IllustrationHONDA ACCORD IGNITION SWITCH FAILURE LEADING TO ENGINE CUT OUT ON HIGHWAY (GOING 80), ELECTRICAL SHORT CAUSED SMOKING FROM DASH. *TR
1999 Honda Accord
Owner reports · Recalls · Investigations
More warning signs than most Accord years
Owner complaints for the 1999 Honda Accord are substantially higher than the model-year median of 356.
About this comparison →How this year compares
Owner complaints by model year
Compare all Accord years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
4025–50K
9150–75K
13675–100K
198100–150K
154150K+
640 reports with mileage · 495 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 388 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 246 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
77 crash reports5 fire reports37 injury reports
Electrical System complaints
388 reportsTL*THE CONTACT OWNS A 1999 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE WOULD RANDOMLY STALL WHILE DRIVING AT ANY SPEED. THE MOST RECENT FAILURE OCCURRED AT 25 MPH. THE VEHICLE WOULD RESTART AFTER 5 OR 6 ATTEMPTS AND WOULD RUN NORMALLY. THE FAILURE WOULD NOT OCCUR EVERY TIME THE VEHICLE WAS DRIVEN, BUT EVERY 4 OR 5 TIME…
Read full complaint
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. THE CONTACT STATED THAT THE VEHICLE WOULD RANDOMLY STALL WHILE DRIVING AT ANY SPEED. THE MOST RECENT FAILURE OCCURRED AT 25 MPH. THE VEHICLE WOULD RESTART AFTER 5 OR 6 ATTEMPTS AND WOULD RUN NORMALLY. THE FAILURE WOULD NOT OCCUR EVERY TIME THE VEHICLE WAS DRIVEN, BUT EVERY 4 OR 5 TIMES THE ENGINE WAS STARTED. THROUGH ONLINE RESEARCH, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 02V120000 (ELECTRICAL SYSTEM:IGNITION:SWITCH) FOR THE SAME YEAR, MAKE, AND MODEL VEHICLE. THE MANUFACTURER STATED THAT THE RECALL DID NOT APPLY TO HER VIN. THE CONTACT FEELS THAT IF THE VEHICLE IS EXPERIENCING THE SAME FAILURE, IT SHOULD BE INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 118,000 AND CURRENT MILEAGE WAS 120,000. UPDATED 09/15/08 *BF THE CONSUMER STATED THE IGNITION SWITCH FAILED AS DESCRIBED IN THE RECALL. THE CONSUMERS VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED. UPDATED 09/17/08. *JB
MILEAGE AT START OF PROBLEM,, APP 60,000 NOW 130,000 IN 08! I BOUGHT MY 99 ACCORD WITH 56,000 MILES IN 2003. I WAS CALLED ABOUT THE RECALL ON THE IGNITION SWITCH, AND HONDA REPLACED IT FOR FREE, ALTHOUGH AT THAT TIME I WAS NOT HAVING ANY PROBLEMS. OK I STARTED HAVING PROBLEMS WITH MY CAR STALLING. FIRST TIME WAS ON I40 GOING …
Read full complaint
MILEAGE AT START OF PROBLEM,, APP 60,000 NOW 130,000 IN 08! I BOUGHT MY 99 ACCORD WITH 56,000 MILES IN 2003. I WAS CALLED ABOUT THE RECALL ON THE IGNITION SWITCH, AND HONDA REPLACED IT FOR FREE, ALTHOUGH AT THAT TIME I WAS NOT HAVING ANY PROBLEMS. OK I STARTED HAVING PROBLEMS WITH MY CAR STALLING. FIRST TIME WAS ON I40 GOING APP 75. I WAS IN THE OUTER FREAKING LANE AND IT JUST TURNED OFF. I LIVED WITH THIS VERY FREAKING HAZARDOUS PROBLEM FOR A LONG TIME BECAUSE I DIDN'T TRUST HONDA AND MONEY (JUST NOTE ONE OF THE PHONE