2021 Grand Design Solitude

The contact owns a 2021 Grand Design Solitude Trailer. The contact stated that while driving approximately 60-65 MPH, the cargo doors opened independently. Additionally, the contact stated that the built-in tables were detaching from the wall, and the wall panels were separating in the bunk room. The contact also noticed that the walls were separating from the floor. The contact related the failure to NHTSA Action Number: PE24029 (Structure). The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not notified of the failure. The failure mileage was unknown.

Since we have purchased our RV we have had several issues with it. Since the first trip the entry door will not stay shut while in transit and continues through today We had requested the dealer check it out but the issue was not remedied. During the time we have owned the RV we have had to have the roof replaced due to poor workmanship at the factory. We had had the TSB for the rear compartment completed however the cargo doors are not aligned properly and one door on the driver side is starting to wear through the aluminum on the side. We have also had the rear cargo door pop open on more than one occasion. We have also had the TSB performed for the improper lag screws being installed at the factory. On one corner of the front of the frame which had cracked they used a 1/8th inch screw with a 1 inch washer instead of a 1/2 by 3 1/2 inch lag screw. The floor in the living room area is dropping up to 1/2 inch at the wall in the front and back of the slides. We have walls starting to separate in the coach as well as the stairs separating from the walls going into the kitchen and the bedroom. There is trim separating from the walls in the bedroom. While this is not the whole list of what is going on it is a good representation of the issues we are facing.

Issue Description: On multiple occasions during travel, cargo doors and the main entry door have opened while the vehicle is in motion. We have been fortunate to notice the doors flying open, allowing us to quickly stop before losing any cargo. Cargo Risk: These compartments carry cargo. When the door flies open, there is a significant risk of cargo flying out of the vehicle. This creates a hazard for oncoming motorists, either through airborne cargo or cargo on the roadway. Evidence of Problems: Missing sidewall screws in front storage. Loose sidewall screws. Bulging on the frame on both edges adjacent to the pin box. Poor alignment of cargo door and entry door. Kitchen slide is binding, preventing proper opening and closing Symptoms / concerns of excessive frame flex

On multiple occasions during travel, We have had cargo doors and the main entry door open when going down the road. We have been fortunate that we have noticed the door flying open, to where we can quickly stop before losing any cargo. Because these are cargo doors, we carry cargo in these compartments. When the door flies open, there is a huge risk of cargo flying out of the vehicle and creating a hazard for oncoming motorists (flying through the air or upon the roadway). We have adjusted the latches on these doors to no avail. we get them to where they work and hold fine, then will start coming open again. We believe based on other evidence (missing sidewall lag bolts, loose sidewall lag bolts, bent sidewall lag bolts, popping sounds when raising or lowering unit, broken slide mechanisms, excessive sawdust on the inside of the vehicle, doors on internal cabinets unable to be opened due to interference, millwork trim falling off) that there is a frame failure or suspension issue with this vehicle causing excessive flex. These issues pose a life safety risk to any person traveling on a roadway.