING THE COMPANY LINE AND STONEWALLING THE CONSUMER, BECAUSE IT WILL COST THEM MONEY AND HURT THEIR REPUTATION. THE NHTSA NEEDS TO FORCE HONDA TO DO THE RIGHT THING AND FIX THE PROBLEM BEFORE SOMEONE IS INJURED OR EVEN WORSE, KILLED. THESE ARE BRAKES, THE MOST IMPORTANT SAFETY DEVICE ON ANY CAR. *TR
NHTSA ODI #10284122
15,039 miles · Sep 11, 2009
Service Brakes, Hydraulic
TOOK MY 2008 HONDA ACCORD (15,039 MILES) TO BE SERVICED FOR THE SECOND TIME SINCE I PURCHASED THE CAR. I WAS TOLD THAT THE REAR BRAKES WERE WORN AND NEEDED TO BE REPLACED AT A COST OVER $200 "FOR A ONE YEAR OLD CAR, HOW ARE THE FRONT BRAKES!?" I WAS TOLD THAT THE FRONT BRAKES SEEMED TO BE FINE. I EXPRESSED TO THEM THAT THIS…
Read full complaint
TOOK MY 2008 HONDA ACCORD (15,039 MILES) TO BE SERVICED FOR THE SECOND TIME SINCE I PURCHASED THE CAR. I WAS TOLD THAT THE REAR BRAKES WERE WORN AND NEEDED TO BE REPLACED AT A COST OVER $200 "FOR A ONE YEAR OLD CAR, HOW ARE THE FRONT BRAKES!?" I WAS TOLD THAT THE FRONT BRAKES SEEMED TO BE FINE. I EXPRESSED TO THEM THAT THIS WAS CRAZY AND THAT THERE IS DEFINITELY SOMETHING WRONG HERE. I ASKED IF THERE WERE ANY COMPLAINTS ABOUT THIS FROM OTHERS. DID NOT QUITE GET A TRUTHFUL ANSWER SO I DECIDED TO RESEARCH ONLINE AND SURE ENOUGH. I AM NOT THE ONLY ONE EXPERIENCING THIS PROBLEM. AT THE SERVICE SHOP I WAS ALSO TOLD THAT AFTER THIS REPAIR/CHANGE OF REAR BRAKES, I WILL HAVE TO REPAIR THEM AGAIN AT ANOTHER 20,000 MILES. I AM VERY DISGUSTED AND THINK THAT HONDA SHOULD STEP UP AND DO SOMETHING FOR ALL THE LOYAL HONDA BUYERS. EITHER FIX THE PROBLEM OR REFUND THE CUSTOMER. *TR
NHTSA ODI #10283722
31,400 miles · Sep 11, 2009
Service Brakes, Hydraulic
PREMATURE REAR BRAKE WEAR. POTENTIAL SAFETY HAZARD, MANUFACTURER IGNORING PROBLEM. HONDA NEEDS TO RECALL THESE VEHICLES IMMEDIATELY BEFORE SOMEONE GETS KILLED. *TR
NHTSA ODI #10283619
19,800 miles · Sep 9, 2009
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT SHE HEARD SQUEAKING WHEN APPLYING PRESSURE TO THE BRAKE PEDAL, AND THEN THE VEHICLE BEGAN TO SHAKE. THE BREAK FAILURE COULD LEAD TO INCREASED STOPPING DISTANCES, WHICH INCREASED THE RISK OF A VEHICLE CRASH. THE VEHICLE WAS TAKEN TO THE DEALER AND A TECHNICIAN REPLA…
Read full complaint
TL*THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT SHE HEARD SQUEAKING WHEN APPLYING PRESSURE TO THE BRAKE PEDAL, AND THEN THE VEHICLE BEGAN TO SHAKE. THE BREAK FAILURE COULD LEAD TO INCREASED STOPPING DISTANCES, WHICH INCREASED THE RISK OF A VEHICLE CRASH. THE VEHICLE WAS TAKEN TO THE DEALER AND A TECHNICIAN REPLACED THE REAR BRAKE PADS. THE FAILURE MILEAGE WAS 19,800 AND THE CURRENT MILEAGE WAS 20,700.
