Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports1 fire reports0 injury reports

Service Brakes complaints

3 reports

Clear category filter

10,080 miles · Aug 22, 2025

Service BrakesSuspension

Read full complaint

The contact owns a 2022 Grand Design Solitude. The contact stated that while pulling into a campground she was informed to check the tires. The RV was taken to a tire center where it was discovered that the brakes had crumbled and there was a spring inside. Additionally, the equalizer was cracked. The contact stated that while driving 75 MPH on the highway, a wheel on the RV detached. The RV was taken to an independent mechanic who determined that the axle was cracked. The local dealer was contacted several times. The RV was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 10,080.

NHTSA ODI #11682444

Mileage unknown · Feb 26, 2024

Service Brakes

Read full complaint

1. **Immediate Call to Halt ABS Brake System Use:** - My recent experience on an 8-mile grade, where the newly installed ABS module and two new axles and brakes failed catastrophically, has left me with no choice but to demand an immediate cessation of the use of these ABS brake systems in your RVs. Despite being in low gear, my truck's brakes overheated to the point of failure, rendering them unable to slow the RV. This terrifying event could have ended in tragedy were it not for the runaway truck lane. After over a decade 1. **Background of the Issue:** - **Severe Brake Failure:** After only 1,900 miles of usage, then again 100 miles into total replacement and again after 700 miles after the next total replacement of axles, brakes, and ABS unit. I faced a critical safety issue several times as have many other Grand Design ABS brake newer model owners - the complete disintegration of all four brakes. The danger was alarmingly signaled by O2 alarms during stops on the first time of the several catastrophic failures, revealing a life-threatening flaw that placed my entire family in peril. 2. **Systemic Failures and Inadequate Response:** - **Widespread Safety Concerns:** This issue is not unique to my vehicle. Numerous owners of the 2021-2022 and 2023 models have experienced similar catastrophic brake failures, signaling a systemic flaw in Grand Design's production. Grand Design allegedly denies that any other owners have had an issue. Hundreds have posted their own similar brake failures with the several RV brands carrying the ABS module, and dozens of Grand Design owners have now done the same. There is lives at risk daily as the weather warms up and families in NEW RV's travel.

NHTSA ODI #11574061

Mileage unknown · Jul 20, 2023

Service Brakes

All four brakes burned up and failed. The landing gear fell out of the assemblies. The brakes were metal on metal and heated up so much the turned the drums red. This fifth wheel is only 6 months old and has had numerous problems not limited to the brakes and landing gear.

NHTSA ODI #11533436

Official recalls

26V044000 · Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle; Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Jan 26, 2026

Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.

Consequence & remedy

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.

Additional source detail variants (2)

Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.

Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

25V784000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

Nov 13, 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Solitude and 2023 Momentum fifth wheels trailers. Loose or missing fasteners on the refrigerator cooling unit can allow excessive movement of the unit, possibly causing the propane line to crack and leak.

Consequence & remedy

Consequence: A propane leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect the refrigerator, and repair or replace it as necessary, free of charge. Owner notification letters were mailed December 23, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910052. This recall is an expansion of NHTSA recall 24V378.

25V061000 · Equipment:recreational Vehicle/trailer:materials:flooring; Structure:body:step/ladder

Feb 7, 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence & remedy

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Additional source detail variants (2)

Structure:body:step/ladder

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Equipment:recreational Vehicle/trailer:materials:flooring

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

24V861000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

Nov 15, 2024

Grand Design RV, LLC (Grand Design) is recalling certain 2022 Imagine, Reflection, Momentum, Solitude, and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.

Consequence & remedy

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect and replace quick disconnect as necessary, free of charge. Owner notification letters were mailed December 6, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910045. This recall supersedes Grand Design RV recall 22V308.

23V490000 · Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle; Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Jul 17, 2023

Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.

Consequence & remedy

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.

Additional source detail variants (2)

Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.

Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle

Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.

22V603000 · Equipment:recreational Vehicle/trailer; Structure:body

Aug 9, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.

Consequence & remedy

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.

Additional source detail variants (2)

Equipment:recreational Vehicle/trailer

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.

Structure:body

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

22V308000 · Equipment:recreational Vehicle/trailer:lpg Systems:lines And Fittings

May 6, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2022 Grand Design Imagine, Reflection, Momentum, Solitude and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.

Consequence & remedy

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will replace the quick disconnect fittings, free of charge. Owner notification letters were mailed May 30, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910029.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24029 · Frame Flex On Grand Design Fifth Wheel Recreational Trailers

Opened Oct 9, 2024 · No close date supplied

Status: open (inferred from source dates) · Structure

The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or entry door opening while in transit, some with objects lost on roadways, while six complaints also state that slideouts extended out partially. ODI has been in contact with both Grand Design and Lippert, the frame manufacturer. Grand Design believes that some frame flex, generally considered to be vertical movement in the upper deck area of the fifth wheel, is normal. However, Grand Design has developed a technical service bulletin (TSB), to evaluate concerns of excessive frame flex, defined as vertical movement greater than 3/8 inch. Per Grand Design, the frame flex is only occurring in the upper deck area of the fifth wheel and is resulting in cosmetic defects such as moving sidewalls, damage to cabinets, binding doors, etc. However, Lippert believes that the effects of frame flex may also extend back to the front axle of the trailer.While Lippert provides frames for multiple trailer manufacturers, the majority of complaints are for these Grand Design products. Cargo and entry doors that open and slideouts that extend while in transit increase the risk of injury or a crash. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to determine whether an unreasonable risk to motor vehicle safety exists. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.