While driving on Interstate at 70 MPH the motorcycle died after it had already been in the shop to fix issue. I was told issue was a failed update. Once I received the bike back I rode for 3 days before lights started flashing and then in the middle of a ride it lost all power and then gained it back 3 times before dyeing comp…
Read full complaint
While driving on Interstate at 70 MPH the motorcycle died after it had already been in the shop to fix issue. I was told issue was a failed update. Once I received the bike back I rode for 3 days before lights started flashing and then in the middle of a ride it lost all power and then gained it back 3 times before dyeing completely on the interstate. The check engine light, battery light and warning light all came on. As this is a driver in Houston TX, power dying on these roads unexpectedly can cause accidents that on a motorcycle can kill me or the driver of another vehicle. After pulling fuse I was able to get started and get it back to dealership. Found multiple people with same issue and dealerships still guessing at the issues.
NHTSA ODI #11657386
Mileage unknown · Apr 27, 2025
Electrical SystemEngineFuel/propulsion System
Vehicle goes into limp mode unexpectedly and with no warning. Lose all throttle control forcing me to pull off out of traffic and trying to do so safely.
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain 2024-2026 FLTRX, FLHX, 2025-2026 FXBR, FLFB, 2025 FLHXU, 2026 FLTRXL, FLTRT, FLHXL, and FLHLT motorcycles built with an Airbox Baseplate (part number 29000373). The airbox backplate breather port may be blocked, allowing pressure to build up inside the crankcase.
Consequence & remedy
Consequence: When the dipstick is removed while the crankcase is pressurized, oil may eject from the fill spout, increasing the risk of injury.
Remedy: Dealers will inspect the breather port, and if the port is blocked, repair the blockage, free of charge. Owner notification letters were mailed May 14, 2026. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov April 16, 2025. Harley-Davidson's number for this recall is 0193.
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain 2024 FLHX, FLHXSE, FLTRX, FLTRXSE, and FLTRXSTSE motorcycles. The voltage regulator output wire may rub on the front corner of the crankcase, exposing the wire and causing an electrical short circuit. A short can result in a loss of electrical power and drive power.
Consequence & remedy
Consequence: The unexpected loss of drive power and the loss of electrical power while in motion increases the risk of a crash.
Remedy: Dealers will inspect and as necessary, repair the voltage regulator output wire harness, and install a secondary retention strap, free of charge. Owner notification letters were mailed September 23, 2024. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0186.
Additional source detail variants (2)
Electrical System:wiring
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain 2024 FLHX, FLHXSE, FLTRX, FLTRXSE, and FLTRXSTSE motorcycles. The voltage regulator output wire may rub on the front corner of the crankcase, exposing the wire and causing an electrical short circuit. A short can result in a loss of electrical power and drive power.
Consequence: The unexpected loss of drive power and the loss of electrical power while in motion increases the risk of a crash.
Remedy: Dealers will inspect and as necessary, repair the voltage regulator output wire harness, and install a secondary retention strap, free of charge. Owner notification letters were mailed September 23, 2024. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0186.
Electrical System:alternator/generator/regulator
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain 2024 FLHX, FLHXSE, FLTRX, FLTRXSE, and FLTRXSTSE motorcycles. The voltage regulator output wire may rub on the front corner of the crankcase, exposing the wire and causing an electrical short circuit. A short can result in a loss of electrical power and drive power.
Consequence: The unexpected loss of drive power and the loss of electrical power while in motion increases the risk of a crash.
Remedy: Dealers will inspect and as necessary, repair the voltage regulator output wire harness, and install a secondary retention strap, free of charge. Owner notification letters were mailed September 23, 2024. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson's number for this recall is 0186.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2024 HARLEY-DAVIDSON Fltrx Problems, Complaints & Recalls | Skip That Year
Illustration