NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
11 reportsClear category filter118,234 miles · Feb 3, 2021
EngineFuel/propulsion System
MY 2000 HONDA ACCORD V6 3.0 VTEC ENGINE IS HAVING SOME ISSUES AFTER IT HEATS UP WHEN I START IT WOULD DO SOME ERRATIC RPM CHANGES ON IDLE AND THEN STALL. IF I MANAGE TO GET IT MOVING DESPITE RPM DROPS, IT RUNS GREAT AND WOULD NOT STALL AGAIN. ALSO, IF I LEAVE IT FOR A WHILE (LIKE 15 MINUTES) AND THEN COME BACK, IT USUALLY STAR…
Read full complaint
MY 2000 HONDA ACCORD V6 3.0 VTEC ENGINE IS HAVING SOME ISSUES AFTER IT HEATS UP WHEN I START IT WOULD DO SOME ERRATIC RPM CHANGES ON IDLE AND THEN STALL. IF I MANAGE TO GET IT MOVING DESPITE RPM DROPS, IT RUNS GREAT AND WOULD NOT STALL AGAIN. ALSO, IF I LEAVE IT FOR A WHILE (LIKE 15 MINUTES) AND THEN COME BACK, IT USUALLY STARTS LIKE NOTHING HAPPENED I BELIEVE THIS IS A DEFECT WITH PCM AND FUEL PRESSURE REGULATOR THE ISSUE HAS TO DO WITH ETHANOL HAVING A LOWER BOILING POINT THAN TRADITIONAL GAS. THIS CAUSES IT TO VAPORIZE ON THE FUEL RAIL WHEN THE CAR'S WARM, BUT NO LONG PUMPING GAS BECAUSE IT'S OFF. WHEN YOU GO TO RE-START THE CAR, INSTEAD OF LIQUID GAS, YOU ARE SPURTING ON FUMES ON THE RAIL. I HAVE NOT HAD THIS FIXED ON MY CAR YET I'VE BEEN DOING SOME RESEARCH AND FOUND SEVERAL ARTICLES ONLINE AND REFERS TO THIS PARTICULAR PROBLEM I'VE HAD MY CAR SERVICE WITH A TUNE-UP OIL CHANGE AND A FUEL INDUCTION SERVICE I'VE ALSO REPLACED THE ALTERNATOR AND THE THROTTLE POSITIONING SENSOR IT IS STILL GIVING ME ISSUES I WOULD LIKE TO SEE IF THERE IS VALIDITY TO MY CLAIM.
NHTSA ODI #11394584
Mileage unknown · May 14, 2020
Engine
2000 HONDA ACCORD SE 2000 [XXX] OIL PASSES TO THE ANTIFREEZE RESERVOIR, MECHANIC ADVICE TO REPLACE THE HEAD GASKET AND DO THE WORK CHECK THE HEAD ON A MACHINE SHOP AND REPLACE THE HEAD GASKET AND CHECK THE HEAD ON MACHINE SHOP REINSTALL THE HEAD ON THE MOTOR CHANGE OIL, ANTIFREEZE. AFTER 2 WEEKS CHECK THE ANTIFREEZE RESERVOI…
Read full complaint
2000 HONDA ACCORD SE 2000 [XXX] OIL PASSES TO THE ANTIFREEZE RESERVOIR, MECHANIC ADVICE TO REPLACE THE HEAD GASKET AND DO THE WORK CHECK THE HEAD ON A MACHINE SHOP AND REPLACE THE HEAD GASKET AND CHECK THE HEAD ON MACHINE SHOP REINSTALL THE HEAD ON THE MOTOR CHANGE OIL, ANTIFREEZE. AFTER 2 WEEKS CHECK THE ANTIFREEZE RESERVOIR AND OIL IS ON IT. THE PROBLEM IS AS FOR THE MECHANIC SUGGESTED, IS THE POROUS OF THE MOTOR IS A DEFECT FROM MELTING ALUMINUM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #11324580
60,000 miles · May 4, 2016
Electrical SystemEngine
AFTER GOING FOR A SHORT DRIVE MY CAR WILL NOT RESTART. FOUND OUT THAT THE PCM IS DEFECTIVE. THE COMPUTER MODULE NEED TO BE REPLACED. NON ARE AVAILABLE. THEY ARE DISCONTINUED.
