Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 10 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
What owners actually said
10 reports
Mileage unknown · Aug 2, 2007
Power TrainInjury
HARLEY DAVIDSON ROADKING 2004 PURCHASED NEW. GEAR SHIFTER WENT "FLACID" AND I WAS UNABLE TO SHIFT INTO ANY GEAR. THIS HAPPENED ONCE IN 2004; TWICE IN 2005; TWICE IN 2006; AND ONCE LAST WEEK IN 2007. EACH TIME THE GEAR SHIFTER WAS TIGHTENED BY THE AMERICAN HARLEY DEALER HERE IN WESTERN NEW YORK; AND ONE TIME IN 2006 HARLEY REPLAC…
Read full complaint
HARLEY DAVIDSON ROADKING 2004 PURCHASED NEW. GEAR SHIFTER WENT "FLACID" AND I WAS UNABLE TO SHIFT INTO ANY GEAR. THIS HAPPENED ONCE IN 2004; TWICE IN 2005; TWICE IN 2006; AND ONCE LAST WEEK IN 2007. EACH TIME THE GEAR SHIFTER WAS TIGHTENED BY THE AMERICAN HARLEY DEALER HERE IN WESTERN NEW YORK; AND ONE TIME IN 2006 HARLEY REPLACED THE GEAR SHIFTER. ON SUCH A NEW BIKE, IT MAKES NO SENSE THAT THIS SAME PROBLEM CONTINUES TO REOCCUR. I COULD BE THROWN OVER THE HANDLEBARS TO MY DEATH IF THIS PROBLEM OCCURS AT A HIGH RATE OF SPEED. THIS BIKE IS ONLY 3 YEARS OLD, AND I'M WONDERING IF THIS IS ANOTHER "CHINA" PRODUCT THAT NEEDS TO BE RECALLED DUE TO CHEAP STEEL!!! AMERICAN HARLEY CHARGED FOR LABOR THE TIME THAT THEY REPLACED THE GEAR SHIFTER, BUT THEY DID REIMBURSE ME FOR THE PART. *TR
NHTSA ODI #10198293
Mileage unknown · Sep 22, 2005
Electrical System
HORN GETS WORSE AND BECOMES INAUDIBLE. THE HARLEY MOTOR COMPANY SHOULD RECALL AND REPLACE ALL HORNS WITH BETTER QUALITY PARTS. MINE HAS BEEN REPLACED AT MY COST. *NM
NHTSA ODI #10137366
13,100 miles · Aug 24, 2005
Fuel System, Gasoline
DT: THE CALLER HAD WARRANTY WORK DONE ON GAS TANK LINE AND THE REPLACEMENT PART WAS OF THE SAME DESIGN ONLY SHORTER. THE CALLER SAID THE LINE FROM THE GAS PUMP WAS RUBBING ON TANK AND CAUSING A HOLE IN THE LINE INSIDE THE TANK. DEALER SAID THE REPLACEMENT PART WILL FAIL. THE CALLER DID NOT HAVE A PROBLEM YET WITH REPLACEMENT…
Read full complaint
DT: THE CALLER HAD WARRANTY WORK DONE ON GAS TANK LINE AND THE REPLACEMENT PART WAS OF THE SAME DESIGN ONLY SHORTER. THE CALLER SAID THE LINE FROM THE GAS PUMP WAS RUBBING ON TANK AND CAUSING A HOLE IN THE LINE INSIDE THE TANK. DEALER SAID THE REPLACEMENT PART WILL FAIL. THE CALLER DID NOT HAVE A PROBLEM YET WITH REPLACEMENT PART. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK
NHTSA ODI #10134022
Mileage unknown · May 24, 2005
Vehicle Speed Control
DT: CONSUMER STATES: MOTOR CUTS OUT UPON ACCELERATION FROM STOP OR IF STARTING THE MOTORCYCLE AND MAKING A TURN. ALSO, IT CUTS OUT. IT MAKES A NOISE PRESSURE RELEASE OF THE AIR. *AK
NHTSA ODI #10121991
50 miles · Sep 18, 2004
Suspension
I HAVE REPORTED THIS BEFORE BUT HAVE NOT HEARD BACK FROM YOU... CAN YOU PLEASE HELP? POOR HANDLING MOTORCYCLE, 2004 HARLEY DAVIDSON, FLHTCI - MOTORCYCLE TENDED TO WANT TO "PULL" TO THE LEFT, ESPECIALLY WHEN DECELERATING - SEVERAL VISITS TO THE DEALER FOR "ALIGNMENTS" OF THE ENGINE/FRAME/DRIVETRAIN - PROBLEM MINIMIZED BUT N…
Read full complaint
