NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
451 reportsClear category filter83,000 miles · Apr 21, 2016
Electrical SystemElectronic Stability Control (esc)Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT WHILE DRIVING, THE ABS, THE VSC AND BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE CONTACT WAS ALSO INFORMED THAT THE REPAIR PARTS NEEDED TO BE ORDERED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT WHILE DRIVING, THE ABS, THE VSC AND BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE CONTACT WAS ALSO INFORMED THAT THE REPAIR PARTS NEEDED TO BE ORDERED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. UPDATED 06/15/16*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED. UPDATED 06/27/16.*JB
NHTSA ODI #10860664
Mileage unknown · Nov 4, 2015
Air BagsElectrical SystemEngine
2008 HONDA ACCORD. CONSUMER WRITES IN REGARDS TO BRAKE , ENGINE, ELECTRICAL, AIR BAG LIGHT, SEAT BELT, LIGHT PROBLEMS AND RADIO PROBLEMS. *SMD THE CONSUMER STATED THE PISTONS WERE REPLACED A COUPLE OF YEARS AGO. THE ENGINE HAS BEEN MISFIRING SINCE JULY 2014. THE COILS, SPARK PLUGS AND FUEL INJECTORS WERE REPLACED AND THE CHEC…
Read full complaint
2008 HONDA ACCORD. CONSUMER WRITES IN REGARDS TO BRAKE , ENGINE, ELECTRICAL, AIR BAG LIGHT, SEAT BELT, LIGHT PROBLEMS AND RADIO PROBLEMS. *SMD THE CONSUMER STATED THE PISTONS WERE REPLACED A COUPLE OF YEARS AGO. THE ENGINE HAS BEEN MISFIRING SINCE JULY 2014. THE COILS, SPARK PLUGS AND FUEL INJECTORS WERE REPLACED AND THE CHECK ENGINE LIGHT CONTINUED TO STAY ON. *JB
NHTSA ODI #10680196
Mileage unknown · Apr 16, 2012
Engine And Engine CoolingService Brakes, Hydraulic
I BOUGHT A NEW 2008 HONDA ACCORD EXL-6 VEHICLE. I HAVE 72,000 MILES ON IT, MOSTLY HIGHWAY DRIVING. I'VE HAD MY REAR BRAKES REPLACED TWICE. THE DEALER TRIED TO TELL ME 30,000 IS AVERAGE FOR BRAKES. ALSO HAD ALL MY SPARK PLUGS REPLACED. # 3 WENT BAD AND THEY SUGGESTED I REPLACE ALL OF THEM. AGAIN, TELLING ME 70,000 MILES IS AVERAG…
Read full complaint
I BOUGHT A NEW 2008 HONDA ACCORD EXL-6 VEHICLE. I HAVE 72,000 MILES ON IT, MOSTLY HIGHWAY DRIVING. I'VE HAD MY REAR BRAKES REPLACED TWICE. THE DEALER TRIED TO TELL ME 30,000 IS AVERAGE FOR BRAKES. ALSO HAD ALL MY SPARK PLUGS REPLACED. # 3 WENT BAD AND THEY SUGGESTED I REPLACE ALL OF THEM. AGAIN, TELLING ME 70,000 MILES IS AVERAGE FOR SPARK PLUG REPLACEMENT. I WAS CHARGED FULL PRICE FOR ALL WORK DONE, I'VE EVEN PAID FOR THE EXTENDED WARRANTY AND THAT DIDN'T COVER THE SPARK PLUGS EITHER. I WOULDN'T EVEN TAKE MY CAR TO THE HONDA DEALER BUT SINCE I FOOLISHLY PAID FOR THE EXTENDED WARRANTY, I'M AFRAID THAT WILL BECOME NULL AND VOID IF ANY OTHER MECHANIC TOUCHES MY CAR FOR ANY REASON. FIRST AND LAST HONDA I WILL EVER PURCHASE. I'D LIKE TO KNOW IF THERE IS ANYWAY I CAN FIND OUT IF I'M ENTITLED TO A REFUND FOR BRAKES & SPARK PLUGS. JUST SPENT ALMOST $600 HAVING THE TWO REPLACED. *JS
NHTSA ODI #10455409
35,000 miles · Apr 14, 2012
Service Brakes, Hydraulic
REAR BRAKE PADS COMPLETELY WORN OUT. FRONT BRAKES PADS STILL@ 75% GOOD. THIS IS UNHEARD OF DUE TO THE FACT THAT MOST OF THE BRAKING IS ON THE FRONT PADS. *TR
NHTSA ODI #10455265
20,800 miles · Apr 13, 2012
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE, HE WAS ADVISED THAT THE REAR BRAKE DRUMS WERE DEFECTIVE. THE DEALER STATED THAT THE DRUMS WERE WEARING PREMATURELY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE, HE WAS ADVISED THAT THE REAR BRAKE DRUMS WERE DEFECTIVE. THE DEALER STATED THAT THE DRUMS WERE WEARING PREMATURELY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 20,800.
