Structure. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports1 fire reports0 injury reports

Equipment complaints

1 reports

Clear category filter

Mileage unknown · Jul 29, 2026

EquipmentStructure

Read full complaint

The contact owns a 2020 Grand Design Recreational Solitude RV. The contact stated that there was extensive frame flex in the RV. The contact stated that the slide-outs rolled out while turning. The contact stated that there was an issue with the kingpin that related to the flex frame. The doors were out of alignment and there were screws popping up out of the floor. The contact associated the failure with NHTSA Action Number: PE24029 (Structure). The RV was taken to the local dealer and was diagnosed with cracks in the frame. The RV was not repaired. The manufacturer was notified of the failure, and the RV was inspected, and no cracks were found. The failure mileage was unknown.

NHTSA ODI #11753457

Official recalls

25V061000 · Equipment:recreational Vehicle/trailer:materials:flooring; Structure:body:step/ladder

Feb 7, 2025

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence & remedy

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Additional source detail variants (2)

Structure:body:step/ladder

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

Remedy: Dealers will reinforce the current step tread with a metal bracket, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910048.

Equipment:recreational Vehicle/trailer:materials:flooring

Grand Design RV, LLC (Grand Design) is recalling certain 2019-2024 Grand Design Solitude fifth wheel trailers. The step tread joints may be unsupported, causing the tread to break.

Consequence: A broken step increases the risk of injury.

22V038000 · Equipment:appliance:refrigerator

Jan 28, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.

Consequence & remedy

Consequence: An electrical arc increases the risk of a fire.

Remedy: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.

20V523000 · Equipment:appliance:refrigerator

Aug 28, 2020

Grand Design RV, LLC (Grand Design) is recalling certain 2017-2021 Solitude recreational trailers. The liquid propane (LP) supply line that runs through the exterior lower refrigerator compartment may contact the burner tube of the refrigerator, possibly damaging the line and causing an LP gas leak.

Consequence & remedy

Consequence: An LP gas leak increases the risk of a fire.

Remedy: Grand Design will notify owners, and dealers will inspect the LP supply line for damage, replacing it as necessary. All lines in the vicinity of the burner tube will be wrapped in a thermal foil heat barrier material, then secured away from the burner tube of the refrigerator with additional P-clamps, free of charge. The recall began September 17, 2020. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910021.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24029 · Frame Flex On Grand Design Fifth Wheel Recreational Trailers

Opened Oct 9, 2024 · No close date supplied

Status: open (inferred from source dates) · Structure

The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or entry door opening while in transit, some with objects lost on roadways, while six complaints also state that slideouts extended out partially. ODI has been in contact with both Grand Design and Lippert, the frame manufacturer. Grand Design believes that some frame flex, generally considered to be vertical movement in the upper deck area of the fifth wheel, is normal. However, Grand Design has developed a technical service bulletin (TSB), to evaluate concerns of excessive frame flex, defined as vertical movement greater than 3/8 inch. Per Grand Design, the frame flex is only occurring in the upper deck area of the fifth wheel and is resulting in cosmetic defects such as moving sidewalls, damage to cabinets, binding doors, etc. However, Lippert believes that the effects of frame flex may also extend back to the front axle of the trailer.While Lippert provides frames for multiple trailer manufacturers, the majority of complaints are for these Grand Design products. Cargo and entry doors that open and slideouts that extend while in transit increase the risk of injury or a crash. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to determine whether an unreasonable risk to motor vehicle safety exists. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.