CALLS FROM HONDA THE MAN TOLD ME HE THOUGHT IT WAS MY IGNITION SWITCH AGAIN AND THAT THEY WOULDN'T BE RESPONSIBLE FOR THE COST OF REPAIR THIS FREAKING TIME BUT LATER DECIDED IT WAS SOMETHING ELSE,!)I WAS IN COLLEGE TAKING MY EMT PRACTICALS WITH AN EMS SYSTEM AND WAS HAVING TO DRIVE TO ANOTHER COUNTY AND BE IN CONTACT VIA CELL PHONE WITH HONDA, AND BORROW MY DADS TRUCK!! THEY HAD MY CAR FOR DAYS AND KEEP CALLING AND ASKING IF ONE OF THERE MECHANICS COULD DRIVE MY CAR TO LUNCH ,, AND IF THEY COULD TAKE IT HOME OVER NIGHT AND SO ON, AND FINALLY SAID IT WOULDN'T STALL FOR THEM!!!!! I WAS '!@#$%! THEY DID ANOTHER DIAGNOSTIC TEST OF 75$ AND MY CHECK ENGINE LIGHT WASN'T EVEN ON! THEY ALSO SAID I NEEDED NEW SPARK PLUGS, I HAD NEW SPARK PLUGS AND IM NOT AN IDIOT,, THERE WAS NOTHING ABSOLUTELY NOTHING WRONG WITH THE ?!@#$% THINGS. THEY ALSO EVENTUALLY DECIDED THAT I NEEDED MY FUEL SYSTEM CLEANED, BECAUSE THEY REALLY DIDN'T KNOW WHAT TO DO AND THIS IS WHAT THEY SAID THEMSELVES! THEY TOLD ME THEY WOULDN'T CHARGE ME FOR THE DIAGNOSTIC FEE IF I GOT THE 120$ NEW SPARK PLUGS, MINE WERE NEW AND WORKING VERY WELL. SO OF COURSE I HAD NO OPTION. AFTER READING S FEW COMPLAINTS HERE AND ON OTHER SITES, I AM SEEING THAT THEY TOTALLY TOOK ME FOR OVER 500$ AND THAT MY PROBLEM WAS IN MY IGNITION SWITCH,, IM WONDERING IF THEY SNUCK AND REPLACED IT AGAIN BEHIND MY BACK JUST TO CHARGE ME FOR OTHER '!@#$% THEY DIDN'T DO. I HATE HONDA I HATE HONDA,, I WANT SOME ?!@#$% JUSTICE. *TR
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. WHILE DRIVING AT ANY SPEED, THE ENGINE SHUTS OFF. WHEN THE CONTACT WIGGLES THE IGNITION SWITCH, THE VEHICLE WILL SOMETIMES RESTART. A MECHANIC INFORMED HIM OF NHTSA CAMPAIGN ID NUMBERS 02V120000, 03V423000, AND 05V025000 (ELECTRICAL SYSTEM: IGNITION:SWITCH); HOWEVER, THE VIN WAS NOT IN…
Read full complaint
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. WHILE DRIVING AT ANY SPEED, THE ENGINE SHUTS OFF. WHEN THE CONTACT WIGGLES THE IGNITION SWITCH, THE VEHICLE WILL SOMETIMES RESTART. A MECHANIC INFORMED HIM OF NHTSA CAMPAIGN ID NUMBERS 02V120000, 03V423000, AND 05V025000 (ELECTRICAL SYSTEM: IGNITION:SWITCH); HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALLS. THE CURRENT AND FAILURE MILEAGES WERE 110,000. UPDATED 07/29/08 *BF UPDATED 07/29/08
MY 99 HONDA ACCORD EX CUTS OFF WHILE TRAVELING DOWN THE ROAD WITHOUT WARNING. THIS IS DUE TO IGNITION SENSOR WHICH I CORRECTED SHORTLY AFTER BUYING MY CAR WITH RICK HENDRICK HONDA. NOW YEARS LATER THERE IS A RECALL ON THE IGNITION INTERLOCK. BUT, HONDA WILL NOT FIX THE IGNITION SENOR BECAUSE IT HAS NOTHING TO DO WITH THE RECAL…
Read full complaint
MY 99 HONDA ACCORD EX CUTS OFF WHILE TRAVELING DOWN THE ROAD WITHOUT WARNING. THIS IS DUE TO IGNITION SENSOR WHICH I CORRECTED SHORTLY AFTER BUYING MY CAR WITH RICK HENDRICK HONDA. NOW YEARS LATER THERE IS A RECALL ON THE IGNITION INTERLOCK. BUT, HONDA WILL NOT FIX THE IGNITION SENOR BECAUSE IT HAS NOTHING TO DO WITH THE RECALL. CERTAINLY THIS IS A SERIOUS SAFETY MATTER AND I FEEL IT'S UNFAIR THAT HONDA WILL ONLY FIX HALF OF THE PROBLEM AND BURDEN THE COST TO ME. I DON'T THINK I'M ALONE WITH THIS TYPE OF PROBLEM. PLEASE INVESTIGATE THIS MATTER. I FEEL I SHOULDN'T HAVE TO PAY FOR THIS IGNITION SENSOR. I HAD THE RECALL IGNITION INTERLOCK FIX AT HONDA OF COLUMBIA, P.O. BOX 8234 , COLUMBIA, SC 29202. *TR