NHTSA ODI #10455109
52,000 miles · Apr 5, 2012
Service Brakes, Hydraulic
2008 HONDA ACCORD ACCORDING TO REPAIR RECORDS HAS HAD THE FRONT BRAKES REPAIRED TWICE SINCE I BOUGHT THE CAR 7 MONTHS AGO. BEING TOLD ALL 4 ROTORS ARE WARPED BUT IT IS NOT A SAFETY ISSUE. I ONLY NOTICED IT BECAUSE OF THE EXCESSIVE SHIMMERING AND SHAKING WHEN I APPLIED THE BRAKES. THE FIX WAS TO REFINISH THE ROTORS, BUT AT SOM…
Read full complaint
2008 HONDA ACCORD ACCORDING TO REPAIR RECORDS HAS HAD THE FRONT BRAKES REPAIRED TWICE SINCE I BOUGHT THE CAR 7 MONTHS AGO. BEING TOLD ALL 4 ROTORS ARE WARPED BUT IT IS NOT A SAFETY ISSUE. I ONLY NOTICED IT BECAUSE OF THE EXCESSIVE SHIMMERING AND SHAKING WHEN I APPLIED THE BRAKES. THE FIX WAS TO REFINISH THE ROTORS, BUT AT SOME POINT THIS OPTION WILL NO LONGER BE ABLE BECAUSE OF THE SPECS OF THE ROTOR SO THEN I WILL BE FORCED INTO REPLACING THEM AT AN APPROXIMATE COST OF $150 A ROTOR. HOW IS IT POSSIBLE THAT ANY PART OF A SYSTEM DESIGNED TO STOP YOUR VEHICLE IS NOT A SAFETY ISSUE. *TR
NHTSA ODI #10454227
18,000 miles · Apr 3, 2012
Engine And Engine CoolingService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH WHEN THE BRAKES WERE ABRUPTLY APPLIED AND THE VEHICLE EXHIBITED AN ABNORMAL GRINDING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HER THAT THE FRONT AND REAR BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. APPROXIM…
Read full complaint
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH WHEN THE BRAKES WERE ABRUPTLY APPLIED AND THE VEHICLE EXHIBITED AN ABNORMAL GRINDING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HER THAT THE FRONT AND REAR BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. APPROXIMATELY 15,000 MILES LATER, THE FAILURE RECURRED WHEN DECELERATING. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT REAR BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED A SECOND TIME BUT AGAIN, THE FAILURE RECURRED WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH. THE VEHICLE WOULD SHUTTER AND THE GRINDING NOISE HAD BECOME INCREASINGLY LOUDER. IN ADDITION, WHILE ATTEMPTING TO START THE VEHICLE THE CONTACT NOTICED A LOUD NOISE FOR APPROXIMATELY TWO SECONDS. THE CONTACT CHECKED THE OIL DIPSTICK AND DISCOVERED THAT THERE WAS NO OIL IN THE ENGINE. THE DEALER ADVISED HAVING AN OIL CONSUMPTION TEST PERFORMED AND DRIVING THE VEHICLE FOR AN ADDITIONAL 1,000 MILES BEFORE CONFIRMING THE FAILURE. THE CONTACT WAS CONCERNED ABOUT THE OIL CONSUMPTION AND THE ENGINE FAILING. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 18,000 AND THE CURRENT MILEAGES WERE APPROXIMATELY 43,000.
