The contact owns a 2023 Grand Design Momentum. The contact stated that while driving at an undisclosed speed, the entry side doors unexpectedly opened. Additionally, the slides of the trailer occasionally unexpectedly extend without operator input. The contact stated that the front frame of the RV was cracked. The RV was taken t…
Read full complaint
The contact owns a 2023 Grand Design Momentum. The contact stated that while driving at an undisclosed speed, the entry side doors unexpectedly opened. Additionally, the slides of the trailer occasionally unexpectedly extend without operator input. The contact stated that the front frame of the RV was cracked. The RV was taken to the dealer, where it was diagnosed with structural failure of the front frame. The contact was not informed whether the frame could be repaired or needed to be replaced. The RV was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 5,000.
NHTSA ODI #11719478
Mileage unknown · Oct 27, 2025
Latches/locks/linkagesStructure
The front of our grand design momentum fifth wheel camper has sustained some structural failure. Our bedroom slide will no longer stay closed when driving down the road. Our storage doors will also open every now and then when we encounter rough bumps or rough roads. We began to notice some small damage inside the front bedroom …
Read full complaint
The front of our grand design momentum fifth wheel camper has sustained some structural failure. Our bedroom slide will no longer stay closed when driving down the road. Our storage doors will also open every now and then when we encounter rough bumps or rough roads. We began to notice some small damage inside the front bedroom of the unit as well. The camper has been untowable for nearly 6 months, with no help from the manufacturer. Even though the have issued an extended warranty for like issues.
NHTSA ODI #11695737
Mileage unknown · Feb 27, 2025
Latches/locks/linkagesStructureUnknown Or Other
The upper deck portion of the 5th wheel frame has been moving independently of the walls which is commonly referred to as "frame flex" or "frame failure", as evidenced by the following: a gap between the wall and floor in the bedroom above the upper deck, pin box receding into the trailer, loose, bent, and missing lag bolts whi…
Read full complaint
The upper deck portion of the 5th wheel frame has been moving independently of the walls which is commonly referred to as "frame flex" or "frame failure", as evidenced by the following: a gap between the wall and floor in the bedroom above the upper deck, pin box receding into the trailer, loose, bent, and missing lag bolts which connect the upper deck to the frame, irregular slide operation in the bedroom above the upper deck, man doors in the trailer being out of square, cargo doors opening during travel, separation of the seam between the filon and "nose", squeaky flooring in the bedroom above the upper deck. The manufacturer has offered to transport the trailer to their manufacturing facility and perform what they are calling a "super" inspection if we agree to sign a release and non-disclosure agreement. The structural components of the trailer are covered by a 5 year warranty which should not require a release and NDA. The trailer is not safe and would be irresponsible to use in its current condition. The "super inspection" repair scope is vague, and the required legal agreement should not be required because the trailer is within the warranty period. The trailer spent almost 10 months at an authorized repair facility. The work done at the repair facility did not resolve or fully and correctly address the frame related issues. The repair facility has in its possession approx 400 pictures of the work performed on our trailer which they will not release to us. The work orders associated with the work done during the 10 months that the trailer was in the repair facility are vague and do not detail what was or was not done.
NHTSA ODI #11645301
Mileage unknown · Jul 6, 2024
Latches/locks/linkages
On this RV the back man door will not close/latch. We have to use a bungy cord to keep it closed. The latch on the door doesn't catch on the wall catch plate.
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Additional source detail variants (2)
Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Solitude and 2023 Momentum fifth wheels trailers. Loose or missing fasteners on the refrigerator cooling unit can allow excessive movement of the unit, possibly causing the propane line to crack and leak.
Consequence & remedy
Consequence: A propane leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Dealers will inspect the refrigerator, and repair or replace it as necessary, free of charge. Owner notification letters were mailed December 23, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910052. This recall is an expansion of NHTSA recall 24V378.
Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.
Consequence & remedy
Consequence: The tread may detach from the step, increasing the risk of a trip and fall injury.
Remedy: Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.
Additional source detail variants (2)
Structure:body:step/ladder
Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.
Consequence: The tread may detach from the step, increasing the risk of a trip and fall injury.
Remedy: Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.
Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.
Consequence: The tread may detach from the step, increasing the risk of a trip and fall injury.
Remedy: Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2024 Momentum 23G and 25G travel trailers. The installed safety chains are underrated for the Gross Vehicle Weight Rating (GVWR).
Consequence & remedy
Consequence: Underrated chains can allow the trailer to detach from the tow vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the safety chains, free of charge. Owner notification letters were mailed September 6, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910040.
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Additional source detail variants (2)
Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Grand Design RV, LLC (Grand Design) is recalling certain 2023 Momentum and Reflection travel trailers, equipped with certain 5200 and 6000 CURT RV axles. The axles may have an improperly tightened grease fitting that can separate and cause damage, possibly resulting in wheel detachment.
Consequence & remedy
Consequence: A detached wheel increases the risk of a crash.
Remedy: Dealers will inspect and repair, or replace the grease fittings, as necessary, free of charge. Owner notification letters were mailed July 28, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910038.
Grand Design RV, LLC (Grand Design) is recalling certain 2023 Momentum toy haulers. The Cargo Carrying Capacity (CCC) label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Incorrect weight information on the label can cause the vehicle to be overloaded, increasing the risk of a crash.
Remedy: Dealers will remove and replace the label, free of charge. Owner notification letters were mailed July 10, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910036.
Grand Design RV, LLC (Grand Design) is recalling 2022-2023 Momentum fifth wheels. The electric ramp door cut-off switch may allow for continuous power to the ramp door, which can cause the door to fall.
Consequence & remedy
Consequence: A falling ramp door increases the risk of injury.
Remedy: Dealers will replace the door mechanism, free of charge. Owner notification letters were mailed August 24, 2022. Owners may contact Grand Design custom service at 1-574-825-9679. Grand Design's number for this recall is 910032.
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.
Consequence & remedy
Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.
Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.
Additional source detail variants (2)
Equipment:recreational Vehicle/trailer
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.
Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.
Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.
Structure:body
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.
Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.
Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE24029 · Frame Flex On Grand Design Fifth Wheel Recreational Trailers
Opened Oct 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Structure
The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or entry door opening while in transit, some with objects lost on roadways, while six complaints also state that slideouts extended out partially. ODI has been in contact with both Grand Design and Lippert, the frame manufacturer. Grand Design believes that some frame flex, generally considered to be vertical movement in the upper deck area of the fifth wheel, is normal. However, Grand Design has developed a technical service bulletin (TSB), to evaluate concerns of excessive frame flex, defined as vertical movement greater than 3/8 inch. Per Grand Design, the frame flex is only occurring in the upper deck area of the fifth wheel and is resulting in cosmetic defects such as moving sidewalls, damage to cabinets, binding doors, etc. However, Lippert believes that the effects of frame flex may also extend back to the front axle of the trailer.While Lippert provides frames for multiple trailer manufacturers, the majority of complaints are for these Grand Design products. Cargo and entry doors that open and slideouts that extend while in transit increase the risk of injury or a crash. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to determine whether an unreasonable risk to motor vehicle safety exists. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 Grand Design Momentum Problems, Complaints & Recalls | Skip That Year
Illustration