WHILE DRIVING, MY CAR WILL STALL. I THEN HAVE TO JIGGLE THE KEY TO START THE CAR UP. SOMETIME IT TAKES SEVERAL TIMES TO GET IT GOING WHILE IN THE MIDDLE OF TRAFFIC. IT OCCURS ON ALMOST A DAILY BASIS AND OCCURS WHILE STOPPED A LIGHT TO EVEN MORE FRIGHTENING WHILE DRIVING IN FOUR GEAR. WHILE THIS HAS YET TO CAUSE AN ACCIDENT, T…
Read full complaint
WHILE DRIVING, MY CAR WILL STALL. I THEN HAVE TO JIGGLE THE KEY TO START THE CAR UP. SOMETIME IT TAKES SEVERAL TIMES TO GET IT GOING WHILE IN THE MIDDLE OF TRAFFIC. IT OCCURS ON ALMOST A DAILY BASIS AND OCCURS WHILE STOPPED A LIGHT TO EVEN MORE FRIGHTENING WHILE DRIVING IN FOUR GEAR. WHILE THIS HAS YET TO CAUSE AN ACCIDENT, THE POSSIBILITY IS VERY HIGH. I RESEARCHED THIS PROBLEM AND FOUND THAT THERE WAS A RECALL IN 2002 (#02V120000). I CALLED HONDA TO FIND OUT WHY I WAS NEVER NOTIFIED OR WHY THE DEAL DID NOT FIX DURING MY COUNTLESS ROUTINE MAINTENANCE VISITS. OUT OF 1,000,000 RECALLS I WAS TOLD MY VIN WAS NOT PART OF THE RECALL. THIS IS AN OBVIOUS ISSUE THAT HAS BEEN DOCUMENTED FOR THE YEAR OF MY CAR, BUT I AM BEING TOLD IT WASN'T PART OF THE RECALL. THIS IS VERY DANGEROUS AND I AM SURE THERE ARE OTHERS WITH THE SAME PROBLEM. *TR
I HAVE A 1999 HONDA ACCORD LX WITH A 4 CYLINDER VTEC ENGINE. 1-12-08 WHILE DRIVING AT LOWER SPEEDS--TYPICALLY 30 TO 45 MPH THE CAR WILL JERK AND CHANGE GEARS WHEN NOT NEEDED. AT HIGHWAY SPEEDS THE CAR STALLS AND I HAVE TO SHIFT TO NEUTRAL TO RESTART. UPDATE: MAY 2008 AND I HAVE NO REVERSE GEAR AT ALL. AFTER READING ALL THE C…
Read full complaint
I HAVE A 1999 HONDA ACCORD LX WITH A 4 CYLINDER VTEC ENGINE. 1-12-08 WHILE DRIVING AT LOWER SPEEDS--TYPICALLY 30 TO 45 MPH THE CAR WILL JERK AND CHANGE GEARS WHEN NOT NEEDED. AT HIGHWAY SPEEDS THE CAR STALLS AND I HAVE TO SHIFT TO NEUTRAL TO RESTART. UPDATE: MAY 2008 AND I HAVE NO REVERSE GEAR AT ALL. AFTER READING ALL THE COMPLAINTS I WOULD REALLY LIKE TO KNOW WHY HONDA HAS NOT PUT A RECALL ON THESE 1998 AND 1999 TRANSMISSIONS. WHY? DOES SOMEONE REALLY HAVE TO DIE BEFORE THEY FIX THEIR OWN PROBLEM? I AM CALLING HONDA IN THE MORNING AND IF I DON'T GET SATISFACTORY RESULTS I WOULD LIKE TO START A NEGATIVE CAMPAIGN AGAINST HONDA. THIS IS CRAZY AND I WANT ANSWERS. *TR
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. THE CONTACT HAD HIS VEHICLE REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 02V120000 (ELECTRICAL SYSTEM:IGNITION:SWITCH) ON SEPTEMBER 27, 2002. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SPORADICALLY STALL WITHOUT WARNING. THE MAJORITY OF THE TIME, THE VEHICLE COULD IMMEDIATELY BE…
Read full complaint