NHTSA ODI #10453924
Mileage unknown · Mar 14, 2012
Service Brakes, Hydraulic
MY HONDA REAR BRAKES WERE NOT WORKING PROPERLY. I HAD DIFFICULTY STOPPING MY 2008 HONDA ACCORD. I HAD MY BRAKES REPLACED AT CRAMER HONDA OF VENICE ON 05/27/10. I WAS TOLD ABOUT HONDA BRAKE RECALL. I WAS ALSO TOLD THAT THE NEW BRAKES I HAD INSTALLED IN MAY 2010 FOR WOULD LAST FOR AT LEAST 80,000, I WAS PAYING FOR THE IMPROVED BRA…
Read full complaint
MY HONDA REAR BRAKES WERE NOT WORKING PROPERLY. I HAD DIFFICULTY STOPPING MY 2008 HONDA ACCORD. I HAD MY BRAKES REPLACED AT CRAMER HONDA OF VENICE ON 05/27/10. I WAS TOLD ABOUT HONDA BRAKE RECALL. I WAS ALSO TOLD THAT THE NEW BRAKES I HAD INSTALLED IN MAY 2010 FOR WOULD LAST FOR AT LEAST 80,000, I WAS PAYING FOR THE IMPROVED BRAKES. WELL CLOSE TO 40,000 MILES LATER THE "NEW IMPROVED BRAKES" ARE CAUSING THE SAME SAFETY PROBLEMS, DIFFICULTY IN STOPPING. ON 3/14/12, I WAS TOLD BY THE BY THE HONDA SERVICE EMPLOYEE THAT WHEN HONDA REDESIGNED THEIR BRAKES, FOR A SMOOTHER STOP, THEY DID NOT REDESIGN THE BRAKE PAD, CAUSING THEM TO WEAR MUCH QUICKER AND CAUSING CONCERNS. I BOUGHT HONDA FOR SAFETY FOR MY 3 YOUNG CHILDREN. I FEEL THE 2008 HONDA ACCORD BRAKES STILL CREATE A SERIOUS SAFETY AND LIABILITY CONCERN. HOW MANY OTHER HONDA ACCORD OWNERS ARE FACING THE SAME SAFETY CONCERNS? *TR
NHTSA ODI #10451704
21,000 miles · Feb 29, 2012
Service Brakes, Hydraulic
REAR BRAKE PAD WEAR WHICH RUINED THE ROTORS AT 21,000. I REPLACED AND REPAIRED THE BRAKES ONLY TO HAVE THE SAME PROBLEM RECUR AT 42,000 MILES. I HAVE NOT HAD TO REPLACE THE FRONT PADS YET. THIS IS CLEARLY A SAFETY ISSUE ALTHOUGH HONDA DOESN'T SEEM TO AGREE NOR HAVE THEY FIXED THE QUALITY OF THE PADS. THEY CONTINUE TO PUT THE SAM…
Read full complaint
REAR BRAKE PAD WEAR WHICH RUINED THE ROTORS AT 21,000. I REPLACED AND REPAIRED THE BRAKES ONLY TO HAVE THE SAME PROBLEM RECUR AT 42,000 MILES. I HAVE NOT HAD TO REPLACE THE FRONT PADS YET. THIS IS CLEARLY A SAFETY ISSUE ALTHOUGH HONDA DOESN'T SEEM TO AGREE NOR HAVE THEY FIXED THE QUALITY OF THE PADS. THEY CONTINUE TO PUT THE SAME DEFECTIVE PADS ON THE CARS. I CANNOT BELIEVE A RECALL HAS NOT BEEN REQUIRED. TOYOTA HAD TO RECALL THEIR CARS WHEN THEY ACCELERATED WHEN THEY SHOULDN'T. HONDA SHOULD RECALL THEIR CARS FOR NOT STOPPING WHEN THEY SHOULD. DEFECTIVE BRAKES SHOULD ALWAYS BE CONSIDERED A SAFETY ISSUE. *TR
NHTSA ODI #10449687
28,096 miles · Feb 28, 2012
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE WAS EXHIBITING A GRINDING NOISE WHEN THE BRAKE WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER AND THE FAILURE WAS LOCATED AS THE REAR BRAKE PADS WEARING PREMATURELY. THE DEALER REPLACED THE BRAKE PADS TWICE, BUT THE FAILURE WAS NOT CORRECTED. THE R…
Read full complaint
TL* THE CONTACT OWNS A 2008 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE WAS EXHIBITING A GRINDING NOISE WHEN THE BRAKE WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER AND THE FAILURE WAS LOCATED AS THE REAR BRAKE PADS WEARING PREMATURELY. THE DEALER REPLACED THE BRAKE PADS TWICE, BUT THE FAILURE WAS NOT CORRECTED. THE REAR BRAKE CONTINUED TO MAKE A GRINDING NOISE AND WEAR PREMATURELY. THE CONTACT ALSO STATED THAT THE FRONT BRAKES WERE EXHIBITING A GRINDING NOISE, BUT THE DEALER POLISHED AND SCRAPED THE FRONT BRAKE PADS AND THE GRINDING NOISE WAS CORRECTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 28,096, AND THE CURRENT MILEAGE WAS 42,920.
