Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
6 reports
72,000 miles · Aug 20, 2015
Suspension
MY 2001 HARLEY-DAVIDSON HAD A FRAME FAILURE ON THE SWING ARM (REAR FORK) WHERE THE AXLE BOLT GOES THROUGH THE SWING ARM. AFTER DOING SOME RESEARCH I FOUND THIS TO BE A VERY COMMON PROBLEM ON THE TOURING MODELS 1997-2001. HARLEY-DAVIDSON DID A RECALL IN 2000 FOR THE SWING ARM, THEY NEVER CHANGED THE DESIGN UNTIL 2002. HARLEY-DAVI…
Read full complaint
MY 2001 HARLEY-DAVIDSON HAD A FRAME FAILURE ON THE SWING ARM (REAR FORK) WHERE THE AXLE BOLT GOES THROUGH THE SWING ARM. AFTER DOING SOME RESEARCH I FOUND THIS TO BE A VERY COMMON PROBLEM ON THE TOURING MODELS 1997-2001. HARLEY-DAVIDSON DID A RECALL IN 2000 FOR THE SWING ARM, THEY NEVER CHANGED THE DESIGN UNTIL 2002. HARLEY-DAVIDSON HAS DISCONTINUED THE SWING ARM FOR THE 2001 TOURING BIKES. THE DEALERS I SPOKE TO HAVE TOLD ME THAT HARLEY-DAVIDSON WANTS YOU UPGRADE TO A 2002-2008 SWING ARM BECAUSE THE CHANGED THE DESIGN TO PREVENT THE SWING ARM FAILURE FROM HAPPENING AGAIN, TO UPGRADE THE CONSUMER MUST UPGRADE TO A NEWER REAR WHEEL,BRAKE CALIPER,AXLE WHEEL BEARINGS , AND SPECIAL BUSHINGS TO ACCEPT THE LARGER PIVOT SHAFT. AT A COST OF APROX. $2900.00 JUST FOR THE PARTS.WHEN THE SWING ARM FAILS THE ONLY THING HOLDING THE REAR WHEEL ON THE BIKE IS THE DRIVE BELT AND SHOCK, IF YOU LOSE A REAR WHEEL ON A MOTORCYCLE IT IS ALMOST CERTAIN DEATH! I SPOKE WITH HARLEY CUSTOMER SERVICE AND THEY SEEM IT IS ACCEPTABLE TO HAVE FRAME FAILURE AT 70,000 MILES, WHEN I ASKED HOW I WAS SUPPOSED TO REPAIR MY BIKE WITH OUT THE PARTS I WAS TOLD TO JUST WELD IT BACK TOGETHER. HOWEVER IN MY RESEARCH I FOUND PEOPLE WITH FAILURES AT 30,000 MILES. THIS IS A TRUE SAFETY ISSUE ON 1997-2001 TOURING BIKES. .
NHTSA ODI #10749936
90,000 miles · Sep 5, 2014
Suspension
THE REAR SWING ARM HAS FAILED ABOVE THE WHEEL AXLE. TRYING TO ORDER A NEW ONE FROM HARLEY AND THEY DO NOT HAVE A REPLACEMENT ONE. I WAS TOLD IT'S OBSOLETE. I LOOKED THIS UP ON GOOGLE AND FOUND OTHERS WITH THE SAME PROBLEM. MY BIKE SHOP WANTS TO GET A USED ONE AND REINFORCE IT BY WELDING A PLATE ABOVE THE AXLE SHAFT. I WOULD FEEL…
Read full complaint
THE REAR SWING ARM HAS FAILED ABOVE THE WHEEL AXLE. TRYING TO ORDER A NEW ONE FROM HARLEY AND THEY DO NOT HAVE A REPLACEMENT ONE. I WAS TOLD IT'S OBSOLETE. I LOOKED THIS UP ON GOOGLE AND FOUND OTHERS WITH THE SAME PROBLEM. MY BIKE SHOP WANTS TO GET A USED ONE AND REINFORCE IT BY WELDING A PLATE ABOVE THE AXLE SHAFT. I WOULD FEEL BETTER WITH A FIX FROM HARLEY. THIS MAY BE MY LAST HARLEY. *TR
NHTSA ODI #10630935
Mileage unknown · Sep 23, 2005
Electrical System