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. THE CONTACT HAD HIS VEHICLE REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 02V120000 (ELECTRICAL SYSTEM:IGNITION:SWITCH) ON SEPTEMBER 27, 2002. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SPORADICALLY STALL WITHOUT WARNING. THE MAJORITY OF THE TIME, THE VEHICLE COULD IMMEDIATELY BE RESTARTED AFTER IT STALLED. THE DEALER STATED THAT BECAUSE HIS VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL, THEY WOULD NOT PROVIDE A FREE REMEDY. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 141,000 AND CURRENT MILEAGE WAS 150,000. UPDATED 4/29/08 *CN
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. WHILE DRIVING AT ANY SPEED OR IDLING AT A TRAFFIC LIGHT, THE VEHICLE WOULD SHUT OFF. OCCASIONALLY, THE ENGINE WOULD NOT TURN OVER AND START. THE DEALER STATED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT STATED THAT WHEN HE TOUCHES ANY METAL PORTION OF THE VEHICLE IN CO…
Read full complaint
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. WHILE DRIVING AT ANY SPEED OR IDLING AT A TRAFFIC LIGHT, THE VEHICLE WOULD SHUT OFF. OCCASIONALLY, THE ENGINE WOULD NOT TURN OVER AND START. THE DEALER STATED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT STATED THAT WHEN HE TOUCHES ANY METAL PORTION OF THE VEHICLE IN COLD WEATHER, A SHOCK OCCURS. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 160,000 AND FAILURE MILEAGE WAS 130,000.
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. THE VEHICLE STALLED AT HIGH AND LOW RATES OF SPEED. THIS FAILURE HAS OCCURRED SIX TIMES. THE DEALER STATED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. SINCE THE REPAIR WAS MADE PREVIOUSLY DUE TO A RECALL, THE DEALER WILL NOT REPAIR IT AGAIN FREE OF CHARGE. THE COST TO REPAI…
Read full complaint
TL*THE CONTACT OWNS A 1999 HONDA ACCORD. THE VEHICLE STALLED AT HIGH AND LOW RATES OF SPEED. THIS FAILURE HAS OCCURRED SIX TIMES. THE DEALER STATED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. SINCE THE REPAIR WAS MADE PREVIOUSLY DUE TO A RECALL, THE DEALER WILL NOT REPAIR IT AGAIN FREE OF CHARGE. THE COST TO REPAIR THE VEHICLE WAS $270.00. THE FAILURE MILEAGE WAS 125000 AND THE CURRENT MILEAGE WAS 126000.
Official recalls
420V026000 · Air Bags:frontal:driver Side:inflator Module
Jan 17, 2020
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
05V025000 · Electrical System:ignition:switch
Jan 28, 2005
ON CERTAIN PASSENGER VEHICLES, THE INTERLOCK OPERATION OF THE IGNITION SWITCH MAY NOT FUNCTION PROPERLY, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO PARK.
Consequence & remedy
Consequence: IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT CONFIRMS INTERLOCK FUNCTION. VEHICLES WILL BE UPDATED WITH A REDESIGNED INTERLOCK LEVER FREE OF CHARGE. THE RECALL BEGAN ON MARCH 7, 2005. OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
03V423000 · Electrical System:ignition:switch
Oct 27, 2003
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE IGNITION SWITCH MAY WEAR EXCESSIVELY AND PREVENT PROPER INTERLOCK OPERATION, MAKING IT POSSIBLE TO TURN THE IGNITION KEY TO THE "OFF" POSITION AND REMOVE THE KEY WITHOUT SHIFTING THE TRANSMISSION TO "PARK."
Consequence & remedy
Consequence: IF THE VEHICLE OPERATOR DOES NOT SHIFT TO "PARK" BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL PERFORM AN INSPECTION PROCEDURE THAT DETERMINES THE AMOUNT OF CYLINDER BODY WEAR. IF SIGNIFICANT WEAR IS INDICATED, THE DEALER WILL REPLACE THE CYLINDER BODY, COLLAR, AND LATCH PLATE. IF NO SIGNS OF WEAR ARE INDICATED, DEALERS WILL REPLACE THE LATCH PLATE WITH A REDESIGNED PART. OWNER NOTIFICATION BEGAN DECEMBER 8, 2003. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
02V120000 · Electrical System:ignition:switch
May 16, 2002
ON CERTAIN SEDANS, COUPES, HATCHBACKS, AND SPORT UTILITY VEHICLES, ELECTRICAL CONTACTS IN THE IGNITION SWITCH CAN DEGRADE DUE TO THE HIGH ELECTRICAL CURRENT PASSING THROUGH THE SWITCH WHEN THE VEHICLE IS STARTED.
Consequence & remedy
Consequence: WORN CONTACTS COULD CAUSE THE ENGINE TO STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN JUNE 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE05002 · IGNITION-PARK Interlock
Opened Jan 13, 2005 · Closed Feb 2, 2005
Status: closed (inferred from source dates) · Electrical System; Electrical System:ignition; Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Additional source detail variants (3)
Electrical System
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
Electrical System:ignition:switch
THE ABOVE FAILURE REPORT COUNTS ARE FOR MODEL YEAR (MY) 1999 - 2001 HONDA ACCORD MODELS THAT WERE NOT WITHIN THE SCOPE OF A RELATED HONDA RECALL ACTION (NHTSA 03V423); THESE VEHICLES WERE INVESTIGATED BY ODI UNDER DEFECT PETITION (DP) 04-006.COMPLAINT INFORMATION FOR OTHER MODELS AND MODEL YEARS WAS NOT OBTAINED BY ODI.THE NOTED POPULATION INDICATES THE NUMBER OF VEHICLES (INCLUDING THE MY 2002 ACCORD PLUS THE PRELUDE AND TL MODELS) THAT ARE WITHIN THE SCOPE OF HONDA?S NEW RECALL (NHTSA 05V-025, HONDA P68, P69); 402,525 OF THESE WERE INVESTIGATED IN DP04-006.SEEPART 573 DOCUMENTS RELATED TO 05V-025 FOR FURTHER DETAIL ON OTHER MODELS AND MYS.ODI NOTES THAT, ACCORDING TO HONDA?S ANALYSIS, INTERLOCK SYSTEM WARRANTY RATES FOR THE TL AND PRELUDE MODELS INVOLVED IN 05V-025 ARE SIMILAR TO THOSE OF THE ACCORD MODELS.INFORMATION PROVIDED BY HONDA DURING DP04-006 INDICATES THAT CERTAIN VEHICLES CONTAINING INTERLOCK SYSTEMS MADE BY ITS JAPANESE LOCK MANUFACTURING FACILITY MAY CONTAIN DEFECTIVE INTERNAL COMPONENTS.IN COMBINATION WITH CERTAIN WEAR AND USAGE FACTORS, THIS MAY LEAD TO A CONDITION THAT PREVENTS THE SYSTEM FROM BLOCKING REMOVAL OF THE IGNITION KEY WHEN THE VEHICLE IS NOT IN PARK.IF THE DRIVER LEAVES THE TRANSMISSION IN A NON-PARK POSITION AND FAILS TO SET THE HAND BRAKE WHEN PARKING, THE VEHICLE MAY ROLL AWAY AND CRASH.INTERLOCK SYSTEMS MANUFACTURED BY HONDA?S U.S. LOCK MANUFACTURER DO NOT APPEAR TO CONTAIN THIS DEFECT AND ARE THEREFORE NOT INCLUDED IN THE RECALL ACTION. IN A LETTER DATED JANUARY 27, 2005, HONDA ADVISED THAT IT WILL CONDUCT A SAFETY RECALL TO EITHER UPGRADE (FOR OPERATIVE SYSTEMS) OR REPAIR (FOR INOPERATIVE SYSTEMS) SUBJECT INTERLOCK SYSTEMS WITH NEW DESIGN LEVEL COMPONENTS THAT DO NOT CONTAIN THE DEFECT.
