Illustration2006 VOLVO. WHILE DRIVING ON THE HIGHWAY HE NOTICED SMOKE COMING FROM THE TRAILER CONSUMER PULLED OVER AND THE TRAILER BECAME ENGULFED. *MC THE FIRE DEPARTMENT WAS WHAT CAUSED THE FIRE. OHIO TRAFFIC CRASH REPORT. *TR
1994 Great Dane Trailer
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Parking Brake. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Air. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports0 injury reports
What owners actually said
2 reportsBRAKES LOCKED UP CAUSING TRAILER TO SWING AROUND AND KNOCK LIGHT POLE DOWN (OHIO TRAFFIC CRASH REPORT). *MJS
Official recalls
302V210004 · Service Brakes, Air:supply:check Valve
Aug 15, 2002
ON CERTAIN TRAILERS EQUIPPED WITH SPRING BRAKE CONTROL VALVE ASSEMBLIES, THERE IS A RECESSED AREA ON TOP OF THE VALVE IN WHICH A BRASS GUIDE PIN FITS DOWN INSIDE THE BODY OF THE VALVE AND IS HELD IN PLACE BY A STEEL SNAP RING. THE RECESSED AREA ALLOWS ACCUMULATION OF WATER, DIRT, AND/OR CHEMICALS TO BUILD UP BEHIND THE SNAP RING TO THE POINT WHERE IT WILL NO LONGER CONTAIN THE GUIDE PIN RESULTING IN A FAILURE OF THE AIR VALVE.
Consequence & remedy
Consequence: FAILURE OF THE VALVE IN AN EMPTY OR LIGHTLY LOADED TRAILER WHILE THE VEHICLE IS IN MOTION COULD RESULT IN A HARD APPLICATION OF THE SPRING BRAKES, POSSIBLY LOCKING UP THE TRAILER WHEELS AND RESULTING IN A VEHICLE CRASH.
Remedy: SEALCO WILL PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS TO ITS CUSTOMERS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SEALCO AT 602-253-1007 OR GREAT DANE AT 912-644-2100.
97V238001 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Dec 30, 1997
VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH ANTILOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL UNITS (ECU) FOR OVER-THE-ROAD TRAILER APPLICATIONS. THE COVER SEAL (O-RING) MAY HAVE BEEN IMPROPERLY INSTALLED IN CERTAIN EASY-STOP TRAILER ABS ELECTRONIC CONTROL UNITS. AN INCORRECTLY INSTALLED SEAL COULD PERMIT WATER TO ENTER THE ECU CAUSING A FAULT TO DEVELOP. THIS WILL CAUSE THE VEHICLE'S TRAILER ABS WARNING LAMP TO ILLUMINATE IMMEDIATELY WHEN THE WATER CONTACTS THE BOARD, DEACTIVATING ALL OR PART OF THE ABS.
Consequence & remedy
Consequence: IF THE WARNING LAMP SIGNAL IS IGNORED FOR A PERIOD OF TIME, CORROSION CAN DEVELOP EVENTUALLY LEAKING TO A COMPLETE LOSS OF ECU FUNCTION. THE SERVICE BRAKES WOULD CONTINUE TO BE FULLY FUNCTIONAL.
Remedy: ROCKWELL IS CONDUCTING THE NOTIFICATION AND REMEDY FOR THIS RECALL DEALERS WILL REPLACE THE ECU ON THESE TRAILERS.
95V185000 · Trailer Hitches
Oct 3, 1995
THE CHAIN TIE ANCHOR MOUNTING WELDS CAN CRACK AND/OR THE CHAIN TIE CAN PULL OUT FROM THE CROSSMEMBER.
Consequence & remedy
Consequence: FAILURE OF THE CHAIN TIE ANCHOR CONNECTION CAN ALLOW A LOAD SECURED TO THE CHAIN TIE TO SHIFT, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE ALL THE CHAIN TIE ANCHORS MOUNTED TO THE ALUMINUM CROSSMEMBERS TO ALLOW ADDITIONAL FASTENING TO THE CROSSMEMBER AND ADDITIONAL WELDING AND REINFORCEMENT OF THE CHAIN TIE ANCHORS ON STEEL CROSSMEMBERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.