Structure. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Suspension complaints

2 reports

Clear category filter

Mileage unknown · Dec 3, 2024

Latches/locks/linkagesSuspension

Read full complaint

The contact owns a 2019 Grand Design RV. The contact stated while driving at an undisclosed speed, the RV the front and rear doors inadvertently opened. The RV was taken to the dealer but was not diagnosed; however, the dealer informed the contact that the doors had been repaired. The contact stated while driving at an undisclosed speed, the rear tires blew out. There was no warning light illuminated. The contact pulled over the RV and noticed that the rear axle had fractured. The dealer was contacted. The RV was not diagnosed or repaired. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was not available. The VIN was not available.

NHTSA ODI #11628648

Mileage unknown · Mar 26, 2024

StructureSuspensionUnknown Or Other

my suspension failed with the leaf springs breaking and the shackles and bushings failed then the frame is breaking( flexing). all fasteners were loose and some missing the body came loose from the frame... this is a issue with many other grand design 5th wheels ... hopefully the parts that fell off on the freeway did not hurt …

Read full complaint

NHTSA ODI #11579614

Official recalls

22V038000 · Equipment:appliance:refrigerator

Jan 28, 2022

Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.

Consequence & remedy

Consequence: An electrical arc increases the risk of a fire.

Remedy: Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.

21V393000 · Equipment:recreational Vehicle/trailer:lpg Systems

May 26, 2021

Grand Design RV, LLC (Grand Design) is recalling certain 2016-2021 Imagine, Transcend, and Momentum travel trailers. The LP regulator that controls the LP gas pressure may fail, allowing excessive gas pressure that causes the appliance flame to increase.

Consequence & remedy

Consequence: Excessive gas pressure and a larger than intended appliance flame can increase the risk of a fire.

Remedy: Dealers will replace the LP regulator, free of charge. Owner notification letters were mailed June 24, 2021. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910023.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE24029 · Frame Flex On Grand Design Fifth Wheel Recreational Trailers

Opened Oct 9, 2024 · No close date supplied

Status: open (inferred from source dates) · Structure

The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or entry door opening while in transit, some with objects lost on roadways, while six complaints also state that slideouts extended out partially. ODI has been in contact with both Grand Design and Lippert, the frame manufacturer. Grand Design believes that some frame flex, generally considered to be vertical movement in the upper deck area of the fifth wheel, is normal. However, Grand Design has developed a technical service bulletin (TSB), to evaluate concerns of excessive frame flex, defined as vertical movement greater than 3/8 inch. Per Grand Design, the frame flex is only occurring in the upper deck area of the fifth wheel and is resulting in cosmetic defects such as moving sidewalls, damage to cabinets, binding doors, etc. However, Lippert believes that the effects of frame flex may also extend back to the front axle of the trailer.While Lippert provides frames for multiple trailer manufacturers, the majority of complaints are for these Grand Design products. Cargo and entry doors that open and slideouts that extend while in transit increase the risk of injury or a crash. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to determine whether an unreasonable risk to motor vehicle safety exists. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.