NHTSA ODI #10863283
95,000 miles · Sep 25, 2015
EngineExterior LightingSuspension
WHEN CAR IS DRIVEN DURING HOT DAYS AND YOU TURN THE CAR OFF, IT WILL NOT START AGAIN TELL THE CAR COOLS OFF. THIS HAPPENS DURING THE SUMMER MONTHS.NOW THAT THE CAR IS OLDER, IT WILL NOT START AT ALL DURING SOME OF THE HOT DAYS. THIS INCLUDE WHEN I START THE CAR FOR FIRST TIME THAT DAY. TOOK THE CAR IN ONCE YEARS AGO AND THEY SAI…
Read full complaint
WHEN CAR IS DRIVEN DURING HOT DAYS AND YOU TURN THE CAR OFF, IT WILL NOT START AGAIN TELL THE CAR COOLS OFF. THIS HAPPENS DURING THE SUMMER MONTHS.NOW THAT THE CAR IS OLDER, IT WILL NOT START AT ALL DURING SOME OF THE HOT DAYS. THIS INCLUDE WHEN I START THE CAR FOR FIRST TIME THAT DAY. TOOK THE CAR IN ONCE YEARS AGO AND THEY SAID THEY FIXED IT BUT I KEEP HAVING THE SAME PROBLEM. THEY WANTED TO CHARGE ME MORE MONEY TO TRY TO FIX IT AGAIN. FRONT PASSAGE HEADLIGHTS ALWAYS BEEN FOGGY. CAR ALSO NEVER HUGGED THE ROAD RIGHT. DEALERSHIP COULD NEVER FIND THE PROBLEM.
NHTSA ODI #10777690
140,000 miles · Jun 11, 2015
Engine
RECENTLY PURCHASED 2000 HONDA ACCORD LX AND BROUGHT IT TO AN INDEPENDENT GARAGE FOR INSPECTION. UPON INSPECTION HE FOUND THE REAR PASSENGER SIDE F THE ENGINE SUB FRAME ROTTED OUT AND UNSAFE TO DRIVE. CAUSE WAS FROM THE AIR CONDITIONING DRAIN PIPE PLACEMENT.
NHTSA ODI #10724829
95,000 miles · Feb 13, 2015
EngineSteeringSuspension
I BOUGHT MY 2000 HONDA ACCORD 4CYL. ABOUT ONE MONTH AGO FROM AN OWNER. DROVE PERFECT FOR THE FIRST WEEK. THEN ONE MORNING MY BRAKE PEDAL GOT REALLY SOFT. AFTER CHECKING ALL FLUIDS AND LEAKS FOUND OUT THAT MY BRAKE LINES WERE RUSTED. I TOOK MY VEHICLE TO A SMALL SHOP TO GET MY BRAKE LINES REPLACED. I THEN GOT A CALL A FEW DAYS LA…
Read full complaint
I BOUGHT MY 2000 HONDA ACCORD 4CYL. ABOUT ONE MONTH AGO FROM AN OWNER. DROVE PERFECT FOR THE FIRST WEEK. THEN ONE MORNING MY BRAKE PEDAL GOT REALLY SOFT. AFTER CHECKING ALL FLUIDS AND LEAKS FOUND OUT THAT MY BRAKE LINES WERE RUSTED. I TOOK MY VEHICLE TO A SMALL SHOP TO GET MY BRAKE LINES REPLACED. I THEN GOT A CALL A FEW DAYS LATER SAYING I SHOULD GO DOWN AND CHECK SOMETHING THEY NOTICED ON MY CAR. TURNS OUT THE PASSENGER SUBFRAME IS RUSTED AND ROTTED OUT. EVERYTHING ELSE UNDERNEATH THE CAR IS CLEAN. THE MECHANIC SAID IT'S WEIRD THAT ONLY THE PASSENGER SIDE SUBFRAME IS RUSTED. HE TOLD ME IT COULD BREAK APART ANYTIME. BEING THAT IT'S NO LONGER SAFE TO DRIVE I HAVE TO GET IT REPLACED NOW. THE COST IS GOING TO BE ABOUT $1200 WITH LABOR. WHEN I GOT HOME I STARTED DOING SOME RESEARCH AND FOUND THAT THERE ARE THOUSANDS OF OTHER PEOPLE WHO ARE HAVING THE SAME PROBLEM AS I DO ON THEIR HONDA ACCORDS. HONDA SHOULD DO A RECALL ON THIS BEING IT'S A STRUCTURAL COMPONENT TO CAR AND SAFETY ISSUE. HOPEFULLY HONDA WILL RECALL THIS SUBFRAME PROBLEM AND REIMBURSE ME LATER. *TR
NHTSA ODI #10683359
60,000 miles · Jul 29, 2014
Engine
