The contact owns a 2022 Grand Design Recreational Trailer. The contact stated that while the trailer was parked, an inspection of the trailer revealed that the front passenger-side door was inoperable and failed to properly open and close. The contact also noticed sawdust present in the bedroom area of the trailer. Additionally,…
Read full complaint
The contact owns a 2022 Grand Design Recreational Trailer. The contact stated that while the trailer was parked, an inspection of the trailer revealed that the front passenger-side door was inoperable and failed to properly open and close. The contact also noticed sawdust present in the bedroom area of the trailer. Additionally, the generator compartment was inoperable and failed to lock properly. The contact received a recall notification from the manufacturer related to the trailer. The trailer was taken to the dealer; however, the trailer was not diagnosed or repaired. The dealer informed the contact that the trailer needed to be inspected, and photographs of the failure were sent to a specialist for further evaluation. The contact later stated that the dealer advised that the inspection had been canceled after the photographs were submitted. The trailer was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 200.
NHTSA ODI #11737122
Mileage unknown · Jul 24, 2025
Latches/locks/linkagesStructure
The contact owns a 2022 Grand Design Momentum RV. The contact stated while driving at an undisclosed speed, the camper was bouncing up and down. Due to the failure, the furniture detached from the wall. In addition, the bedroom floor fractured and pieces of the floor were separated. The manufacturer was made aware of the failure…
Read full complaint
The contact owns a 2022 Grand Design Momentum RV. The contact stated while driving at an undisclosed speed, the camper was bouncing up and down. Due to the failure, the furniture detached from the wall. In addition, the bedroom floor fractured and pieces of the floor were separated. The manufacturer was made aware of the failure and the contact was advised to take the camper to a dealer in North Carolina, a six-hour drive away. The dealer determined that the failure was the result of nine lag bolts that were missing from the camper frame. The contact was informed that the failure was due to a manufacturer defect. The camper was repaired; however, the failure reoccurred. The contact stated that the pin box shifted downward, and the main slide on the passenger's side fractured and shifted down towards the ground and the furniture detached away from the wall. The main bedroom floor was fractured and sagging. The contact stated that while the RV was hitched and traveling, the main door unlatched and opened. Additionally, the garage door was bowed due to the failure of the frame. The manufacturer was made aware of the failure and a case was filed. The contact was advised to take the camper back to the dealer. The contact requested the manufacturer to buy the camper back, however the request was denied.
NHTSA ODI #11675985
Mileage unknown · Jan 22, 2025
Latches/locks/linkagesStructure
I am having the frame flex issues as well as others. I’m not getting anywhere with grand design. The doors come open when traveling if not strapped from the inside. Pin box on the hitch moves excessively, interior panels are moving in the front, middle and rear of the trailer.
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Additional source detail variants (2)
Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC (Grand Design) is recalling certain 2021-2024 Momentum and 2022-2024 Solitude Fifth Wheel trailers. The U-bolt may become loose due to inadequate preload and preload losses, causing the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will replace the axle attachment components, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910054. This recall supersedes NHTSA Recalls 23V490 and 24V193.
Grand Design RV, LLC (Grand Design) is recalling certain 2022 Imagine, Reflection, Momentum, Solitude, and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.
Consequence & remedy
Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Dealers will inspect and replace quick disconnect as necessary, free of charge. Owner notification letters were mailed December 6, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910045. This recall supersedes Grand Design RV recall 22V308.
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2024 Momentum 23G and 25G travel trailers. The installed safety chains are underrated for the Gross Vehicle Weight Rating (GVWR).
Consequence & remedy
Consequence: Underrated chains can allow the trailer to detach from the tow vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the safety chains, free of charge. Owner notification letters were mailed September 6, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910040.
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence & remedy
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Additional source detail variants (2)
Suspension:rear:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Suspension:front:springs:leaf Spring ASSEMBLY:U-BOLT, Leaf Spring To Axle
Grand Design RV, LLC. (Grand Design) is recalling certain 2021-2024 Momentum and Solitude fifth wheels, equipped with certain CURT 7000 and 8000 lb axles. The U-bolts may have been improperly tightened, which can cause the axle to move out of position.
