Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
3 reports
10,000 miles · Mar 25, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 HARLEY DAVIDSON XB (N/A). THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER BUT THE FAILURE WAS NOT DIAGNOSED. THE CONTACT LATER INSPECTED THE VEHICLE AND DISCOVERED THAT THERE WAS A FAILURE WITHIN THE FUEL PUMP AND THE WIRES HAD…
Read full complaint
TL* THE CONTACT OWNS A 2005 HARLEY DAVIDSON XB (N/A). THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER BUT THE FAILURE WAS NOT DIAGNOSED. THE CONTACT LATER INSPECTED THE VEHICLE AND DISCOVERED THAT THERE WAS A FAILURE WITHIN THE FUEL PUMP AND THE WIRES HAD BLOWN THE FUSES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.
NHTSA ODI #10392866
Mileage unknown · Dec 18, 2006
Latches/locks/linkagesUnknown Or Other
I RECENTLY PURCHASED A MOTORCYCLE TRAILER FROM KENDON INDUSTRIES, 3711 E. LA PALMA AVE, ANAHEIM, CA 92806. THE TRAILER WAS SPECIFICALLY DESIGNED FOR A LONG BIKE (CHOPPER STYLE). THE FIRST TIME I USED THE TRAILER, I WAS TRAVELING ON THE FREEWAY AND NOTICED THAT THE TIE DOWNS FOR THE BIKE AND COME LOOSE AND THE BIKE VERY NEARLY …
Read full complaint
I RECENTLY PURCHASED A MOTORCYCLE TRAILER FROM KENDON INDUSTRIES, 3711 E. LA PALMA AVE, ANAHEIM, CA 92806. THE TRAILER WAS SPECIFICALLY DESIGNED FOR A LONG BIKE (CHOPPER STYLE). THE FIRST TIME I USED THE TRAILER, I WAS TRAVELING ON THE FREEWAY AND NOTICED THAT THE TIE DOWNS FOR THE BIKE AND COME LOOSE AND THE BIKE VERY NEARLY CAME LOOSE FROM THE TRAILER INTO HEAVY FREEWAY TRAFFIC. KENDON TRAILERS HAVE A FRONT WHEEL MOUNTING UNIT THAT OPERATES IN A WAY THAT AS YOU MOVE THE MOTORCYCLE FORWARD INTO THE MOUNTING UNIT THE MOUNTING UNIT ROCKS FORWARD SECUTING THE FRONT WHEEL AGAINST THE FRONT OF THE TRAILER. THE TRAILER ALSO HAS FOUR TIE DOWN POINTS (TWO AT THE FRONT AND TWO AT THE REAR). THE MAJOR PROBLEM WITH THE TRAILER IS THE FACT THAT THE FRONT TIE DOWN POINTS ARE BEHIND THE STEARING HEAD OF THE MOTORCYCLE. AS A RESULT, WHEN THE TRAILER HITS A BUMP, THE ACTION OF THE TRAILER IS TO PULL THE BIKE BACKWARDS (AWAY FROM THE FRONT SECURING UNIT). THIS IS WHAT HAPPENED TO ME. WHILE TRAVELING ON THE FREEWAY I MUST HAVE HIT A BUMB WHICH CAUSED THE MOTORCYCLE TO PULL OUT OF THE FRONT UNIT. THIS ALSO INCREASED THE SLACK IN THE TIE DOWNS WHICH ALLOWED THE BIKE TO FLOP FROM SIDE TO SIDE AND ALMOST CAUSED THE BIKE TO EXIT THE TRAILER (WHICH HAS NO SIDES OR REAR SECURITY). *NM
NHTSA ODI #10176495
Mileage unknown · Oct 6, 2005
Suspension
DT: 2005 HARLEY DAVIDSON WIDE GLIDE. THE FRONT FORKS WERE SO WEAK THAT THEY SAGGED WHEN THE CONSUMER WAS NOT BRAKING. THE CONSUMER STATED THE SPRINGS WERE TOO WEAK IN THE FORKS. THE CONSUMER FOUND OTHER COMPLAINTS ABOUT THE SAME PROBLEM. HE TRIED TO GET THE AFTER MARKET SPRINGS, BUT THEY WERE ON BACK ORDER. THE CONSU…
Read full complaint
DT: 2005 HARLEY DAVIDSON WIDE GLIDE. THE FRONT FORKS WERE SO WEAK THAT THEY SAGGED WHEN THE CONSUMER WAS NOT BRAKING. THE CONSUMER STATED THE SPRINGS WERE TOO WEAK IN THE FORKS. THE CONSUMER FOUND OTHER COMPLAINTS ABOUT THE SAME PROBLEM. HE TRIED TO GET THE AFTER MARKET SPRINGS, BUT THEY WERE ON BACK ORDER. THE CONSUMER NOTICED THIS A WEEK AGOON SEPTEMBER 29, 2005. *AK UPDATED 03/09/06
ON CERTAIN MOTORCYCLES, A CONDITION OCCURS THAT COULD ALLOW PRESSURE TO BUILD UP IN THE FUEL TANK. ON FUEL INJECTED VEHICLES, THIS CONDITION COULD CAUSE FUEL TO SPRAY OUT UNEXPECTEDLY WHEN THE FUEL CAP IS REMOVED. ON CARBURETED VEHICLES, EXCESSIVE FUEL COULD BE TRANSFERRED TO THE CARBURETOR, WHICH WOULD EVENTUALLY ALLOW FUEL TO DRIP FROM THE AIR CLEANER.
Consequence & remedy
Consequence: THESE SITUATIONS COULD CAUSE SERIOUS PERSONAL INJURY OR CREATE A FIRE HAZARD FOR PERSONS OR PROPERTY ON OR NEAR THE MOTORCYCLE.
Remedy: DEALERS WILL TEST EACH CANISTER FOR BLOCKAGE, THEN REPLACE AS NECESSARY. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 HARLEY-DAVIDSON Xl Problems, Complaints & Recalls | Skip That Year
Illustration