Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 16 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
16 reports
Mileage unknown · Sep 2, 2015
Unknown Or OtherFire
THE 5TH WHEEL WAS 2 1/2 MONTHS OLD. AFTER RETURNING FROM A 250 MILE TRIP WE ATTEMPTED TO OPEN THE BEDROOM SLIDE AND IT WOULDN'T OPEN. I PLUGGED IN THE ELECTRICAL PLUG AND OPENED THE SLIDE IN ORDER TO UNLOAD THE REMAINING CLOTHES, THEN I CLOSED THE SLIDE. THIS WAS AT APPROXIMATELY 8:00PM. AT 10:45PM MY GIRLFRIEND HEARD THREE L…
Read full complaint
THE 5TH WHEEL WAS 2 1/2 MONTHS OLD. AFTER RETURNING FROM A 250 MILE TRIP WE ATTEMPTED TO OPEN THE BEDROOM SLIDE AND IT WOULDN'T OPEN. I PLUGGED IN THE ELECTRICAL PLUG AND OPENED THE SLIDE IN ORDER TO UNLOAD THE REMAINING CLOTHES, THEN I CLOSED THE SLIDE. THIS WAS AT APPROXIMATELY 8:00PM. AT 10:45PM MY GIRLFRIEND HEARD THREE LOUD EXPLOSIONS AND WE RAN OUTSIDE TO FIND THE 5TH WHEEL TOTALLY ENGULFED IN FLAMES. I BELIEVE NOW THE EXPLOSIONS WERE THE TIRES ON THE 5TH WHEEL. THE FRAMES (BOTH OF THEM) THAT RUN THE LENGTH OF THE 5TH WHEEL WERE BENT APPROXIMATELY 18" TOWARD THE PASSENGER SIDE OF THE TRAILER. IN ADDITION BOTH AXLES ARE BEND DOWNWARD. I DON'T IF THIS A RESULT OF THE HEAT OR NOT.
NHTSA ODI #10761146
2,500 miles · Aug 9, 2015
Suspension
VIN STICKER ON SIDE OF FIFTH WHEEL TRAILER STATES "6000 LB AXLES" BUT TRAILER HAD UNDERSIZED AXLES RATED AT 5200 LB AXLES! GRAND DESIGN RV OWNERS PLEASE CHECK YOU AXLES BEFORE SOMEONE GETS HURT!
NHTSA ODI #10747286
2,000 miles · Aug 7, 2015
Service Brakes
SHORTLY AFTER DELIVERY OF A BRAND NEW 5TH WHEEL TRAVEL TRAILER I BEGAN TO NOTICE GREASE LEAKING FROM THE DRUM. AFTER PULLING THE BRAKE DRUMS I FOUND DARK GREASE HAD MIGRATED PAST THE SEALS AND IN TO THE DRUMS COATING THE INSIDE OF THE DRUMS, BRAKE PAD SURFACES AND MAGNET. THE BRAKE SYSTEM ON MY TRAILER ARE MANUFACTURED AND AS…
Read full complaint
SHORTLY AFTER DELIVERY OF A BRAND NEW 5TH WHEEL TRAVEL TRAILER I BEGAN TO NOTICE GREASE LEAKING FROM THE DRUM. AFTER PULLING THE BRAKE DRUMS I FOUND DARK GREASE HAD MIGRATED PAST THE SEALS AND IN TO THE DRUMS COATING THE INSIDE OF THE DRUMS, BRAKE PAD SURFACES AND MAGNET. THE BRAKE SYSTEM ON MY TRAILER ARE MANUFACTURED AND ASSEMBLED BY LIPPERT COMPONENTS, IND.
