IllustrationFRAME SUPPORT COMPONENTS ARE FAILING. OBVIOUS CRACKING AND BENDING ISSUES FROM MAIN FRAME RAILS TO OUTER WALLS.
2009 Haulmark Trailer
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
3 reportsOUR TRAILER HAD COMPLETE STRUCTURAL FRAME FAILURE DUE TO SUB STANDARD STEEL USED ON FRAME , WELDING BREAKS AND WELDING FAILURES , OUT RIGGER SUPPORT FAILURE LEADING TO BOWING AND SIDE WALL FAILURE . THE TRAILER BEGAN TO LEAK IN THE RAIN DUE TO THE STRUCTURAL FAILURE .
TL*THE CONTACT OWNS A 2009 HAULMARK TRAILER EQUIPPED WITH HI-RUN TIRES. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A TOTAL OF 3 TIRE BLOWOUTS WHILE DRIVING APPROXIMATELY 65 MPH. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED BUT THE TIRES WERE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN. THE VIN WAS UNA…
Read full complaint
TL*THE CONTACT OWNS A 2009 HAULMARK TRAILER EQUIPPED WITH HI-RUN TIRES. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A TOTAL OF 3 TIRE BLOWOUTS WHILE DRIVING APPROXIMATELY 65 MPH. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED BUT THE TIRES WERE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN. THE VIN WAS UNAVAILABLE.
Official recalls
109V182000 · Structure
May 27, 2009
HAULMARK IS RECALLING 2,227 MODEL YEAR 2008 AND 2009 TRANSPORT/CAR HAULER TRAILERS, MODELS TS7DT2, TSC85WT2&3, TSR85WT2&3, TSRV85WT2&3, MAUFACTURED BETWEEN AUGUST 14, 2007 AND MAY 19, 2009. DUE TO INADEQUATE REINFORCEMENT OF THE STRUCTURE WHERE THE AXLE BRACKET ATTACHES TO THE FRAME RAIL, OVER TIME METAL FATIGUE CAN CAUSE CRACKS IN THE WELDS LEADING TO POTENTIAL FAILURE OF THE AXLE BRACKET ATTACHMENT TO THE FRAME RAIL.
Consequence & remedy
Consequence: FAILURE OF THE AXLE BRACKET ATTACHMENT TO THE TRAILER FRAME RAIL WHILE THE TRAILER IS BEING OPERATED COULD RESULT IN THE AXLE BECOMING SEPARATED FROM THE TRAILER FRAME. THIS CONDITION COULD LEAD TO A VEHICLE CRASH.
Remedy: HAULMARK WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE TRAILERS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 6, 2009. OWNERS MAY CONTACT HAULMARK AT 1-800-348-7530 EXT. 292.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.