1999 HONDA ACCORD, TRANSMISSION FAILED AFTER ONLY 59,000 MILES! ENGINE LIGHT CAME ON ONLY 5 MILES BEFORE I TOOK IT TO AUTHORIZED HONDA DEALER WHO DEEMED IT UNSAFE TO DRIVE! I DO NOT HAVE ALL THE SERVICE RECORDS BUT I KNOW I DID TAKE IT FOR EVERY SINGLE SERVICE SUGGESTED IN THE MANUAL. NOT ONLY DOES HONDA KNOW ABOUT THIS PROBLEM …
Read full complaint
1999 HONDA ACCORD, TRANSMISSION FAILED AFTER ONLY 59,000 MILES! ENGINE LIGHT CAME ON ONLY 5 MILES BEFORE I TOOK IT TO AUTHORIZED HONDA DEALER WHO DEEMED IT UNSAFE TO DRIVE! I DO NOT HAVE ALL THE SERVICE RECORDS BUT I KNOW I DID TAKE IT FOR EVERY SINGLE SERVICE SUGGESTED IN THE MANUAL. NOT ONLY DOES HONDA KNOW ABOUT THIS PROBLEM (IT EXTENDED THE WARRANTY ON 2000 AND 2001 MODELS, WHICH ARE IDENTICAL TO THE 1999) BUT JUST IN MY SMALL TOWN ALONE I PERSONALLY KNOW OF 2 OTHER PEOPLE WHO HAD THE SAME PROBLEM!AFTER MUCH PRESSING, HONDA AGREED TO PAY FOR LESS THAN A THIRD OF THE $5000.00 COST OF NEW TRANSMISSION BIG DEAL! ALSO THEY REFUSED TO PAY FOR MY RENTAL (NOW GOING ON 2 WEEKS)....IT TOOK THEM OVER W EEK TO RESPOND TO MY COMPLAINT LEAVING ME EITHER DRIVING AN UNSAFE (IN THEIR WORDS) CAR OR RENTING 1! *LA
NHTSA ODI #10054905
55,000 miles · Jan 15, 2004
Power Train
TRANSMISSIONS SLIPS AND SHIFTS ROUGHLY AND INCONSISTENTLY. WARRANTY HAS BEEN EXTENDED BUT ONLY FOR '00 & '01 MODELS. SAME FAULTY TRANSMISSION STANDARD WITH 1999 ACCORDS. IT IS ONLY A MATTER OF TIME BEFORE PEOPLE START GETTING HIT AND DO THE HITTING AS SHIFTING BECOMES UNPREDICTABLE.
NHTSA ODI #10070141
75,000 miles · Jan 15, 2004
Power Train
DIFFERENTIAL SEALS ON 1999 HONDA ACCORD EXL ARE LEAKING.*MR (NAR) TRANSMISSION NEEDS TO BE REPLACED. *CB
NHTSA ODI #10054156
90,000 miles · Jan 13, 2004
Power Train
POWER TRAIN: AUTOMATIC TRANSMISSION - ACCORD 1999 EX-V6 TRANSMISSION SHIFTS HARD AND SOMETIMES IT EVEN SLIPS (PAUSES WHEN SHIFTING GEAR). SUSPECT THE PROBLEM TO BE SIMILAR TO MODEL YEAR 2000 AND 2001, BUT NO RECALL ISSUED FOR 1999.
NHTSA ODI #10053121
45,500 miles · Jan 12, 2004
Power Train
1999 HONDA ACCORD NEEDED TRANSMISSION REPLACED AT 40,000 AND NOW IS HAVING PROBLEMS AGAIN AT 46,000 MILES. A REPLACEMENT IS NEEDED. CAR IS SLOW TO MOVE IN 1ST AND DOES NOT SHIFT PROPERLY. HARD TO GET MOVING WITH TRAFFIC AND IS DANGEROUS WHEN FAST ACCELERATION IS NEEDED IN TRAFFIC. *LA
NHTSA ODI #10052881
Mileage unknown · Jan 2, 2004
Power Train
MY HONDA ACCORD LX 4DR 1999 MODEL HAS TRANSMISSION PROBLEM. IT DOES NOT GO LITTLE UPSLOPE ON REVESE GEAR. I FOUND LOT OF COMPLAINT ON THE WEB ABOUT REVERSE GEAR SLEEPING GOING UPSLOPE.*AK
NHTSA ODI #10051506
70,000 miles · Dec 30, 2003
Power Train
INTERMITTENTLY, THE TRANSMISSION IS SLOW TO ENGAGE FROM REVERSE TO DRIVE. ALSO THE TRANSMISSION WILL SLIP WHILE UP SHIFITING, CAUSING THE CAR TO STALL AND THEN JERK INTO GEAR. WHEN DOWN SHIFITING, THE CAR WOULD STALL WHEN SHIFTING FROM 3RD TO 2ND GEAR. THE DEALER STATES THAT THE TRANSMISSION IS DEFECVTIVE AND NEEDS TO BE REPLAC…
Read full complaint
INTERMITTENTLY, THE TRANSMISSION IS SLOW TO ENGAGE FROM REVERSE TO DRIVE. ALSO THE TRANSMISSION WILL SLIP WHILE UP SHIFITING, CAUSING THE CAR TO STALL AND THEN JERK INTO GEAR. WHEN DOWN SHIFITING, THE CAR WOULD STALL WHEN SHIFTING FROM 3RD TO 2ND GEAR. THE DEALER STATES THAT THE TRANSMISSION IS DEFECVTIVE AND NEEDS TO BE REPLACED. HONDA HAS EXTENDED THE WARRANTIES ON THE 2000/01 MODEL YEARS WHICH HAVE THE SAME V6 AUTOMATIC TRANSMISSION, BUT NOT ON THE 99 HONDAS.
NHTSA ODI #10051347
75,000 miles · Dec 10, 2003
Power Train
AUTOMATIC TRANSMISSION FAILURE. *LA
NHTSA ODI #10049516
81,000 miles · Nov 25, 2003
Power Train
WHILE AT SLOW SPEED THE TRANSMISSON PAUSED AND KICKED FORWARD ON A 1999 HONDA ACCORD EX V6 WITH ONLY 78,000 PLUS MILES. *LA
NHTSA ODI #10047581
80,000 miles · Nov 23, 2003
Power Train
TRANSMISSION FAILURE: HARSH SHIFTING. CAR WOULD REV AND HAVE TROUBLE ENGAGING INTO GEAR FROM TO GEAR. HIT THE GAS PEDAL, BUT CAR WOULD BARELY MOVE . VERY DANGEROUS CONDITIONS!! ALMOST GOT INTO A CAR ACCIDENT. *LA
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
ON CERTAIN PASSENGER VEHICLES, THE INTERLOCK OPERATION OF THE IGNITION SWITCH MAY NOT FUNCTION PROPERLY, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO PARK.
Consequence & remedy
Consequence: IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT CONFIRMS INTERLOCK FUNCTION. VEHICLES WILL BE UPDATED WITH A REDESIGNED INTERLOCK LEVER FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Additional source detail variants (3)
Electrical System
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Additional source detail variants (2)
Electrical System:ignition
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration