DT*: THE CONTACT STATED WHILE PARKED THE DRIVER SIDE REAR TIRE WENT FLAT. AN INDEPENDENT REPAIR SHOP SENT A TECHNICIAN WHO DETERMINED THAT THE TREAD SEPARATED. THE TIRE WAS TAKEN TO A DEALERSHIP AND REPLACED. THEN WHILE PARKED AT A REST AREA, THE PASSENGER SIDE REAR TIRE WENT FLAT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AN…
Read full complaint
DT*: THE CONTACT STATED WHILE PARKED THE DRIVER SIDE REAR TIRE WENT FLAT. AN INDEPENDENT REPAIR SHOP SENT A TECHNICIAN WHO DETERMINED THAT THE TREAD SEPARATED. THE TIRE WAS TAKEN TO A DEALERSHIP AND REPLACED. THEN WHILE PARKED AT A REST AREA, THE PASSENGER SIDE REAR TIRE WENT FLAT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND IT WAS DETERMINED THE THREE REMAINING TIRES HAD TREAD SEPARATION. THOSE TIRES WERE REPLACED. THE DRIVER SIDE FRONT TIRE WENT FLAT AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE IT WAS DETERMINED THE DRIVER SIDE FRONT AND REAR PASSENGER SIDE TIRE BOTH HAD TREAD SEPARATION. THE SAME MAKE AND MODEL TIRE HAS BEEN USED EACH TIME. THE TIRE FAILURE CAUSED MINOR DAMAGE TO THE TRAVEL TRAILER, A 2003 HOLIDAY RAMBLER PRESIDENTIAL. *AK UPDATED 5/22/2006 - *NM
ON CERTAIN FIFTH WHEEL TRAILERS EQUIPPED WITH LIQUID PROPANE GAS (LPG), IT WAS DISCOVERED AN EXCESS OF LPG HOSE WAS COILED IN THE REAR REFRIGERATOR ACCESS COMPARTMENT A CAUSING IT TO BE ROUTED CLOSE IN PROXIMITY TO THE BURNER FLUE BOX COVER OF THE REFRIGERATOR.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY CAUSE THERMAL DAMAGE TO THE LPG LINE AND PRODUCE A LEAK OF LPG IN THE ACCESS COMPARTMENT THAT COULD RESULT IN AN EXPLOSION OR FIRE.
Remedy: OWNERS ARE BEING ASKED TO INSPECT THE LPG LINE FROM THE OUTSIDE OF THE VEHICLE TO ENSURE THAT IT IS NOT CLOSE TO THE BURNER. IF NO DAMAGE TO THE LINE IS PRESENT AND THE LPG LINE IS THE APPROPRIATE LENGTH AND ROUTED CORRECTLY, THE COVER WILL BE REINSTALLED AND NO FURTHER ACTION WILL BE TAKEN. IF AN EXCESS OF HOSE IS CAUSING CONTACT OR CLOSE PROXIMITY TO THE BURNER COVER, OWNERS SHOULD SHUT OFF THE SUPPLY OF GAS AT THE LPG TANKS AND CONTACT MONACO IMMEDIATELY. THE RECALL BEGAN DECEMBER 8, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
ON CERTAIN FIFTH WHEEL TRAILERS, A DEFICIENCY IN THE STRUCTURAL INTEGRITY OF THE MAIN FRAME RAILS COULD CAUSE THE RAILS TO CRACK AND AXLES COULD SHIFT, CAUSING THE FIFTH WHEEL TO PULL ERRATICALLY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE DRIVER OF THE TOW VEHICLE TO LOSE CONTROL CREATING THE POTENTIAL FOR A CRASH RESULTING IN PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT AND ADD AN ADDITION OF GUSSET PLATES AND CROSS TUBES TO STRENGHEN THE AXLE SPRING HANGERS. THE RECALL BEGAN ON OCTOBER 29, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
ON CERTAIN TRAVEL TRAILERS, THE FEDERAL CERTIFICATION LABEL IS INCORRECT. THE AXLE WEIGHT RATING SHOWS 5200 LBS. WHEN THE CORRECT RATING SHOULD BE 5080 LBS.
Consequence & remedy
Consequence: PRIOR TO HAVING THE NEW LABEL INSTALLED, OWNERS MUST FOLLOW THE CORRECT RATING OF THE AXLE AND TIRE MAXIMUM CAPACITY TO PREVENT A BLOWOUT OR DAMAGE TO THE AXLES.
Remedy: DEALERS WILL REPLACE THE FEDERAL CERTIFICATION LABEL ON THE UNITS INVOLVED. OWNER NOTIFICATION BEGAN JULY 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-877-466-6226.
ON CERTAIN FIFTH WHEEL VEHICLES ,THE FEDERAL CERTIFICATION LABEL HAS AN INCORRECT AXLE WEIGHT RATING. THE INITIAL LABEL READ 12,100 WITH 5,200 LB. AXLES. CORRECTED LABEL SHOULD READ 14,400 WITH 6,000 LB. AXLES.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE REGULATIONS.
Remedy: DEALERS WILL INSTALL A CORRECTED LABEL ON THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE LABEL WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-877-466-8226.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE05026 · Wheels Cracking And Breaking
Opened May 11, 2005 · Closed Sep 22, 2005
Status: closed (inferred from source dates) · Wheels; Wheels:hubcap/cover; Wheels:rim
IN RESPONSE TO THE PRODUCT FAILURES THAT PROMPTED ODI TO INITIATE INVESTIGATION PE05-026, MONACO COACH HAS FILED DEFECT NOTICE 05V-418 THAT PROPOSES TO CONDUCT A PRODUCT RECALL TO REPLACE CERTAIN 16 CHROME PLATED STEEL WHEELS THAT WERE INSTALLED AS ORIGINAL EQUIPMENT BETWEEN MARCH 2005 AND JULY 2005 IN APPROXIMATELY 290 2005 AND 2006 MODEL YEAR FIFTH WHEEL TRAILERS. TREDIT TIRE, MONACO COACH'S SUPPLIER OF TIRE AND WHEEL ASSEMBLIES, HAD INVESTIGATED THE REASONS FOR THE CRACKED AND BROKEN WHEELS, DETERMINED THE CAUSES, AND NOTIFIED MONACO AND ODI (05E-051) OF THEIR FINDINGS.IN RESPONSE TO ODI'S INQUIRIES IN INVESTIGATION PE05-026, MONACO COACH HAS INFORMED ODI THAT SOME WHEELS INSTALLED IN MODEL YEAR 2003, 2004, AND 2005 VEHICLES THAT ARE NOT CURRENTLY ADDRESSED BY CAMPAIGN 05V-418 HAVE ALSO BEEN REPORTED CRACKED, BROKEN, AND/OR LEAKING. ACCORDINGLY, ODI WILL EVALUATE WHETHER ADDITIONAL ACTIONS APPEAR TO BE WARRANTED FOR WHEELS INSTALLED IN MONACO VEHICLES MANUFACTURED PRIOR TO MARCH 2005 AND NOT ADDRESSED BY CAMPAIGN O5V-418.
Additional source detail variants (3)
Wheels:hubcap/cover
IN RESPONSE TO THE PRODUCT FAILURES THAT PROMPTED ODI TO INITIATE INVESTIGATION PE05-026, MONACO COACH HAS FILED DEFECT NOTICE 05V-418 THAT PROPOSES TO CONDUCT A PRODUCT RECALL TO REPLACE CERTAIN 16 CHROME PLATED STEEL WHEELS THAT WERE INSTALLED AS ORIGINAL EQUIPMENT BETWEEN MARCH 2005 AND JULY 2005 IN APPROXIMATELY 290 2005 AND 2006 MODEL YEAR FIFTH WHEEL TRAILERS. TREDIT TIRE, MONACO COACH'S SUPPLIER OF TIRE AND WHEEL ASSEMBLIES, HAD INVESTIGATED THE REASONS FOR THE CRACKED AND BROKEN WHEELS, DETERMINED THE CAUSES, AND NOTIFIED MONACO AND ODI (05E-051) OF THEIR FINDINGS.IN RESPONSE TO ODI'S INQUIRIES IN INVESTIGATION PE05-026, MONACO COACH HAS INFORMED ODI THAT SOME WHEELS INSTALLED IN MODEL YEAR 2003, 2004, AND 2005 VEHICLES THAT ARE NOT CURRENTLY ADDRESSED BY CAMPAIGN 05V-418 HAVE ALSO BEEN REPORTED CRACKED, BROKEN, AND/OR LEAKING. ACCORDINGLY, ODI WILL EVALUATE WHETHER ADDITIONAL ACTIONS APPEAR TO BE WARRANTED FOR WHEELS INSTALLED IN MONACO VEHICLES MANUFACTURED PRIOR TO MARCH 2005 AND NOT ADDRESSED BY CAMPAIGN O5V-418.
Wheels
IN RESPONSE TO THE PRODUCT FAILURES THAT PROMPTED ODI TO INITIATE INVESTIGATION PE05-026, MONACO COACH HAS FILED DEFECT NOTICE 05V-418 THAT PROPOSES TO CONDUCT A PRODUCT RECALL TO REPLACE CERTAIN 16 CHROME PLATED STEEL WHEELS THAT WERE INSTALLED AS ORIGINAL EQUIPMENT BETWEEN MARCH 2005 AND JULY 2005 IN APPROXIMATELY 290 2005 AND 2006 MODEL YEAR FIFTH WHEEL TRAILERS. TREDIT TIRE, MONACO COACH'S SUPPLIER OF TIRE AND WHEEL ASSEMBLIES, HAD INVESTIGATED THE REASONS FOR THE CRACKED AND BROKEN WHEELS, DETERMINED THE CAUSES, AND NOTIFIED MONACO AND ODI (05E-051) OF THEIR FINDINGS.IN RESPONSE TO ODI'S INQUIRIES IN INVESTIGATION PE05-026, MONACO COACH HAS INFORMED ODI THAT SOME WHEELS INSTALLED IN MODEL YEAR 2003, 2004, AND 2005 VEHICLES THAT ARE NOT CURRENTLY ADDRESSED BY CAMPAIGN 05V-418 HAVE ALSO BEEN REPORTED CRACKED, BROKEN, AND/OR LEAKING. ACCORDINGLY, ODI WILL EVALUATE WHETHER ADDITIONAL ACTIONS APPEAR TO BE WARRANTED FOR WHEELS INSTALLED IN MONACO VEHICLES MANUFACTURED PRIOR TO MARCH 2005 AND NOT ADDRESSED BY CAMPAIGN O5V-418.
Wheels:rim
IN RESPONSE TO THE PRODUCT FAILURES THAT PROMPTED ODI TO INITIATE INVESTIGATION PE05-026, MONACO COACH HAS FILED DEFECT NOTICE 05V-418 THAT PROPOSES TO CONDUCT A PRODUCT RECALL TO REPLACE CERTAIN 16 CHROME PLATED STEEL WHEELS THAT WERE INSTALLED AS ORIGINAL EQUIPMENT BETWEEN MARCH 2005 AND JULY 2005 IN APPROXIMATELY 290 2005 AND 2006 MODEL YEAR FIFTH WHEEL TRAILERS. TREDIT TIRE, MONACO COACH'S SUPPLIER OF TIRE AND WHEEL ASSEMBLIES, HAD INVESTIGATED THE REASONS FOR THE CRACKED AND BROKEN WHEELS, DETERMINED THE CAUSES, AND NOTIFIED MONACO AND ODI (05E-051) OF THEIR FINDINGS.IN RESPONSE TO ODI'S INQUIRIES IN INVESTIGATION PE05-026, MONACO COACH HAS INFORMED ODI THAT SOME WHEELS INSTALLED IN MODEL YEAR 2003, 2004, AND 2005 VEHICLES THAT ARE NOT CURRENTLY ADDRESSED BY CAMPAIGN 05V-418 HAVE ALSO BEEN REPORTED CRACKED, BROKEN, AND/OR LEAKING. ACCORDINGLY, ODI WILL EVALUATE WHETHER ADDITIONAL ACTIONS APPEAR TO BE WARRANTED FOR WHEELS INSTALLED IN MONACO VEHICLES MANUFACTURED PRIOR TO MARCH 2005 AND NOT ADDRESSED BY CAMPAIGN O5V-418.
2003 Holiday Rambler Presidential Problems, Complaints & Recalls | Skip That Year
Illustration