DP04006 · IGNITION-PARK Interlock
Opened Oct 8, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Additional source detail variants (2)
Electrical System:ignition
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
Electrical System:ignition:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) PRODUCED AN INFORMATION REQUEST (IR) LETTER DATED OCTOBER 14, 2004 WHICH DEFINED THE SUBJECT VEHICLES AS MODEL YEAR 1999 - 2001 HONDA ACCORD VEHICLES WHICH WERE NOT WITHIN THE SCOPE OF PRIOR RECALL ACTION (03V423) HONDA CONDUCTED TO RESOLVE AN INTERLOCK DEFECT.HONDA SUBMITTED RESPONSES ON NOVEMBER 29 AND DECEMBER 21, 2004.THE FAILURE REPORTS NOTED ABOVE HAVE BEEN DETERMINED FROM ODI'S ANALYSIS OF NHTSA'S COMPLAINT DATABASE AND AN INITIAL ANALYSIS OF THE MANUFACTURER'S IR RESPONSE DATA (FURTHER ANALYSIS REQUIRED).SOME OF THE HONDA REPORTS ARE DUPLICATIVE OF ODI.TAKING INTO ACCOUNT A SHORTER SERVICE LIFE, THE FAILURE INCIDENCE OF THE SUBJECT VEHICLES IS SIMILAR TO THAT DETERMINED WHEN ODI CONDUCTED PRELIMINARY EVALUATION (PE) 03-013, WHICH INVOLVED INTERLOCK FAILURES ON OLDER ACCORDS SUBSEQUENTLY RECALLED UNDER THE 03V423 ACTION.ACCORDINGLY, THE PETITON IS GRANTED AND ODI HAS OPENED PE05-002 TO FURTHER INVESTIGATE THE MATTER.
EA03017 · IGNITION-PARK Interlock
Opened Sep 9, 2003 · Closed Dec 17, 2003
Status: closed (inferred from source dates) · Electrical System:ignition:switch; Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Additional source detail variants (2)
Electrical System:ignition:switch
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF HONDA COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE ONE INJURY OCCURRED WHEN A ROLLAWAY VEHICLE STRUCK THE EXITING OPERATOR WHO HAD INADVERTENTLY PARKED THE VEHICLE IN AN UNSECURED STATE (NOT IN PARK, BRAKE NOT ENGAGED).HONDA IDENTIFIED THE WARRANTY CLAIMS FROM COMPLAINT DESCRIPTIONS THAT CONTENDED THE INTERLOCK SYSTEM FAILED TO OPERATE PROPERLY.HONDA PRESENTED THE RESULTS OF THEIR INVESTIGATION INTO INTERLOCK SYSTEM FAILURES AT AN OCTOBER 16, 2003 MEETING WITH ODI IN WHICH HONDA IDENTIFIED A SUPPLIER AND AN ENGINEERING SPECIFICATION CHANGE FOR THE IGNITION CYLINDER BODY (CB), A SUBCOMPONENT OF THE IGNITION LOCK ASSEMBLY.RESULTS FROM HONDA?S ANALYSIS DEMONSTRATED A STRONG CORRELATION BETWEEN THE PRODUCTION DATE RANGE OF VEHICLES THAT EXPERIENCED HIGHER INTERLOCK WARRANTY CLAIM RATES AND THE IMPLEMENTATION DATES OF THE CHANGES.AN ENGINEERING SPECIFICATION FOR A SURFACE TREATMENT PROCESS FOR THE CB WAS ELIMINATED AT THE BEGINNING OF MY 1998.THE SUPPLIER OF THE CB WAS CHANGED IN FEBRUARY 1999.VEHICLES BUILT WITHIN THIS TIME PERIOD CONTAIN A CB WITH POOR SURFACE HARDNESS THAT CAN WEAR PREMATURELY.AS THE WEAR PROGRESSES, THE INTERLOCK SYSTEM BECOMES INCAPABLE OF PREVENTING KEY REMOVAL WHEN THE SHIFTER IS IN A NON-PARK POSITION.INTERLOCK FAILURE INCREASES THE RISK OF A VEHICLE ROLLAWAY AND SUBSEQUENT CRASH OR INJURY WHEN VEHICLES ARE PARKED UNSECURED.HONDA ACCORD VEHICLES SUBJECT TO THIS CHANGE INCLUDE MY 1998 AND MY 1999 THROUGH FEBRUARY 1999 PRODUCTION.VEHICLES PRODUCED AFTER THIS DATE ARE NOT AFFECTED BY THIS CONDITION AND THUS ARE NOT CONSIDERED AT RISK FOR FAILURE.ODI NOTES THAT 12 OF THE 13 VOQ REPORTS FALL WITHIN THIS PRODUCTION RANGE (THE 13TH DOES NOT HAVE A VIN AND CANNOT BE VERIFIED).THE ABOVE POPULATION REPRESENTS THE NUMBER OF THE ACCORD VEHICLES TO BE RECALLED.HONDA ALSO REPORTED THAT CERTAIN ODYSSEY AND ACURA CL AND TL MODELS WERE AFFECTED AND WOULD ALSO BE RECALLED.A TOTAL OF 570,120 VEHICLES WILL BE RECALLED.UNDER RECALL 03V-423, HONDA WILL INSPECT VEHICLES AND REPLACE COMPONENTS (INCLUDING THE CB) ON VEHICLES WITH EXCESSIVE WEAR.VEHICLES NOT SHOWING WEAR WILL HAVE A REDESIGNED PART INSTALLED WHICH PREVENTS WEAR.