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER AND AN INDEPENDENT MECHANIC THREE TIMES FOR REPAIRS. THE CONTACT STATED THAT THE ENGINE OXYGEN SENSOR AND…
Read full complaint
TL* THE CONTACT OWNS A 2000 HONDA ACCORD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER AND AN INDEPENDENT MECHANIC THREE TIMES FOR REPAIRS. THE CONTACT STATED THAT THE ENGINE OXYGEN SENSOR AND THE CATALYTIC CONVERTER WERE BOTH REPLACED ON ALL THREE SEPARATE OCCASIONS. THE FAILURE PERSISTED AFTER EACH REPAIR WAS COMPLETED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10617310
95,000 miles · Mar 19, 2014
Engine
TL* THE CONTACT OWNS A 2006 HONDA ACCORD. THE CONTACT STATED WHILE THAT DRIVING APPROXIMATELY 65 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS MANEUVERED OFF THE ROADWAY WHEN THE CONTACT NOTICED THAT A TRAIL OF OIL WAS LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WH…
Read full complaint
TL* THE CONTACT OWNS A 2006 HONDA ACCORD. THE CONTACT STATED WHILE THAT DRIVING APPROXIMATELY 65 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS MANEUVERED OFF THE ROADWAY WHEN THE CONTACT NOTICED THAT A TRAIL OF OIL WAS LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT A SEAL NEEDED TO BE REPLACED IN THE COMPARTMENT OF THE TIMING BELT . THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. UPDATED 05/12/14 MA *TR
NHTSA ODI #10573568
149,500 miles · Sep 9, 2013
EngineFuel System, Gasoline
I FEAR MY VEHICLE IS BEING DENIED A RECALL DUE TO IT BY HONDA. MY VEHICLE FAILED ITS ANNUAL EMISSIONS TEST ON AUG. 22. THE STATE SENT ME A NOTICE INFORMING ME THAT MY 2000 HONDA ACCORD WAS PART OF A RECALL CLASS IN 2004 THAT WAS CONNECTED TO AN EMISSIONS PROBLEM. I RECEIVED NO ALERT FROM HONDA ABOUT SUCH A RECALL. WHEN I A…
Read full complaint
I FEAR MY VEHICLE IS BEING DENIED A RECALL DUE TO IT BY HONDA. MY VEHICLE FAILED ITS ANNUAL EMISSIONS TEST ON AUG. 22. THE STATE SENT ME A NOTICE INFORMING ME THAT MY 2000 HONDA ACCORD WAS PART OF A RECALL CLASS IN 2004 THAT WAS CONNECTED TO AN EMISSIONS PROBLEM. I RECEIVED NO ALERT FROM HONDA ABOUT SUCH A RECALL. WHEN I ASKED HONDA ABOUT IT THIS WEEK, THEY TOLD ME MY CAR WAS NOT PART OF THE RECALL CLASS. AND THEY CLAIMED THAT THEY COULD DETERMINE THIS BY MY CAR'S VIN -- THAT THE VIN INDICATED IT WAS NOT PART OF THE RECALL CLASS. SO I AM ASKING FOR YOUR HELP TO DETERMINE IF MY VEHICLE IS PART OF THE RECALL. BASED ON MY REVIEW OF YOUR "2004 ANNUAL SUMMARY OF EMISSION RELATED RECALL" (HTTP://WWW.EPA.GOV/OTAQ/CERT/RECALL/420B05022.PDF), IT SEEMS LIKE IT IS PART OF THE CLASS. THANK YOU FOR YOUR HELP. *TR
NHTSA ODI #10542767
164,869 miles · Nov 21, 2012
Engine
I FIRST NOTICED THAT WHEN THE CAR WAS IDLING, IT DIDN'T SOUND EXACTLY RIGHT. THEN ABOUT A WEEK LATER WE NOTICED THAT WHEN WE BEGAN TO STOP, THE CAR JUMPED. AFTER THAT WHEN YOU GO TO TAKE OFF FROM BEING STOPPED THE CAR WILL REV UP THE RPMS AND THEN THE MOTOR CATCHES UP AND JERKS INTO GEAR. WHEN WE CALLED AND TALKED TO A MECHAN…
