2023 Grand Design Solitude

Frame and structural integrity/towable RV. 7/15/2024 — First Warranty Repair (Frame): Blue Compass found broken seal-plate welds on the frame; welds repaired, bolts replaced. 30 ft of roof membrane, which had pulled loose and "ballooned" in transit, was fully replaced. 6/2026 — Recurrence: Roof membrane pulled loose again during travel. Mobile tech (Mike's RV Repair, GA) performed a temporary repair ($668.60, GD-reimbursed), initially noting "frame flex" based on owner's account of 2024 history, later revised to "possible frame flex" absent independent diagnosis. 6/19–21/2026 — Follow-up Repair: GD/dealer deemed mobile-tech photos insufficient. Blue Compass Charleston reopened the repair, found membrane improperly tucked under the front cap, corrected and resealed it. Cost: $1,375.08. 7/23–8/8/2026 — Inspection, No Cause Found: Blue Compass Prescott Valley performed a free inspection; air test found no leak source. At pickup, service writer and tech visually compared the unit to a new one on the lot and confirmed filon flex/loose pin-box fit, expressing concern, but had no authority to independently request Grand Design SRT involvement. 8/10/2026–Present: Owner escalated to Grand Design; new case #01085558 opened for frame flex. GD committed to 24–48-hr follow-up; deadline passed with no contact. Additional structural symptoms since observed: lag bolts replaced in 2024 frame repair are missing, backed out or loose, detached service bay shell, separated closet panel with exposed insulation, misaligned closet doors/wall gaps, screws backing out throughout the basement — suggesting a broader chassis/structural issue beyond the roof. Documentation available: repair invoices, photos/video, mobile tech invoice, receipts, full GD case history. Have an appointment on 9/4/26 for dealer to do a frame inspection that Grand Design and Lippert are requiring to be done before considering any support with repairs.

Frame Flex & Water Intrusion - We first noticed movement back in August 2024. It seemed like the tongue was going to come through our back truck window where I sit to work with our 3 cats. The inside of the Solitude is a mess too with lights coming down from ceiling, doors are all scratch from rubbing while be transported, trim coming off, wall paper being torn apart, had lag bolts coming up through the floor, leakage in master bedroom, floor warping and more. We took it in to have it fixed in November 2024 to only get her back in late march of 2025. They had to weld and reinforce frame but would not admit to frame flex or provide me with an updated weight placard so it's like they don't want evidence on it. They had to replace the whole floor which meant they had to take off slides to get everything out and now she is back up there with severe water intrusions from slides and other things again. Moisture reader is reading in places between 30 to 48% but Grand Design is denying any water intrusion even thought they took slides out. They only respond after an email is sent. This is unacceptable and hope that one day we can get these RV manufacturers to follow same rules as a vehicle. Why are they all in IN - they have the most laxed laws governing recreational vehicles. Our lives are in danger while driving these RV's on US highways which means we are putting others in danger too. Why aren't they held to a higher standard...where is the safety in all of this. I have pictures all everything if needed for documentation. Thank you for your time.

My fifthwheel was installed with improper lag bolts, causing frame flex issues. I lost my roof going down the highway last year, pass-through storage compartment doors coming open during transit. Along with that, interior damage became apparent early on after the purchase of the RV, indicating a much greater problem than anticipated. Grand Design sent out an SRT to repair my unit; however, they failed to pull the pylon down off the front of the unit to inspect the frame welds. I may have an impending disaster going down the roadway in the future. All but one lag bolt was being held in under tension. The unit could have become detached from the tow vehicle, and the safety braking mechanism likely wouldn't have engaged. If my roof came completely off, or items would have fallen out of the pass-through compartments, this could have easily caused a major accident leading to fatalities on the highway.

This is a 5th wheel trailer by Grand Design ("GD"). We had significant frame movement due to improper construction and broken welds, resulting in: 1) Screws shearing off at the top of the nose cap, causing the roof to bubble and tear during transit. Roof and screws were replaced under warranty. 2) Entry door was misaligned and required adjustment to close properly (likely due to shifting of frame/body). Strike plate and lock adjusted. 3) Side door to propane tank compartment popped open during transit on the interstate. 4) Rubber strip covering siding/body screws under nose cap flew off during transit on the interstate. Rubber strip replaced. 5) Screws shearing off near hitch, causing siding under nose cap to sag. We were unable to reattach it ourselves with screws as recommended by GD because the frame no longer aligned properly. Front end taken apart and rebuilt, additional metal added by GD under warranty (refused to provide written details or to update weight). 6) Broken weld under front closets in front of nose cap (front bedroom model). GD initially denied welds were broken. Front end taken apart and rebuilt, additional metal added (refused to provide written details or to update weight) by GD under warranty. 7) Frame movement caused rear frame wall to detach and screws to pop out in interior (causing recliners to detach and move during transit). "Dimples" appeared on exterior lower siding ~4" up from rear on both sides. Unclear on specific damage, because GD will not fully explain in writing. GD added one ~4" piece of metal between the siding and rear wall framing on each side (picture attached) and replaced screws, under warranty. 8) Extreme wear on leaf springs, axels, and tires, caused by excessive movement due to broken/poorly engineered frame, requiring replacement. GD replaced parts, partially under warranty. GD stated the unit was not road worthy, but told us to haul it to them. They refused to send pictures of damage or repair other than the one.

-Movement at the kingpin when lowered on tow vehicle along with door side wall and upper cap separations, major concern especially while traveling for us and other traffic -bedroom slide not coming all the way in remaining several inches out from where it’s suppose to this is the most recent issues added to our growing list) this is a major concern for us and other traffic while traveling -both exterior main doors and 2 cargo doors do not shut properly and pop open major concern while traveling (shifting door frames) -grease cap on same wheel has come off 3 times the first before we pulled out of the dealership and the 2nd within a couple hours after leaving the dealership also a big concern being part of the traveling part of this vehicle -water leaks in the upper deck, we don’t know where it’s coming from and found water dripping out from back side of kingpin and other places in the camper

We have excessive Frame Flex. Cargo doors and entry doors open on the road spilling storage contents on road. Axle Equalizer welds breaking. Doors Binding. Vehicle is overweight from factory, over specified weight placard on sticker. This is an on-going problem with Grand Design's larger 5th wheel trailers. They are unsafe on the roads.

We are a fulltime RVer living in this unit for 11 months. We had missing lag bolts that attaches the upper deck to the frame and what bolts were installed were too small. They were 3/8" x 3" in a 1/2" hole that was supposed to be 1/2" x 3.5". We called Grand Design in Indiana and opened a case. They told us to take our unit to the dealership where we bought it and have the frame inspected for flex and the proper lag bolts installed. Grand Design told us if there was any cracks in the steel then it will need further repair in Indiana. When we arrived and during this process; they found other issues. crack in bedroom wall, wrinkled wallpaper, crack in the sill plate and half the screws missing. Did some work on the end cap on the roof. They told us the flex was 1/4" on both sides and that was ok. They called in a welder for the sill plate. Replaced all the lag bolts. After receiving it back none of the doors closed correctly as if the whole unit was now twisted. We decided to trade it in as we don't trust it now. When we took it back for the switch we noticed the end cap had separated and see daylight at the floor. We told the manager because they already put it on the market to sell. This unit is compromised and should not be sold. We saw that our grand design solitude was transferred to another facility that we happen to stop for warranty on our new 5th wheel and saw it. We talked to the manager again and said you can't sell this; it's compromised and they said they already did and were prepping it for the new owners. When we found out that our Grand Design had issues it cost us a lot to get out of it and into another unit so we weren't without a home. This unit is not safe to be on the road. When we hitched up the new 5th wheel of same size we were shocked in the difference. The grand design did not tow smoothly; there is still something wrong with it and afraid someone else owns it now so a dealer can make a buck.

we have frame flex issues, the doors to the generator compartment has come open while driving, the safety lights are being pushed out from the body, trim is coming off, our bedroom slide does not close all the way, our living room slide broke and dropped down. Our hitch flex while on the our trucks, and the trim is moving so the movement on the frame is actively happening. We had the unit now for 1 year now but these issues started since we purchased the unit. this is the complete list of issues we can see: 1. Bedroom Slide is not closing tight, major gaps at the bottom compared to the top. 2. Hitch flexes while attached to truck 3.Decals have been pushed and peeling around the trim, due to trim moving. 4. Trim is coming off the out side of trailer on bedroom slide side 5.Under bedroom slide is separating and screws have been coming out (we caught them and put them back in) 6. Light on outside wall (same side as bedroom slide) is popping out from the bottom and peeling the decals our. Looks like something is pushing it out. 7. Generator and propane compartment doors do not shut properly. They have shifted over time since we have had the unit. We had to put an extension on generator compartment door just so we could keep it shut, it had come open while we were traveling. 8. Closet shelfs do stay, they fall out every time we travel. At first it was only the top shelf now the second shelf fell out on our last trip. 9. Slide floor broke and fell. This slide is also missing or broken off screw on the outside. 10. In front wardrobe closet the trim is pulling away from walls, and shelves have gaps against the walls. 11.Missing lag bolt 12. There is popping, grinding and creaking when moving and raising trailer on/ off truck. Grand design is ignoring our concerns about the safelty of this unit and how the frame could have a complete failure at any time.