NHTSA ODI #10449592
Official recalls
8Jun 27, 2019
Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2014 TSX Sport Wagon, 2010-2013 ZDX, 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic and Civic Hybrid, 2008-2010 Civic GX NGV, 2012-2015 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2014 Fit EV, 2010-2014 Insight, and 2009-2015 Pilot vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are F5F and Q5E.
May 16, 2019
Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2013 TSX Sport Wagon, and 2010-2012 ZDX and 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic, Civic Hybrid and Civic NGV, 2012-2014 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2010-2013 Insight, and 2009-2015 Pilot vehicles. The front passenger air bag inflator may have been installed incorrectly during replacement.
Consequence & remedy
Consequence: An incorrectly installed air bag inflator may not properly deploy the passenger frontal air bag in the event of a crash, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect the inflator installation and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began July 5, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are M4O, P4R, T4Q, and W4P.
Apr 26, 2018
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.
Consequence & remedy
Consequence: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.
Aug 31, 2017
Honda (American Honda Motor Co.) is recalling certain 2008-2012 Accord, 2010-2012 Accord Crosstour, 2006-2011 Civic, 2007-2011 CR-V, 2009-2012 Fit and Pilot, 2010-2012 Insight, and 2009-2012 Acura TSX vehicles that received replacement passenger frontal air bag inflators. One dealership may have incorrectly installed the replacement air bag inflators.
Consequence & remedy
Consequence: In the event of a crash, an incorrectly installed passenger frontal air bag inflator may deploy the air bag improperly, increasing the risk of injury.
Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag module assembly, free of charge. The recall began October 30, 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are O07, Y0A, N06, G05, M04, Y01, and O09.
Jan 10, 2017
Honda (American Honda Motor Co.) is recalling certain 2009-2012 Acura TSX, 2011-2012 Acura TSX Wagon, 2010-2012 Acura ZDX, 2008-2012 Honda Accord, 2010-2012 Honda Accord Crosstour and Honda Insight, 2009-2012 Honda Fit, 2009-2012 Pilot, 2007-2011 Honda CR-V, 2012 Honda FCX Clarity and 2006-2011 Honda Civic, Civic Hybrid, Civic NGV vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2009 Acura TSX, Honda Fit and Pilot, 2008-2009 Honda Accord, 2006-2009 Civic, Civic Hybrid and Civic NGV, and 2007-2009 Honda CR-V vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone B" above, Honda is recalling certain 2008 Honda Accord, 2006-2008 Honda Civic, Civic Hybrid and Civic NGV and 2007-2008 Honda CR-V vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the front passenger side air bag inflator, free of charge. The manufacturer has mailed an interim notification, and will send a second notification when parts are available. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KE1 and KE2.
May 24, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2009-2011 Acura TSX, 2011 TSX Wagon, 2010-2011 Acura ZDX, 2008-2011 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic, Civic Hybrid, and Civic GX, 2007-2011 CR-V, 2010-2011 FCX Clarity and Insight, and 2009-2011 Fit, and Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless already included in "Zone A" above, Honda is recalling certain model year 2008 Honda Accord, 2006-2008 Civic, Civic Hybrid and Civic GX, and 2007-2008 CR-V vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Honda will notify owners, and dealers will replace the inflator, free of charge. The recall began March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall is KA4, KA5, KA6, and KA7.