Consequence: An axle that moves out of position can cause a loss of vehicle control and increase the risk of a crash.
Remedy: Dealers will inspect and tighten the U-bolts, as necessary. Any damaged components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed August 16, 2023. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910039.
Grand Design RV, LLC (Grand Design) is recalling 2022-2023 Momentum fifth wheels. The electric ramp door cut-off switch may allow for continuous power to the ramp door, which can cause the door to fall.
Consequence & remedy
Consequence: A falling ramp door increases the risk of injury.
Remedy: Dealers will replace the door mechanism, free of charge. Owner notification letters were mailed August 24, 2022. Owners may contact Grand Design custom service at 1-574-825-9679. Grand Design's number for this recall is 910032.
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.
Consequence & remedy
Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.
Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.
Additional source detail variants (2)
Equipment:recreational Vehicle/trailer
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.
Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.
Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.
Structure:body
Grand Design RV, LLC (Grand Design) is recalling certain 2022-2023 Momentum, Solitude, Imagine, Reflection, and Transcend travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.
Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.
Remedy: Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by August 22, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910031.
Grand Design RV, LLC (Grand Design) is recalling certain 2022 Momentum travel trailers. The 110-volt power supply wire was incorrectly wired directly into the solar inverter, which can overload the circuit and cause the power supply wire to overheat.
Consequence & remedy
Consequence: An overheated power supply wire increases the risk of a fire.
Remedy: Dealers will rewire the 110-volt power wire, free of charge. Owner notification letters were mailed July 25, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910030.
Grand Design RV, LLC (Grand Design) is recalling certain 2022 Momentum travel trailers. The 110-volt power supply wire was incorrectly wired directly into the solar inverter, which can overload the circuit and cause the power supply wire to overheat.
Consequence: An overheated power supply wire increases the risk of a fire.
Remedy: Dealers will rewire the 110-volt power wire, free of charge. Owner notification letters were mailed July 25, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910030.
Electrical System
Grand Design RV, LLC (Grand Design) is recalling certain 2022 Momentum travel trailers. The 110-volt power supply wire was incorrectly wired directly into the solar inverter, which can overload the circuit and cause the power supply wire to overheat.
Consequence: An overheated power supply wire increases the risk of a fire.
Remedy: Dealers will rewire the 110-volt power wire, free of charge. Owner notification letters were mailed July 25, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910030.
Grand Design RV, LLC (Grand Design) is recalling certain 2022 Grand Design Imagine, Reflection, Momentum, Solitude and Transcend travel trailers. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.
Consequence & remedy
Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Dealers will replace the quick disconnect fittings, free of charge. Owner notification letters were mailed May 30, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910029.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE24029 · Frame Flex On Grand Design Fifth Wheel Recreational Trailers
Opened Oct 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Structure
The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or entry door opening while in transit, some with objects lost on roadways, while six complaints also state that slideouts extended out partially. ODI has been in contact with both Grand Design and Lippert, the frame manufacturer. Grand Design believes that some frame flex, generally considered to be vertical movement in the upper deck area of the fifth wheel, is normal. However, Grand Design has developed a technical service bulletin (TSB), to evaluate concerns of excessive frame flex, defined as vertical movement greater than 3/8 inch. Per Grand Design, the frame flex is only occurring in the upper deck area of the fifth wheel and is resulting in cosmetic defects such as moving sidewalls, damage to cabinets, binding doors, etc. However, Lippert believes that the effects of frame flex may also extend back to the front axle of the trailer.While Lippert provides frames for multiple trailer manufacturers, the majority of complaints are for these Grand Design products. Cargo and entry doors that open and slideouts that extend while in transit increase the risk of injury or a crash. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to determine whether an unreasonable risk to motor vehicle safety exists. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2022 Grand Design Momentum Problems, Complaints & Recalls | Skip That Year
Illustration