4 GOODYEAR MARATHON WERE INSTALLED ON OUR REFLECTION FIFTH WHEEL CAMPER. THE ORIGINAL TIRES ON THE CAMPER WERE EXCHANGED FOR THE GOODYEAR TIRES. DOT 2VUN1LHR4213 THROUGH 4813. ON JULY 24,2016 THE TIRES WERE ADJUSTED TO 80 PSI. AFTER ABOUT 65 MILES INTO OUR TRIP THE DRIVER SIDE FRONT TIRE EXPLODED AND SHEARED THE TREAD FROM THE …
Read full complaint
4 GOODYEAR MARATHON WERE INSTALLED ON OUR REFLECTION FIFTH WHEEL CAMPER. THE ORIGINAL TIRES ON THE CAMPER WERE EXCHANGED FOR THE GOODYEAR TIRES. DOT 2VUN1LHR4213 THROUGH 4813. ON JULY 24,2016 THE TIRES WERE ADJUSTED TO 80 PSI. AFTER ABOUT 65 MILES INTO OUR TRIP THE DRIVER SIDE FRONT TIRE EXPLODED AND SHEARED THE TREAD FROM THE TIRE. THE EXPLODING TIRE CAUSED $3700 WORTH OF DAMAGE AS QUOTED BY AN AUTHORIZED DEALER. THE TIRE WAS TURNED INTO AN AUTHORIZED GOOD YEAR DEALER AND A REPLACEMENT PROTOW TIRE WAS PURCHASED FOR $144. ON THE RETURN TRIP THE OTHER GOODYEAR MARATHON SAME SIDE SEPARATED. THIS TIRE WAS RETURNED TO GOODYEAR FOR EVALUATION. TIRE SIZE ST 235-80-16 LOAD RANGE E.DOT 2VUN 1LHR 4813 THE FIRST TIRE EXPLOSION WAS VIOLENT, THROWING FRAGMENTS INTO FOLLOWING TRAFFIC. ONE NEAR ACCIDENT WAS OBSERVED OF TRAFFIC TRYING TO AVOID THE SHARDS WITH THE CAR APPEARING TO GO SIDEWAYS. THE SECOND EXPLOSION WAS LESS VIOLENT BUT STILL LEFT LARGE CHUNKS IN THE HIGHWAY. STATE POLICE WERE CALLED FRO ASSISTANCE.
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Consequence & remedy
Consequence: An electrical arc increases the risk of a fire.
Remedy: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2017 Reflection recreational trailers, model 357BHS and 367BHS, manufactured November 12, 2014, to September 22, 2016. The affected vehicles have an incorrect Gross Axle Weight Rating (GAWR) on the Federal Certification Label, stating a GAWR of 7,000 lbs when the actual GAWR is 6,400 lbs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: If the operator loads the vehicle to the GAWR on the label, it can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will install a corrected Federal Certification Label, free of charge. Owners will also have the option to replace the Certification Label themselves, free of charge. The recall began on October 28, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910007.
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence & remedy
Consequence: The inaccurate label may result in users overloading their trailer, resulting in axle or tire failure and increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
Additional source detail variants (2)
Equipment:other:labels
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence: The inaccurate label may result in users overloading their trailer, resulting in axle or tire failure and increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Grand Design RV, LLC (Grand Design) is recalling certain model year 2014-2016 Reflection fifth-wheel trailers manufactured September 5, 2013, to June 30, 2015. The affected vehicles may have been manufactured with axles rated to 5200 lbs. instead of 6000 lbs. as designed and as listed on the Certification Label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence: The inaccurate label may result in users overloading their trailer, resulting in axle or tire failure and increasing the risk of a crash.
Remedy: Grand Design will notify owners, and dealers will inspect the trailers and will replace any axle that is only rated to 5200 lbs. with an axle rated to 6000 lbs., free of charge. The recall began on September 10, 2015. Owners may contact Grand Design customer service at 1-574-825-8000 ext. 2015. Grand Design's number for this recall is 910004.
Grand Design RV, LLC (Grand Design) is recalling certain model year 2015-2016 Reflection 303RLS, 308BHTS and 313RLTS, model 2016 Solitude 375RE trailers manufactured March 12, 2015, to April 6, 2015. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.
Consequence & remedy
Consequence: If the wheel studs break, the wheel could detach from the vehicle, increasing the risk of a crash.
Remedy: Grand Design has notified owners, and dealers will replace any affected wheel hub, free of charge. The recall began on April 14, 2015. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910003.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2015 Grand Design Reflection Problems, Complaints & Recalls | Skip That Year
Illustration