NHTSA ODI #10283470
29,108 miles · Sep 9, 2009
Service Brakes, Hydraulic
BRAKE PAD FAILURE. *TR
NHTSA ODI #10283462
30,000 miles · Sep 8, 2009
Service Brakes, Hydraulic
HONDA ACCORD 2008 REAR BRAKES WORN PREMATURELY. AFTER 30,000 MILES, I WAS TOLD BY HONDA MECHANIC THAT MY FRONT BRAKES LOOK LIKE NEW (9 MM. LEFT), BUT BOTH REAR BRAKES NEEDED TO BE REPLACED (1 MM. LEFT). BOTH REAR BRAKES WORN EVENLY. AFTER SEARCHING FEW CAR FORUMS, I FOUND THAT I'M NOT ALONE HAVING THIS PROBLEM. BRAKES WERE REPL…
Read full complaint
HONDA ACCORD 2008 REAR BRAKES WORN PREMATURELY. AFTER 30,000 MILES, I WAS TOLD BY HONDA MECHANIC THAT MY FRONT BRAKES LOOK LIKE NEW (9 MM. LEFT), BUT BOTH REAR BRAKES NEEDED TO BE REPLACED (1 MM. LEFT). BOTH REAR BRAKES WORN EVENLY. AFTER SEARCHING FEW CAR FORUMS, I FOUND THAT I'M NOT ALONE HAVING THIS PROBLEM. BRAKES WERE REPLACED AT MY EXPENSE. *TR
NHTSA ODI #10283132
15,000 miles · Sep 5, 2009
Service Brakes, Hydraulic
TOOK MY NEW 2008 HONDA ACCORD COUPE EX-L V6 TO MY LOCAL HONDA DEALERSHIP SERVICE DEPARTMENT IN EARLY 2009 TO INVESTIGATE WHY MY BRAKES CONSISTENTLY SQUEAL EXTREMELY LOUDLY AT ONLY ~15,000 MILES, AND THEY TOLD ME THEY DIDN'T KNOW, COULDN'T REPRODUCE THE PROBLEM, AND EVEN TOLD ME MY BRAKE PADS WERE IN EXCELLENT CONDITION. I TOOK T…
Read full complaint
TOOK MY NEW 2008 HONDA ACCORD COUPE EX-L V6 TO MY LOCAL HONDA DEALERSHIP SERVICE DEPARTMENT IN EARLY 2009 TO INVESTIGATE WHY MY BRAKES CONSISTENTLY SQUEAL EXTREMELY LOUDLY AT ONLY ~15,000 MILES, AND THEY TOLD ME THEY DIDN'T KNOW, COULDN'T REPRODUCE THE PROBLEM, AND EVEN TOLD ME MY BRAKE PADS WERE IN EXCELLENT CONDITION. I TOOK THE CAR BACK TO ANOTHER DEALERSHIP A FEW MONTHS LATER FOR THE SAME PROBLEM AND THEY TOLD ME IMMEDIATELY THAT THERE WAS SOME KIND OF BULLETIN RECENTLY RELEASED BY HONDA ABOUT THIS PROBLEM ON 2008-2009 HONDA ACCORDS. THEY TOLD ME THERE WASN'T YET ANY "TECHNICAL SERVICE ADVISORY" BUT WERE AWARE OF THE PROBLEM, AND THAT IT WASN'T A SAFETY ISSUE. SINCE THEN, I HAVE NOT HEARD ANYTHING MORE ON THE ISSUE AND HAVE FOUND HUNDREDS OF COMPLAINTS ON THE INTERNET ABOUT THE SAME PROBLEM. THIS ISSUE IS EXTREMELY ANNOYING, A MAJOR NUISANCE FOR A BRAND NEW CAR WITH LESS THAN 20,000 MILES AND BRAKE PADS IN EXCELLENT CONDITION. I WOULD LIKE TO KNOW WHY HONDA IS NOT DOING ANYTHING FURTHER TO PURSUE A RECALL OR NOTIFY THEIR CONSUMERS AS TO THE NATURE OF THE PROBLEM TO PREVENT PEOPLE FROM SPENDING UNNECESSARILY ON NEW BRAKE PADS AND ROTORS, WHICH WILL NOT FIX THE PROBLEM. THANKS YOU. *TR
NHTSA ODI #10282959
17,500 miles · Sep 4, 2009
Service Brakes, Hydraulic
WE PURCHASED A 2008 HONDA ACCORD EXL IN 09/2008. VEHICLE IS USED TO COMMUTE TO WORK AND MAJORITY OF THE MILES ARE HIGHWAY. VEHICLE IS DRIVEN NORMALLY. AT APPROX. 17500 MILES, WE WERE TOLD THE REAR BRAKES NEED TO BE REPLACED BECAUSE OF WEAR ON THE BRAKE PADS. FRONT BRAKES ARE FINE. TALKED TO OTHER HONDA ACCORD OWNERS WHO ARE…