NHTSA ODI #10746975
2,500 miles · Jul 29, 2015
Service Brakes
I WAS RETURNING FROM A TRIP, WHEN THE ELECTRIC BRAKES ON MY 5TH WHEEL TRAILER STARTED NOT WORKING. EVEN WITH THE BRAKE CONTROLLER GAIN TURNED TO MAXIMUM, THERE WAS LITTLE TO NO BRAKING. I INSPECTED THE BRAKES WHEN I GOT HOME AND FOUND THAT GREASE WAS LEAKING FROM ALL 4 WHEEL BEARING GREASE SEALS COATING THE BRAKE SHOES. THIS …
Read full complaint
I WAS RETURNING FROM A TRIP, WHEN THE ELECTRIC BRAKES ON MY 5TH WHEEL TRAILER STARTED NOT WORKING. EVEN WITH THE BRAKE CONTROLLER GAIN TURNED TO MAXIMUM, THERE WAS LITTLE TO NO BRAKING. I INSPECTED THE BRAKES WHEN I GOT HOME AND FOUND THAT GREASE WAS LEAKING FROM ALL 4 WHEEL BEARING GREASE SEALS COATING THE BRAKE SHOES. THIS WAS ONLY THE 3RD TRIP I HAD TAKEN WITH THIS UNIT AND HAD TOWED IT LESS THAN 2500 MILES TOTAL SINCE PURCHASE IN AUGUST 2014. STOPPING DISTANCE WAS MUCH MORE THAN NORMAL WITH NO TRAILER BRAKES. AN ACCIDENT WOULD HAVE OCCURRED HAD THERE BEEN AN UNUSUAL SITUATION REQUIRING A SUDDEN STOP. MANUFACTURE IS CORRECTING THE PROBLEM UNDER WARRANTY WITH TOTAL BRAKE AND SEAL REPLACEMENT.
NHTSA ODI #10744672
400 miles · Jul 15, 2015
Service Brakes
THIS IS A NEW TRAILER THAT HAD GREASE ON ALL FOUR BRAKES DUE TO GREASE PASSING THROUGH THE SEALS. THE MANUFACTURER IS THE ONLY ONE THAT HAD PACKED THE WHEEL BEARINGS. THE HUBS WERE FILLED WITH GREASE INDICATING THAT THE "EASY-LUBE" FEATURE HAD BEEN USED TO PACK THE BEARINGS. I DON'T BELIEVE THE SEALS ARE BAD, I BELIEVE THE PR…
Read full complaint
THIS IS A NEW TRAILER THAT HAD GREASE ON ALL FOUR BRAKES DUE TO GREASE PASSING THROUGH THE SEALS. THE MANUFACTURER IS THE ONLY ONE THAT HAD PACKED THE WHEEL BEARINGS. THE HUBS WERE FILLED WITH GREASE INDICATING THAT THE "EASY-LUBE" FEATURE HAD BEEN USED TO PACK THE BEARINGS. I DON'T BELIEVE THE SEALS ARE BAD, I BELIEVE THE PROCEDURES ARE FLAWED. FIFTH WHEELS OF THIS WEIGHT SHOULD NOT HAVE THIS TYPE OF AXLE. THERE AREN'T ANY SEALS THAT ARE GOING TO CONTAIN THE GREASE FROM A GREASE GUN THAT IS FILLING THE HUB .
NHTSA ODI #10734300
2,500 miles · Jul 9, 2015
Service Brakes
LIPPERT BRAKE SHOES AND MAGNETS CONTAMINATED WITH GREASE. GREASE SEAL BLEW OUT WITH EXCESSIVE GREASE AND/OR FAULTY SEALS. STOPPING ABILITY OF VEHICLE EXTREMELY IMPACTED AND DANGEROUS
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Consequence & remedy
Consequence: An electrical arc increases the risk of a fire.
Remedy: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2017 Reflection recreational trailers, model 357BHS and 367BHS, manufactured November 12, 2014, to September 22, 2016. The affected vehicles have an incorrect Gross Axle Weight Rating (GAWR) on the Federal Certification Label, stating a GAWR of 7,000 lbs when the actual GAWR is 6,400 lbs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the operator loads the vehicle to the GAWR on the label, it can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will install a corrected Federal Certification Label, free of charge. Owners will also have the option to replace the Certification Label themselves, free of charge. The recall began on October 28, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910007.
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: The inaccurate label may result in users overloading their trailer, resulting in axle or tire failure and increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
Additional source detail variants (2)
Equipment:other:labels
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence: The inaccurate label may result in users overloading their trailer, resulting in axle or tire failure and increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence: The inaccurate label may result in users overloading their trailer, resulting in axle or tire failure and increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2016 Reflection 303RLS, 308BHTS and 313RLTS, model 2016 Solitude 375RE trailers manufactured March 12, 2015, to April 6, 2015. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.
Consequence & remedy
Consequence: If the wheel studs break, the wheel could detach from the vehicle, increasing the risk of a crash.
Remedy: Grand Design has notified owners, and dealers will replace any affected wheel hub, free of charge. The recall began on April 14, 2015. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910003.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2015 Grand Design Reflection Problems, Complaints & Recalls | Skip That Year
Illustration