Read full complaint
I FIRST NOTICED THAT WHEN THE CAR WAS IDLING, IT DIDN'T SOUND EXACTLY RIGHT. THEN ABOUT A WEEK LATER WE NOTICED THAT WHEN WE BEGAN TO STOP, THE CAR JUMPED. AFTER THAT WHEN YOU GO TO TAKE OFF FROM BEING STOPPED THE CAR WILL REV UP THE RPMS AND THEN THE MOTOR CATCHES UP AND JERKS INTO GEAR. WHEN WE CALLED AND TALKED TO A MECHANIC (HIGHLY KNOWN FOR TRANSMISSIONS) ABOUT IT, HE TOLD US THAT THEY HAVE BEEN HAVING A LOT OF PROBLEMS WITH THE 1998-2000 MODEL HONDAS, AFTER 100,000 MILES DOING THIS, THAT THE TRANSMISSION IS GOING OUT ON IT, THAT WE NEED TO HAVE IT REPLACED. I WAS EXPECTING TO HAVE THIS CAR FOR A LONG, LONG TIME, AS HONDA IS KNOWN FOR BEING A VERY RELIABLE CAR. *TR
NHTSA ODI #10485399
Official recalls
8Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 2001-2002 Acura 3.2CL, 2000-2003 Acura 3.5RL, 2000-2001 Acura 3.2TL, Honda CR-V and Honda Odyssey, 2001-2002 Acura MDX and 2000 Accord Coupe, Accord Sedan, Civic Coupe, and Civic Sedan vehicles. These vehicles may have received a replacement driver frontal air bag module as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the air bags in the vehicles, replacing the driver frontal air bag inflator with an inflator of a different design, as necessary, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138.
Jan 28, 2005
ON CERTAIN PASSENGER VEHICLES, THE INTERLOCK OPERATION OF THE IGNITION SWITCH MAY NOT FUNCTION PROPERLY, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO PARK.
Consequence & remedy
Consequence: IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT CONFIRMS INTERLOCK FUNCTION. VEHICLES WILL BE UPDATED WITH A REDESIGNED INTERLOCK LEVER FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Jun 7, 2004
ON CERTAIN PASSENGER VEHICLES, THE DIMMER CONTROL FOR THE INSTRUMENT PANEL LIGHTS COULD FAIL DUE TO HEAT BUILDUP.
Consequence & remedy
Consequence: IF THIS OCCURS, THE INSTRUMENT LIGHTS MAY FAIL AND, AT NIGHT, THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES, SUCH AS THE SPEEDOMETER.
Remedy: DEALERS WILL REPLACE A MULTIPLEX CONTROL UNIT FOR THE INSTRUMENT PANEL LIGHTS. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.
Mar 14, 2002
ON CERTAIN PASSENGER VEHICLES, A COMPONENT IN THE INFLATOR OF SOME PASSENGER AIR BAG MODULES WAS NOT WELDED PROPERLY.
Consequence & remedy
Consequence: AS A RESULT, THE AFFECTED AIR BAGS MAY NOT DEPLOY CORRECTLY IN A CRASH, INCREASING THE RISK OF INJURY TO A FRONT SEAT PASSENGER.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. OWNER NOTIFICATION BEGAN APRIL 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Feb 8, 2002
CERTAIN SEDANS AND COUPES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." CERTAIN REAR SEAT BELT BUCKLES WERE IMPROPERLY MANUFACTURED.
Consequence & remedy
Consequence: THE REAR SEAT BELTS WILL WORK PROPERLY AND PROVIDE PROTECTION IN A CRASH, BUT THE OWNER MAY EXPERIENCE DIFFICULTY UNFASTENING THE BELT AFTER THE CRASH.