Read full complaint
WE PURCHASED A 2008 HONDA ACCORD EXL IN 09/2008. VEHICLE IS USED TO COMMUTE TO WORK AND MAJORITY OF THE MILES ARE HIGHWAY. VEHICLE IS DRIVEN NORMALLY. AT APPROX. 17500 MILES, WE WERE TOLD THE REAR BRAKES NEED TO BE REPLACED BECAUSE OF WEAR ON THE BRAKE PADS. FRONT BRAKES ARE FINE. TALKED TO OTHER HONDA ACCORD OWNERS WHO ARE EXPERIENCING THE SAME PROBLEM. THE REAR BRAKES ARE DEFECTIVE AND OF POOR QUALITY. HONDA DEALERSHIP IS WILLING TO PAY 1/2 OF THE SERVICE CHARGE. *TR
NHTSA ODI #10282824
Official recalls
8Jun 27, 2019
Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2014 TSX Sport Wagon, 2010-2013 ZDX, 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic and Civic Hybrid, 2008-2010 Civic GX NGV, 2012-2015 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2014 Fit EV, 2010-2014 Insight, and 2009-2015 Pilot vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are F5F and Q5E.
May 16, 2019
Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2013 TSX Sport Wagon, and 2010-2012 ZDX and 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic, Civic Hybrid and Civic NGV, 2012-2014 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2010-2013 Insight, and 2009-2015 Pilot vehicles. The front passenger air bag inflator may have been installed incorrectly during replacement.
Consequence & remedy
Consequence: An incorrectly installed air bag inflator may not properly deploy the passenger frontal air bag in the event of a crash, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect the inflator installation and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began July 5, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are M4O, P4R, T4Q, and W4P.
Apr 26, 2018
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.
Consequence & remedy
Consequence: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.
Aug 31, 2017
Honda (American Honda Motor Co.) is recalling certain 2008-2012 Accord, 2010-2012 Accord Crosstour, 2006-2011 Civic, 2007-2011 CR-V, 2009-2012 Fit and Pilot, 2010-2012 Insight, and 2009-2012 Acura TSX vehicles that received replacement passenger frontal air bag inflators. One dealership may have incorrectly installed the replacement air bag inflators.
Consequence & remedy
Consequence: In the event of a crash, an incorrectly installed passenger frontal air bag inflator may deploy the air bag improperly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag module assembly, free of charge. The recall began October 30, 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are O07, Y0A, N06, G05, M04, Y01, and O09.