THE HORN ON MY HARLEY DAVIDSON, SOUNDS LIKE A HALF DEAD DUCK. MY WIFE WAS IN THE CAR AND I WAS BEHIND HER ON MY 2001 FLHTCI AND I WAS BLOWING MY HORN AND SHE COULD NOT HEAR IT IN THE CAR WITH THE WINDOWS UP. THESE HORNS ARE NOT LOUD ENOUGH TO BE HEARD. SOMETHING NEEDS TO BE DONE.*JB
NHTSA ODI #10137473
15 miles · Apr 29, 2004
Engine And Engine Cooling
WHILE DRIVING AT HIGH SPEEDS AND AT HIGH TEMPERATURES OIL SPRAYED FROM THE AIR CLEANER. THE HOT OIL SPRAYED BACKWARDS ONTO THE LOWER PANTS LEG OF THE CONSUMER. ALSO, THE OIL SPRAYED ON THE REAR TIRE AND THE REAR BRAKE PAD. DEALER EXAMINED THE VEHICLE TEN TIMES. *AK
NHTSA ODI #10071838
Mileage unknown · Jun 11, 2002
Tires
SCPD PURCHASED 4, 2001 FLHPI, 3 OF WHICH HAVE EXPERIENCED BELT SEPARATIONS. WE HAVE HAD SEVERAL OTHER FLHPI SINCE 1998 - 2002, WITHOUT A SINGLE FAILURE. ALL THREE ARE LOW SPEED SEPARATIONS. DEALER ADMITTED A "PROBLEM" WITH BELTS IN STORAGE BEING DEFECTIVE, BUT "DID NOT MAKE IT ONTO MOTORCYCLES". HARLEY SAID THEY WILL EXAMIN EACH…
Read full complaint
SCPD PURCHASED 4, 2001 FLHPI, 3 OF WHICH HAVE EXPERIENCED BELT SEPARATIONS. WE HAVE HAD SEVERAL OTHER FLHPI SINCE 1998 - 2002, WITHOUT A SINGLE FAILURE. ALL THREE ARE LOW SPEED SEPARATIONS. DEALER ADMITTED A "PROBLEM" WITH BELTS IN STORAGE BEING DEFECTIVE, BUT "DID NOT MAKE IT ONTO MOTORCYCLES". HARLEY SAID THEY WILL EXAMIN EACH CASE INDIVIDUALLY!*AK
NHTSA ODI #762948
Mileage unknown · Mar 21, 2002
Steering
WHEN RELEASING HANDLE BAR IT CAUSES MOTORCYCLE TO MOVE TO THE LEFT. DEALER NOTIFIED. *AK *TT
ON CERTAIN TOURING AND POLICE MODEL MOTORCYCLES, THE 40 AMP MAIN CIRCUIT BREAKER CAN "OPEN" FOR REASONS OTHER THAN WHICH IT WAS DESIGNED, CAUSING AN UNEXPECTED INTERRUPTION OF ALL ELECTRICAL POWER TO THE MOTORCYCLE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE MOTORCYCLE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CIRCUIT BREAKER. OWNER NOTIFICATION BEGAN APRIL 23, 2004. OWNERS SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-343-4056.
ON CERTAIN MOTORCYCLES, THE CLIPS THAT RETAIN THE WIRING FOR THE FRONT FENDER TIP LIGHT CAN BECOME DETACHED FROM THE FENDER, CAUSING THE WIRES TO FRAY AND SHORT.
Consequence & remedy
Consequence: THIS COULD CAUSE THE LIGHTING SYSTEM FUSE TO BLOW, LEAVING THE VEHICLE WITHOUT AN OPERATIONAL FRONT FENDER TIP LIGHT, HEADLIGHT, TAILLIGHT, RUNNING LIGHTS, AND PASSING LAMPS (IF EQUIPPED).
Remedy: DEALERS WILL REPLACE THE FENDER TIP LIGHT WIRING HARNESS RETENTION CLIPS, AND INSPECT AND REPLACE, IF NECESSARY, ANY DAMAGED WIRING HARNESSES. OWNER NOTIFICATION BEGAN JANUARY 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HARLEY-DAVIDSON AT 1-414-342-4680.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 HARLEY-DAVIDSON Flhtci Problems, Complaints & Recalls | Skip That Year
Illustration