Feb 2, 2016
American Honda Motor Company, Inc. (Honda) is recalling certain model year 2008-2010 Accord vehicles. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury.
Remedy: Honda will notify owners, and dealers will replace the air bag control units, free of charge. Parts are expected to be available in Fall 2016. Interim notifications have been mailed to owners on March 15, 2016, and a second notice will be mailed when remedy parts are available. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is JW9. Note: This recall supersedes Recall 15V665.
Aug 4, 2011
HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2010 ACCORD, 2007-2010 CR-V, AND 2005-2008 ELEMENT PASSENGER CARS MANUFACTURED FROM JULY 1, 2004, THROUGH SEPTEMBER 3, 2010. THE OUTER RACE OF THE SECONDARY SHAFT BEARING MAY BE BROKEN DURING CERTAIN DRIVING STYLES. A BROKEN OUTER RACE MAY CAUSE ABNORMAL NOISE, THE MALFUNCTION INDICATOR LIGHT TO TURN ON, AND ALLOW CONTACT BETWEEN THE TRANSMISSION IDLE GEAR AND AN ELECTRONIC SENSOR HOUSING WITHIN THE TRANSMISSION.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SHORT CIRCUIT CAUSING THE ENGINE TO STALL. ADDITIONALLY, BROKEN PIECES OF THE OUTER RACE OR BALL BEARING FROM THE SECONDARY SHAFT MAY BECOME LODGED IN THE PARKING PAWL RESULTING IN THE VEHICLE ROLLING AFTER THE DRIVER HAS PLACED THE GEAR SELECTOR IN THE PARK POSITION. ENGINE STALL AND UNEXPECTED VEHICLE MOVEMENT INCREASES THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS WITHIN THE PATH OF A ROLLING VEHICLE.
Remedy: HONDA WILL NOTIFY OWNERS AND DEALERS WILL UPDATE THE AUTOMATIC TRANSMISSION CONTROL MODULE SOFTWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE15029 · Srs Control Module Failure
Opened Aug 18, 2015 · Closed Jun 17, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Additional source detail variants (4)
Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags:frontal:sensor/control MODULE-INACTIVE
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
Air Bags
As discussed further below, and by letter dated January 22, 2016, Honda is recalling certain model year (MY) 2008 through 2010 Honda Accords to replace a defective air bag/SRS control module that can result in the Supplemental Restraint System (SRS) becoming fully inoperative (disabled).See NHTSA Safety Recall 16V056 at SaferCar.gov for further details.Honda's response to an agency Information Request letter indicated that the SRS module was manufactured by tier-one supplier Continental and contained a power supply ASIC manufactured by tier-two supplier Atmel. The original ASIC was susceptible to a moisture ingress issue due to inadequate ASIC passivation layer.Water ingress could result in moisture reaching the Titanium Nitride (TiN) layer in the ASIC causing corrosion and breakage of electrical circuits.The damaged ASIC then causes failures of the SRS module resulting in 1) incomplete boot-up when power is supplied to the module or 2) the inability of the module to establish either internal or external bus communications.In either case the air bag readiness indicator light on the instrument cluster is illuminated and all air bags and seat belt pretensioners are disabled.During the investigation, ODI obtained the SRS module from a complainant crash vehicle where the air bags did not deploy despite a significant frontal impact.An inspection of the module was performed at a Continental facility.The inspection confirmed that the module had the ASIC fault thus preventing the SRS module from completing the boot-up process.An attempt was made to recover stored EDR data from the module however none was present; this outcome is consistent with an Atmel ASIC failure.A second SRS module alleged to have the ASIC problem was inspected during the same visit.This second module was unable to communicate with the test equipment.The ASIC was replaced on this module and full function was restored to the module confirming the ASIC as the cause of the SRS module fault.According to Honda, tier-two Atmel implemented three different corrective actions in early 2008.Implementation of the corrective actions into module production by tier-one Continental, and into vehicle production by Honda resulted in three distinct vehicle populations.The first population consists of certain non-consecutively built MY 2008 to 2010 Accords with modules that did not contain any of the corrective actions.This population of 341,444 vehicles exhibited a significant level of module failure in service and is thus being recalled.The second population of 382,693 non-consecutively built MY 2008 to 2010 Accords contained two of the three corrective actions.This population exhibited a significantly lower level of SRS module failure, compared to the first population, but a marginally higher level compared to the