Jan 10, 2017
Honda (American Honda Motor Co.) is recalling certain 2009-2012 Acura TSX, 2011-2012 Acura TSX Wagon, 2010-2012 Acura ZDX, 2008-2012 Honda Accord, 2010-2012 Honda Accord Crosstour and Honda Insight, 2009-2012 Honda Fit, 2009-2012 Pilot, 2007-2011 Honda CR-V, 2012 Honda FCX Clarity and 2006-2011 Honda Civic, Civic Hybrid, Civic NGV vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2009 Acura TSX, Honda Fit and Pilot, 2008-2009 Honda Accord, 2006-2009 Civic, Civic Hybrid and Civic NGV, and 2007-2009 Honda CR-V vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone B" above, Honda is recalling certain 2008 Honda Accord, 2006-2008 Honda Civic, Civic Hybrid and Civic NGV and 2007-2008 Honda CR-V vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the front passenger side air bag inflator, free of charge. The manufacturer has mailed an interim notification, and will send a second notification when parts are available. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KE1 and KE2.
May 24, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2009-2011 Acura TSX, 2011 TSX Wagon, 2010-2011 Acura ZDX, 2008-2011 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic, Civic Hybrid, and Civic GX, 2007-2011 CR-V, 2010-2011 FCX Clarity and Insight, and 2009-2011 Fit, and Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless already included in "Zone A" above, Honda is recalling certain model year 2008 Honda Accord, 2006-2008 Civic, Civic Hybrid and Civic GX, and 2007-2008 CR-V vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the inflator, free of charge. The recall began March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall is KA4, KA5, KA6, and KA7.
Feb 2, 2016
American Honda Motor Company, Inc. (Honda) is recalling certain model year 2008-2010 Accord vehicles. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury.
Remedy: Honda will notify owners, and dealers will replace the air bag control units, free of charge. Parts are expected to be available in Fall 2016. Interim notifications have been mailed to owners on March 15, 2016, and a second notice will be mailed when remedy parts are available. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JW9. Note: This recall supersedes Recall 15V665.
Aug 4, 2011
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2010 ACCORD, 2007-2010 CR-V, AND 2005-2008 ELEMENT PASSENGER CARS MANUFACTURED FROM JULY 1, 2004, THROUGH SEPTEMBER 3, 2010. THE OUTER RACE OF THE SECONDARY SHAFT BEARING MAY BE BROKEN DURING CERTAIN DRIVING STYLES. A BROKEN OUTER RACE MAY CAUSE ABNORMAL NOISE, THE MALFUNCTION INDICATOR LIGHT TO TURN ON, AND ALLOW CONTACT BETWEEN THE TRANSMISSION IDLE GEAR AND AN ELECTRONIC SENSOR HOUSING WITHIN THE TRANSMISSION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SHORT CIRCUIT CAUSING THE ENGINE TO STALL. ADDITIONALLY, BROKEN PIECES OF THE OUTER RACE OR BALL BEARING FROM THE SECONDARY SHAFT MAY BECOME LODGED IN THE PARKING PAWL RESULTING IN THE VEHICLE ROLLING AFTER THE DRIVER HAS PLACED THE GEAR SELECTOR IN THE PARK POSITION. ENGINE STALL AND UNEXPECTED VEHICLE MOVEMENT INCREASES THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS WITHIN THE PATH OF A ROLLING VEHICLE.
Remedy: HONDA WILL NOTIFY OWNERS AND DEALERS WILL UPDATE THE AUTOMATIC TRANSMISSION CONTROL MODULE SOFTWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE15029 · Srs Control Module Failure
Opened Aug 18, 2015 · Closed Jun 17, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Additional source detail variants (4)
Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
EA14004 · Inadvertent Side Air Bag Deployment
Opened Jul 29, 2014 · Closed Jan 4, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
Additional source detail variants (2)
Air Bags
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
Air Bags:side/window
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
PE14004 · Inadvertent Side Air Bag Deployment
Opened Jan 31, 2014 · Closed Jul 29, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Additional source detail variants (2)
Air Bags
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Air Bags:side/window
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Illustration