The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no …
Read full complaint
The contact owns a 2025 Ford F-600 SD. The contact stated that while driving at an undisclosed speed, the front of the vehicle raised up and the contact discovered that the vehicle, which had been converted into a motorhome, was improperly weighted, causing excessive weight on the rear axle. The contact stated that there was no clearance between the rear spring pack and the bump stop because the rear of the vehicle was significantly heavier than the front. The contact stated that the rear springs were resting on the frame of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that additional rear springs needed to be installed to increase the clearance between the springs and the bump stops. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 3,300.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.
Consequence & remedy
Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will install mechanical fasteners, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910059. This recall supersedes NHTSA recall 26V042.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.
Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will install mechanical fasteners, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910059. This recall supersedes NHTSA recall 26V042.
Structure:critical Fasteners
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.
Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will install mechanical fasteners, free of charge. Owner notification letters were mailed May 11, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910059. This recall supersedes NHTSA recall 26V042.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The driver and passenger seat bases may have not been tightened properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, “Seating Systems.”
Consequence & remedy
Consequence: A loose base may allow the seat to move during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and properly tighten the seat bases as necessary, free of charge. Owner notification letters were mailed May 15, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall M910060.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage motorhomes. The entry door position switch may not make adequate contact to read that the door is closed, which allows the steps to deploy unexpectedly.
Consequence & remedy
Consequence: Steps extending while in transit increase the risk of a crash.
Remedy: Dealers will reposition the switch, free of charge. Owner notification letters were mailed May 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910058.
Additional source detail variants (2)
Electrical System
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage motorhomes. The entry door position switch may not make adequate contact to read that the door is closed, which allows the steps to deploy unexpectedly.
Consequence: Steps extending while in transit increase the risk of a crash.
Remedy: Dealers will reposition the switch, free of charge. Owner notification letters were mailed May 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910058.
Structure:body:step/ladder
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage motorhomes. The entry door position switch may not make adequate contact to read that the door is closed, which allows the steps to deploy unexpectedly.
Consequence: Steps extending while in transit increase the risk of a crash.
Remedy: Dealers will reposition the switch, free of charge. Owner notification letters were mailed May 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910058.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage motorhomes. The seat base on the driver and front passenger seat may have been improperly tightened, causing the base to become loose. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, “Seating Systems.”
Consequence & remedy
Consequence: A loose seat base increases the risk of injury in the event of a crash.
Remedy: Dealers will inspect and tighten the seat base, as necessary, free of charge. Owner notification letters were mailed March 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910057.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.
Consequence & remedy
Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will properly secure the solar panels, free of charge. Owner notification letters were mailed March 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910053. This recall has been superseded by Recall 26V276.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.
Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will properly secure the solar panels, free of charge. Owner notification letters were mailed March 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910053. This recall has been superseded by Recall 26V276.
Structure:critical Fasteners
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational vehicles. The adhesive securing the solar panels to the roof may fail, allowing the solar panel to detach.
Consequence: A detached solar panel can become a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Dealers will properly secure the solar panels, free of charge. Owner notification letters were mailed March 4, 2026. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910053. This recall has been superseded by Recall 26V276.
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational trailers, equipped with Lippert Modularia entrance doors. The door latch mechanism may fail.
Consequence & remedy
Consequence: Door latch failure may prevent occupants from exiting the vehicle in an emergency, increasing the risk of injury.
Remedy: Dealers will install a new retainer clip and install a secondary retainer to the tension rod, free of charge. Owner notification letters were mailed September 12, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910051.
Additional source detail variants (2)
Equipment:recreational Vehicle/trailer
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational trailers, equipped with Lippert Modularia entrance doors. The door latch mechanism may fail.
Consequence: Door latch failure may prevent occupants from exiting the vehicle in an emergency, increasing the risk of injury.
Remedy: Dealers will install a new retainer clip and install a secondary retainer to the tension rod, free of charge. Owner notification letters were mailed September 12, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910051.
Latches/locks/linkages
Grand Design RV, LLC (Grand Design) is recalling certain 2025-2026 Lineage recreational trailers, equipped with Lippert Modularia entrance doors. The door latch mechanism may fail.
Consequence: Door latch failure may prevent occupants from exiting the vehicle in an emergency, increasing the risk of injury.
Remedy: Dealers will install a new retainer clip and install a secondary retainer to the tension rod, free of charge. Owner notification letters were mailed September 12, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is M910051.
Grand Design RV, LLC (Grand Design) is recalling certain 2025 Lineage 25FW motorhomes. The battery warming pad was installed incorrectly, which can damage internal wiring and cause an electrical short.
Consequence & remedy
Consequence: An electrical short increases the risk of a fire.
Remedy: Dealers will replace the battery warming pad, free of charge. Owner notification letters were mailed December 6, 2024. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910046.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2025 Grand Design Lineage Problems, Complaints & Recalls | Skip That Year
Illustration