Remedy: IN A PREVIOUS RECALL (01V-380), ONLY RIGHT AND LEFT BUCKLES WERE INSPECTED. THE REAR CENTER BUCKLE SHOULD ALSO BE INSPECTED AND CORRECTED IF NECESSARY. THIS RECALL IS BEING CONDUCTED ONLY FOR THE CENTER BUCKLE. DEALERS WILL INSPECT THE VEHICLES AND REPLACE THE SEAT BELT ASSEMBLIES THAT WERE IMRPOPERLY MANUFACTURED. ONLY BUCKLES THAT ARE MARKED (ON THE BACK SIDE OF THE BUCKLE) WITH AN ASSEMBLY NUMBER BEGINNING WITH 00185, 00186, OR 00187, WILL BE REPLACED. OWNERS SHOULD CONTACT THEIR DEALER FOR THIS REPLACEMENT. OWNER NOTIFICATION BEGAN MARCH 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009.
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN SEDANS AND COUPES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." CERTAIN REAR SEAT BELT BUCKLES WERE IMPROPERLY MANUFACTURED.
Consequence & remedy
Consequence: THE REAR SEAT BELTS WILL WORK PROPERLY AND PROVIDE PROTECTION IN A CRASH, BUT THE OWNER MAY EXPERIENCE DIFFICULTY UNFASTENING THE BELT AFTER THE CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES AND REPLACE THE SEAT BELT ASSEMBLIES THAT WERE IMPROPERLY MANUFACTURED. ONLY BUCKLES THAT ARE MARKED (ON THE BACK SIDE OF THE BUCKLE) WITH AN ASSEMBLY NUMBER BEGINNING WITH 00185, 00186, OR 00187, WILL BE REPLACED. OWNERS SHOULD CONTACT THEIR DEALER FOR THIS REPLACEMENT. OWNER NOTIFICATION BEGAN JANUARY 22, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009.
Jul 14, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SUSPENSION LOWER ARMS AND/OR CONTROL ARMS COULD BREAK DUE TO IMPROPER WELDING.
Consequence & remedy
Consequence: VEHICLE HANDLING AND CONTROL WOULD BE REDUCED.
Remedy: DEALERS WILL INSPECT AND REPLACE THE REAR SUSPENSION LOWER ARMS OR CONTROL ARMS IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE05043 · Srs Readiness Indicator Illumination
Opened Aug 12, 2005 · Closed Mar 24, 2006
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
THE SUBJECT VEHICLES ARE DESIGNED WITH AN OCCUPANT POSITION DETECTION SYSTEM (OPDS) FOR THE PASSENGER SEAT TO SUPPRESS THE SIDE AIRBAG IN THE EVENT OF AN OUT-OF-POSITION OCCUPANT.ON SOME VEHICLES, THE OPDS UNIT AND SENSOR GRID MAY BE SUSCEPTIBLE TO HIGH MOISTURE CONTENT AND/OR TO SPORADIC ELECTRICAL INTERFERENCE THAT WOULD RESULT IN THE ILLUMINATION OF THE SRS READINESS INDICATOR.IN THIS CONDITION, OPDS SUPPRESSION WILL NOT FUNCTION, BUT THE SIDE AIRBAG WILL STILL DEPLOY IN THE EVENT OF A SIDE CRASH. HONDA ISSUED A TECHNICAL SERVICE BULLETIN IN APRIL 2004 TO ADDRESS THIS PROBLEM. HOWEVER, THE PROBLEM PERSISTS EVEN AFTER THE WARRANTY PERIOD EXPIRES.AS A RESULT, SOME OWNERS MAY NOT BE OBTAINING THE NECESSARY REMEDIAL SERVICE WORK.CONTINUED ILLUMINATION OF THE SRS INDICATOR CAN MASK THE DETECTION OF OTHER AIRBAG COMPONENT FAULTS IF THEY OCCUR. IN MARCH 2006, HONDA ISSUED A SERVICE BULLETIN (06-009) TO EXTEND THE WARRANTY ON SRS ILLUMINATION AND OPDS ISSUES TO 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST).HONDA WILL SEND NOTIFICATION LETTERS TO OWNERS OF THE SUBJECT VEHICLES AND WILL PROVIDE A NO COST REPLACEMENT OF THE OPDS UNIT AS NEEDED.IN ADDITION, OTHER MY 1999-04 HONDA AND ACURA VEHICLES ARE ALSO COVERED BY THE BULLETIN.THIS ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags:frontal:sensor/control MODULE-INACTIVE