PE03014 · IGNITION-PARK Interlock System
Opened Apr 15, 2003 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl)
SIX OF THE ODI COMPLAINTS ARE DUPLICATIVE OF THE MANUFACTURER COMPLAINTS, AS WELL AS FOUR OF THE CRASHES.THE NOTED INJURY OCCURRED WHEN A ROLLAWAY VEHICLE THAT HAD BEEN INADVERTENTLY PARKED IN NEUTRAL STRUCK THE EXITING OPERATOR.THE WARRANTY CLAIM COUNT SHOWN FOR OTHER REPRESENTS INCIDENTS WHERE HONDA'S ANALYSIS OF CLAIM DETAIL INDICATES THE INTERLOCK SYSTEM MALFUNCTIONED.THE INTERLOCK SYSTEM UTILIZES A LEVER TO BLOCK IGNITION KEY REMOVAL WHEN THE TRANSMISSION IS NOT IN PARK.HONDA HAS IDENTIFIED A WEAR CONDITION OF THE INTERLOCK LEVER THAT CAN CAUSE THE SYSTEM TO MALFUNCTION; WHEN WEAR OCCURS THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE SHIFTER IS IN A NON-PARK POSITION.HONDA DOCUMENTS INDICATE THAT A MANUFACTURING PROCESS MAY BE THE CAUSE OF INTERLOCK LEVER WEAR, AND THAT THIS PROCESS WAS REVISED IN JANUARY OF 2001.AN ENGINEERING ANALYSIS WILL BE OPENED TO FURTHER INVESTIGATE THIS CONCERN AND ITS SCOPE.
PE02072 · Seat Frame Bracket Failure
Opened Oct 2, 2002 · Closed Mar 28, 2003
Status: closed (inferred from source dates) · Seats
THIS PE WAS OPENED BASED ON 10 CONSUMER COMPLAINTS IN THE ODI DATABASE ALLEGING THAT THE POWER ASSISTED SEATS WERE FAILING IN CERTAIN 1998-2002 HONDA ACCORD VEHICLES.FAILURES ARE CONCENTRATED IN THE 1998-99 MODEL YEAR VEHICLES.THE BRACKET THAT ATTACHES THE SEAT BOTTOM TO THE SEAT BASE IS FRACTURING DUE TO: 1-THE WELD CONDITION OF BRACKET, 2-THE DRIVERS WEIGHT, AND 3-THE IMPACT ON THE SEAT WHEN THE DRIVER ENTERS THE VEHICLE AND SITS DOWN.OVER TIME THE BRACKET THAT ATTACHES THE SEAT MAY FAIL AT THE LEFT FRONT CORNER OF THE SEAT BOTTOM.THE OTHER 3 POINTS OF ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BASE STAY ATTACHED AND THE SEAT MOVEMENT IS LIMITED.THE ATTACHMENT OF THE SEAT BOTTOM TO THE SEAT BACK DOES NOT FAIL.THE CONDITION IS MOST APPARENT DURING RAPID ACCELERATION CAUSING THE SEAT TO TILT REARWARD.ALTHOUGH A FEW COMPLAINTS REPORT CONCERN OVER LOSS OF VEHICLE CONTROL, NO LOSS OF CONTROL INCIDENTS, CRASHES OR INJURIES ARE REPORTED.IN RESPONSE TO CUSTOMER COMPLAINTS, HONDA WILL PROVIDE OWNERS OF 1998 AND SOME 1999 ACCORDS A NO-COST REINFORCEMENT FOR THE SEAT AT THE LEFT FRONT CORNER.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.