I HAVE REPORTED THIS BEFORE BUT HAVE NOT HEARD BACK FROM YOU... CAN YOU PLEASE HELP? POOR HANDLING MOTORCYCLE, 2004 HARLEY DAVIDSON, FLHTCI - MOTORCYCLE TENDED TO WANT TO "PULL" TO THE LEFT, ESPECIALLY WHEN DECELERATING - SEVERAL VISITS TO THE DEALER FOR "ALIGNMENTS" OF THE ENGINE/FRAME/DRIVETRAIN - PROBLEM MINIMIZED BUT NOT ELIMINATED. - "HIGH SPEED WOBBLES" OCCURRED REGULARLY AND WITHOUT NOTICE WHICH I HANDLED BECUASE I AM AN EXPERIENCED RIDER AND VERY FORTUNATE TO HAVE BEEN ABLE TO SURVIVE. - REMOVAL OF TIRE TO REPAIR PUNCTURE AND CHECK OF SWINGARM FOUND THE SWINGARM MOVES LEFT TO RIGHT ABOUT 1/4 INCH.*AK
NHTSA ODI #10091250
3,000 miles · Aug 9, 2004
SuspensionTires
PASSING A SEMI TRACTOR TRAILER A ABOUT 70MPH FRONT END STEERING ON NEW 04 ELECTRAGLIDE CLASSIC BEGAN A WOBBLING OF THE FRONT TIRE. IT WAS EXTREMELY NOTICABLE AND NEARLY CAUSED THE BIKE TO GO INTO THE TRACTOR TRAILER. IN ORDER TO SOLVE THE PROBLEM I REDUCED MY SPEED W/O APPLYING BRAKES TO ABOUT 40MPH AND THE WOBBLING FINALLY STOP…
Read full complaint
PASSING A SEMI TRACTOR TRAILER A ABOUT 70MPH FRONT END STEERING ON NEW 04 ELECTRAGLIDE CLASSIC BEGAN A WOBBLING OF THE FRONT TIRE. IT WAS EXTREMELY NOTICABLE AND NEARLY CAUSED THE BIKE TO GO INTO THE TRACTOR TRAILER. IN ORDER TO SOLVE THE PROBLEM I REDUCED MY SPEED W/O APPLYING BRAKES TO ABOUT 40MPH AND THE WOBBLING FINALLY STOPPED. *AK *TC
NHTSA ODI #10086292
5,000 miles · Aug 3, 2004
Service Brakes, Hydraulic
WHEN BRAKING THERE WOULD BE A LOUD GRINDING NOISE, WHICH COULD CAUSE EXTENDED STOPPING DISTANCE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10087113
20 miles · Jul 24, 2004
Suspension
MOTORCYCLE STABILITY ISSUE. I PURCHASED NEW WITH ABOUT 20 TEST MILES, AN FLHTCI, 2004, HARLEY DAVIDSON MOTORCYLE. IMMEDIATELY UPON RIDING I FOUND IT "PULLED" TO THE LEFT, ESPECIALLY WHEN YOU ROLL OFF THE THROTTLE(DECELERATE). THE AMOUNT OF DEFLECTION WOULD HAVE CAUSED A SWERVE INTO ONCOMING TRAFFIC HAD I NOT BEEN AN EXPERIENC…
Read full complaint
MOTORCYCLE STABILITY ISSUE. I PURCHASED NEW WITH ABOUT 20 TEST MILES, AN FLHTCI, 2004, HARLEY DAVIDSON MOTORCYLE. IMMEDIATELY UPON RIDING I FOUND IT "PULLED" TO THE LEFT, ESPECIALLY WHEN YOU ROLL OFF THE THROTTLE(DECELERATE). THE AMOUNT OF DEFLECTION WOULD HAVE CAUSED A SWERVE INTO ONCOMING TRAFFIC HAD I NOT BEEN AN EXPERIENCED RIDER. DEALER HAS MADE SEVERAL ATTEMPTS BUT IS UNABLE TO RESOLVE THE ISSUE.*AK
NHTSA ODI #10082583
Mileage unknown · Jun 4, 2004
Engine And Engine Cooling
WITHOUT WARNING, THE MOTORCYCLE LOST POWER WHEN RIDING AT ANY SPEED. THIS CAUSED THE CONSUMER TO DRIFT TO THE SIDE OF THE ROAD. THE CONSUMER CONTACTED THE DEALERSHIP ABOUT THIS ISSUE. *AK *SC *JB
NHTSA ODI #10071707
Mileage unknown · May 25, 2004
Service Brakes, Hydraulic
THE DEALERSHIP REPLACED THE FRONT ROTORS AND PADS . HOWEVER THE PROBLEM STILL EXISTED. PLEASE PROVIDE FURTHER INFORMATION. *JB
ON CERTAIN MOTORCYCLES, A CONDITION OCCURS THAT COULD ALLOW PRESSURE TO BUILD UP IN THE FUEL TANK. ON FUEL INJECTED VEHICLES, THIS CONDITION COULD CAUSE FUEL TO SPRAY OUT UNEXPECTEDLY WHEN THE FUEL CAP IS REMOVED. ON CARBURETED VEHICLES, EXCESSIVE FUEL COULD BE TRANSFERRED TO THE CARBURETOR, WHICH WOULD EVENTUALLY ALLOW FUEL TO DRIP FROM THE AIR CLEANER.
Consequence & remedy
Consequence: THESE SITUATIONS COULD CAUSE SERIOUS PERSONAL INJURY OR CREATE A FIRE HAZARD FOR PERSONS OR PROPERTY ON OR NEAR THE MOTORCYCLE.
Remedy: DEALERS WILL TEST EACH CANISTER FOR BLOCKAGE, THEN REPLACE AS NECESSARY. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 HARLEY-DAVIDSON Road King Problems, Complaints & Recalls | Skip That Year
Illustration