THE SUBJECT VEHICLES ARE DESIGNED WITH AN OCCUPANT POSITION DETECTION SYSTEM (OPDS) FOR THE PASSENGER SEAT TO SUPPRESS THE SIDE AIRBAG IN THE EVENT OF AN OUT-OF-POSITION OCCUPANT.ON SOME VEHICLES, THE OPDS UNIT AND SENSOR GRID MAY BE SUSCEPTIBLE TO HIGH MOISTURE CONTENT AND/OR TO SPORADIC ELECTRICAL INTERFERENCE THAT WOULD RESULT IN THE ILLUMINATION OF THE SRS READINESS INDICATOR.IN THIS CONDITION, OPDS SUPPRESSION WILL NOT FUNCTION, BUT THE SIDE AIRBAG WILL STILL DEPLOY IN THE EVENT OF A SIDE CRASH. HONDA ISSUED A TECHNICAL SERVICE BULLETIN IN APRIL 2004 TO ADDRESS THIS PROBLEM. HOWEVER, THE PROBLEM PERSISTS EVEN AFTER THE WARRANTY PERIOD EXPIRES.AS A RESULT, SOME OWNERS MAY NOT BE OBTAINING THE NECESSARY REMEDIAL SERVICE WORK.CONTINUED ILLUMINATION OF THE SRS INDICATOR CAN MASK THE DETECTION OF OTHER AIRBAG COMPONENT FAULTS IF THEY OCCUR. IN MARCH 2006, HONDA ISSUED A SERVICE BULLETIN (06-009) TO EXTEND THE WARRANTY ON SRS ILLUMINATION AND OPDS ISSUES TO 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST).HONDA WILL SEND NOTIFICATION LETTERS TO OWNERS OF THE SUBJECT VEHICLES AND WILL PROVIDE A NO COST REPLACEMENT OF THE OPDS UNIT AS NEEDED.IN ADDITION, OTHER MY 1999-04 HONDA AND ACURA VEHICLES ARE ALSO COVERED BY THE BULLETIN.THIS ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
THE SUBJECT VEHICLES ARE DESIGNED WITH AN OCCUPANT POSITION DETECTION SYSTEM (OPDS) FOR THE PASSENGER SEAT TO SUPPRESS THE SIDE AIRBAG IN THE EVENT OF AN OUT-OF-POSITION OCCUPANT.ON SOME VEHICLES, THE OPDS UNIT AND SENSOR GRID MAY BE SUSCEPTIBLE TO HIGH MOISTURE CONTENT AND/OR TO SPORADIC ELECTRICAL INTERFERENCE THAT WOULD RESULT IN THE ILLUMINATION OF THE SRS READINESS INDICATOR.IN THIS CONDITION, OPDS SUPPRESSION WILL NOT FUNCTION, BUT THE SIDE AIRBAG WILL STILL DEPLOY IN THE EVENT OF A SIDE CRASH. HONDA ISSUED A TECHNICAL SERVICE BULLETIN IN APRIL 2004 TO ADDRESS THIS PROBLEM. HOWEVER, THE PROBLEM PERSISTS EVEN AFTER THE WARRANTY PERIOD EXPIRES.AS A RESULT, SOME OWNERS MAY NOT BE OBTAINING THE NECESSARY REMEDIAL SERVICE WORK.CONTINUED ILLUMINATION OF THE SRS INDICATOR CAN MASK THE DETECTION OF OTHER AIRBAG COMPONENT FAULTS IF THEY OCCUR. IN MARCH 2006, HONDA ISSUED A SERVICE BULLETIN (06-009) TO EXTEND THE WARRANTY ON SRS ILLUMINATION AND OPDS ISSUES TO 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST).HONDA WILL SEND NOTIFICATION LETTERS TO OWNERS OF THE SUBJECT VEHICLES AND WILL PROVIDE A NO COST REPLACEMENT OF THE OPDS UNIT AS NEEDED.IN ADDITION, OTHER MY 1999-04 HONDA AND ACURA VEHICLES ARE ALSO COVERED BY THE BULLETIN.THIS ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05002 · IGNITION-PARK Interlock
Opened Jan 13, 2005 · Closed Feb 2, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Additional source detail variants (3)
Electrical System
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
DP04006 · IGNITION-PARK Interlock
Opened Oct 8, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Additional source detail variants (2)
Electrical System:ignition
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration