Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports1 fire reports0 injury reports

Tires complaints

2 reports

Clear category filter

20,000 miles · Sep 16, 2025

StructureSuspensionTires

Read full complaint

The contact owns a 2022 Grand Design Solitude RV. The contact stated that while driving 65 MPH and hauling the RV, the rear passenger's side tire of the RV experienced a blowout. The contact was able to pull over to the side of the road. The contact replaced the tire with a regular-size spare tire; however, the rear passenger's side tire experienced a second blowout while driving on the same day. The contact stated that the tire failures caused damage to the RV. The vehicle was taken to the dealer, where it was diagnosed with frame flex, frame steel fracture, and missing screws around the hitch, and unparalleled axles. The RV was not repaired. The manufacturer was notified of the failure, and a Grand Design technician confirmed that the RV was experiencing excessive frame flex, which the contact related to the tire failure. The manufacturer recommended towing the RV to one of their locations for frame repairs, but the contact was advised that the repair of the axle damage caused by the tire failures, prior to towing the vehicle, would be paid for out-of-pocket. The RV was not repaired. The failure mileage was approximately 20,000.

NHTSA ODI #11687601

4,000 miles · Jul 17, 2025

TiresWheels

Read full complaint

The contact owns a 2022 Grand Design Solitude. The contact stated that the front passenger's side tire had lost air pressure due to a crack on the tire sidewall on three separate occasions. The contact stated that the TPMS had confirmed the lost of air pressure on the front passenger's side tire. Additionally, The contact stated that he had discovered the same crack on all three front passenger's side tires that were replaced. The contact stated the crack in all three tires appeared to have formed within an inch of the wheel valve stem. The contact stated that the tires were replaced; however, the failure persisted. No further information was available. The manufacturer was notified of the failure and a warranty claim was filed on after each failure. The vehicle was not repaired. The failure mileage was approximately 4,000.

NHTSA ODI #11674288

Official recalls

26V044000 · Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle; Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Jan 26, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.

Consequence & remedy

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.

Additional source detail variants (2)

Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.

Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

25V784000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

Nov 13, 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Solitude and 2023 Momentum fifth wheels trailers. Loose or missing fasteners on the refrigerator cooling unit can allow excessive movement of the unit, possibly causing the propane line to crack and leak.

Consequence & remedy

Consequence: A propane leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect the refrigerator, and repair or replace it as necessary, free of charge. Owner notification letters were mailed December 23, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910052. This recall is an expansion of NHTSA recall 24V378.

25V061000 · Equipment:recreational Vehicle/trailer:materials:flooring; Structure:body:step/ladder

Feb 7, 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence & remedy

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Additional source detail variants (2)

Structure:body:step/ladder

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Equipment:recreational Vehicle/trailer:materials:flooring

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

24V861000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

Nov 15, 2024

Grand Design RV, LLC (Grand Design) is recalling certain 2022 Imagine, Reflection, Momentum, Solitude, and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.

Consequence & remedy

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect and replace quick disconnect as necessary, free of charge. Owner notification letters were mailed December 6, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910045. This recall supersedes Grand Design RV recall 22V308.

23V490000 · Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle; Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Jul 17, 2023

Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.

Consequence & remedy

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.

Additional source detail variants (2)

Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.

Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

22V603000 · Equipment:recreational Vehicle/trailer; Structure:body

Aug 9, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.

Consequence & remedy

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.

Additional source detail variants (2)

Equipment:recreational Vehicle/trailer

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.

Structure:body

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

22V308000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

May 6, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2022 Grand Design Imagine, Reflection, Momentum, Solitude and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.

Consequence & remedy

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will replace the quick disconnect fittings, free of charge. Owner notification letters were mailed May 30, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910029.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24029 · Frame Flex On Grand Design Fifth Wheel Recreational Trailers

Opened Oct 9, 2024 · No close date supplied

Status: open (inferred from source dates) · Structure

The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or entry door opening while in transit, some with objects lost on roadways, while six complaints also state that slideouts extended out partially. ODI has been in contact with both Grand Design and Lippert, the frame manufacturer. Grand Design believes that some frame flex, generally considered to be vertical movement in the upper deck area of the fifth wheel, is normal. However, Grand Design has developed a technical service bulletin (TSB), to evaluate concerns of excessive frame flex, defined as vertical movement greater than 3/8 inch. Per Grand Design, the frame flex is only occurring in the upper deck area of the fifth wheel and is resulting in cosmetic defects such as moving sidewalls, damage to cabinets, binding doors, etc. However, Lippert believes that the effects of frame flex may also extend back to the front axle of the trailer.While Lippert provides frames for multiple trailer manufacturers, the majority of complaints are for these Grand Design products. Cargo and entry doors that open and slideouts that extend while in transit increase the risk of injury or a crash. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to determine whether an unreasonable risk to motor vehicle safety exists. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.