third population.Honda is conducting a 15 year unlimited mileage extended warranty program for this second population.Under the program Honda will replace the SRS module free of charge for vehicles that experience an SRS module malfunction due to ASIC failure.Owners eligible for the extended warranty will be notified by Honda in writing.The third population consists of vehicles containing all three corrective actions, this population exhibits a normal level of SRS module failure.Based on the safety recall and extended warranty this investigation is closed.The VOQ reports cited above can be reviewed at SaferCar.gov under the following identification numbers: 10871612, 10869953, 10810554, 10788238, 10781994, 10778712, 10765025, 10761583, 10759019, 10758622, 10747850, 10735806, 10734761, 10733519, 10715339, 10703521, 10676517, 1065
EA14004 · Inadvertent Side Air Bag Deployment
Opened Jul 29, 2014 · Closed Jan 4, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
Additional source detail variants (2)
Air Bags
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
Air Bags:side/window
Honda is conducting a safety recall of approximately 303,900 model year 2008-2009 Honda Accord sedans to address inadvertent deployment of the side air bags (see NHTSA recall 15V-665 for more information).It should be noted that almost all of the recalled vehicles are the 2008 Accords (built from start of model year 2008 production to June 25, 2008) as only about 500 early-built 2009 Accords (built from June 24 to June 30, 2008) are included in the recall.The Office of Defects Investigation (ODI) has identified 351 reported incidents of inadvertent side air bag deployments in the 2008 Accord sedans.This investigation found there is risk of serious injury to vehicle occupants or users who are positioned in the direct path of a deploying side curtain air bag.Based on the recall action taken by Honda, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA14-004 public file available on-line at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers:10232206 10235294 10255323 10268158 10268191 10269514 10276755 10279446 10280675 10308292 10319979 10342520 10353536 10408925 10436506 10447151 10458732 10468196 10468200 10493407 10494971 10522291 10524389 10543092 10544473 10545258 10547591 10554073 10563629 10565311 10565423 10576518 10579241 10584501 10585442 10606937 10608973 10627302 10638541 10640968 10650861 10654858 10679518 10680063 10683967 10712981 10717410 10717777 10761860
PE14004 · Inadvertent Side Air Bag Deployment
Opened Jan 31, 2014 · Closed Jul 29, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:side/window
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Additional source detail variants (2)
Air Bags
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Air Bags:side/window
ODI has identified 293 incidents of alleged inadvertent deployment of the side air bags in model year (MY) 2008 Honda Accord 4-door vehicles.This total represents all incidents reported to both ODI and Honda including those from Honda's warranty system (note: the total shown above eliminates all duplicative reports to ODI and Honda).This investigation has revealed that when the driver or front passenger door is shut, the driver-side or passenger-side side curtain air bag can deploy, and in some cases, the side seat-mounted torso air bag can deploy as well.Fourteen people allegedly suffered injuries caused by the deploying air bags.In June 2008, near the end of MY 2008 Accord 4-door production, Honda changed the crash parameter for door closing force, which is embedded in the electronic control unit's software code, in order to reduce the incidents of the inadvertent side air bag deployments.More specifically, the software design change was made on June 5, 2008 for the Accords built in the U.S. and on June 30, 2008 for those built in Japan.ODI found the number of the inadvertent deployment incidents declined significantly for the vehicles with the new crash parameter setting, i.e., the late-built MY 2008 vehicles and all MY 2009 vehicles.Honda reported the Accord 2-door model utilizes a different software/crash parameter than the subject 4-door model.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA14-004) to determine, among other things, the risk of air bag deployment injuries to vehicle users in vulnerable positions.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10232206, 10235294, 10255323, 10268158, 10268191, 10269514, 10276755, 10279446, 10280675, 10308292, 10319979, 10342520, 10353536, 10408925, 10436506, 10447151, 10458732, 10468196, 10468200, 10493407, 10494971, 10522291, 10524389, 10543092, 10544473, 10545258, 10547591, 10554073, 10563629, 10565311, 10565423, 10576518, 10579241, 10584501, 10585442, 10606937, 10608973.
Illustration