Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports1 fire reports0 injury reports

Unknown Or Other complaints

12 reports

Clear category filter

Mileage unknown · Jun 20, 2024

StructureUnknown Or Other

Read full complaint

This 2022 grand design solitude was used on one 200 mile trip other than going to the dealer for repairs and it has upper deck frame flex because it keeps shearing off the screws on the front filon. The frame flexes so much even empty that when it’s sitting on the front jacks the passenger side storage door is locked good , but when you put the weight on the truck 5th wheel to travel down the road, the door doesn’t stay locked and opens. The passenger side wall is sagged down, pulling away from the camper and the floor is sag down also on that side and screws are pushing through the floors. There’s a huge list of things wrong with this camper. Those are just a few. It is not safe for the roads.

NHTSA ODI #11595564

Mileage unknown · May 13, 2024

StructureUnknown Or Other

Read full complaint

The outside and inside body parts started to separate. Frame failed. Yes it is available to be inspected upon request 5th wheel could have broken free from tow vehicle while traveling down the highway. . Problem was confirmed by the manufacturer, we were told to bring it in to the manufacturer service center. They confirmed the frame had failed. They deconstructed upper deck and then added supports and repaired the damaged areas of the frame. However we are unable to see what they have done. We have to hope the “fix” is enough to hold the frame together as we drive down the road . There are no warning lamps or messages you just have to be really aware of any changes in hitch moving and screws falling out, decals getting ruined around filon and on the inside is the furniture or stairs rubbing on the walls is the moulding twisted. Our roof popped after the first 6 months . There isn’t anything that screams a problem until it’s too late. We noticed things happening very quickly, however being new to a 5th wheel we thought a lot of what we were seeing was normal travel movement.

NHTSA ODI #11588371

Official recalls

26V044000 · Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle; Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Jan 26, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.

Consequence & remedy

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.

Additional source detail variants (2)

Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.

Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

25V784000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

Nov 13, 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Solitude and 2023 Momentum fifth wheels trailers. Loose or missing fasteners on the refrigerator cooling unit can allow excessive movement of the unit, possibly causing the propane line to crack and leak.

Consequence & remedy

Consequence: A propane leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect the refrigerator, and repair or replace it as necessary, free of charge. Owner notification letters were mailed December 23, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910052. This recall is an expansion of NHTSA recall 24V378.

25V061000 · Equipment:recreational Vehicle/trailer:materials:flooring; Structure:body:step/ladder

Feb 7, 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence & remedy

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Additional source detail variants (2)

Structure:body:step/ladder

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Equipment:recreational Vehicle/trailer:materials:flooring

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

24V861000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

Nov 15, 2024

Grand Design RV, LLC (Grand Design) is recalling certain 2022 Imagine, Reflection, Momentum, Solitude, and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.

Consequence & remedy

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect and replace quick disconnect as necessary, free of charge. Owner notification letters were mailed December 6, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910045. This recall supersedes Grand Design RV recall 22V308.

23V490000 · Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle; Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Jul 17, 2023

Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.

Consequence & remedy

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.

Additional source detail variants (2)

Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.

Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

22V603000 · Equipment:recreational Vehicle/trailer; Structure:body

Aug 9, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.

Consequence & remedy

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.

Additional source detail variants (2)

Equipment:recreational Vehicle/trailer

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.

Structure:body

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

22V308000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

May 6, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2022 Grand Design Imagine, Reflection, Momentum, Solitude and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.

Consequence & remedy

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will replace the quick disconnect fittings, free of charge. Owner notification letters were mailed May 30, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910029.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24029 · Frame Flex On Grand Design Fifth Wheel Recreational Trailers

Opened Oct 9, 2024 · No close date supplied

Status: open (inferred from source dates) · Structure

The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or entry door opening while in transit, some with objects lost on roadways, while six complaints also state that slideouts extended out partially. ODI has been in contact with both Grand Design and Lippert, the frame manufacturer. Grand Design believes that some frame flex, generally considered to be vertical movement in the upper deck area of the fifth wheel, is normal. However, Grand Design has developed a technical service bulletin (TSB), to evaluate concerns of excessive frame flex, defined as vertical movement greater than 3/8 inch. Per Grand Design, the frame flex is only occurring in the upper deck area of the fifth wheel and is resulting in cosmetic defects such as moving sidewalls, damage to cabinets, binding doors, etc. However, Lippert believes that the effects of frame flex may also extend back to the front axle of the trailer.While Lippert provides frames for multiple trailer manufacturers, the majority of complaints are for these Grand Design products. Cargo and entry doors that open and slideouts that extend while in transit increase the risk of injury or a crash. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to determine whether an unreasonable risk to motor vehicle safety exists. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.