2018 Grand Design Imagine

TL* THE CONTACT OWNS A 2018 GRAND DESIGN IMAGINE TRAILER. THE CONTACT STATED THAT DUE TO THE LEAF SPRING FLATTENING OUT, THE TIRES WERE RUBBING AGAINST THE BOTTOM OF THE TRAILER. THE CONTACT STATED THAT THE FAILURE SHOULD NOT OCCUR BECAUSE THE TRAILER WAS NOT OVERLOADED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS NO RECALL ASSOCIATED WITH THE FAILURE. NO FURTHER ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. *DT

TL* THE CONTACT OWNS A 2018 GRAND DESIGN IMAGINE 2600 RV. AFTER TRAVELING APPROXIMATELY 5,000 MILES, THE CONTACT DISCOVERED THAT BOTH OF THE VEHICLE'S AXLES HAD LOST THEIR CAMBERS. THERE WERE NO WARNING INDICATORS FOR THE AXLE MALFUNCTION. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND AGREED TO COVER THE COST TO REPLACE BOTH THE AXLE AND SPRING SETS. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC AND THE COST WAS COVERED BY THE MANUFACTURER. AFTER THE VEHICLE WAS REPAIRED, THE CONTACT TRAVELED ANOTHER 6,000 MILES AND NOTICED THAT THE REAR DRIVER'S SIDE TIRE BEGAN TO WEAR SIGNIFICANTLY AND THERE WAS ADVANCED TIRE WEAR ON THE OTHER THREE TIRES. THE CONTACT TOOK THE TRAILER TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT BOTH AXLES WERE BENT AND HAD FAILED AGAIN. ALSO, ALL FOUR WHEELS WERE OUT OF ALIGNMENT. THE CONTACT HAD THE WHEELS ALIGNED AND ALL FOUR TIRES REPLACED. THE CONTACT RESEARCHED THE COST AND DISCOVERED THAT GRAND DESIGN MANUFACTURED VEHICLES WITH WHAT HE BELIEVED WERE LOW COST, POORLY DESIGNED SPRINGS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AGAIN AND INFORMED THE CONTACT THAT THEY COULD REPAIR THE VEHICLE AGAIN. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE FAILURE MILEAGE WAS APPROXIMATELY 5,000.

TL* THE CONTACT OWNS A 2018 GRAND DESIGN IMAGINE TRAILER. WHILE THE CONTACT WAS PERFORMING A SAFETY INSPECTION OF THE TRAILER, SHE NOTICED THAT THE REAR TIRES WERE BALD. THE VEHICLE WAS TAKEN TO D AND G CUSTOM CONVERSIONS, INC. (383 BURGNERS ROAD, CARLISLE, PA 17015, 717-249-8875) WHERE IT WAS DIAGNOSED THAT THE AXLES WERE FAULTY. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE TRAILER REPAIR CENTER WOULD BE PROVIDED WITH THE REQUIRED APPROVAL FOR REPAIRS. WHEN THE REPAIR CENTER CALLED FOR APPROVAL, NO REMEDY WAS PROVIDED. THE VIN WAS UNKNOWN.

SPRINGS GOING FLAT OR FAILING. SEVERAL REPORTS ON GD FACEBOOK PAGE. I THINK IT NEEDS TO BE LOOKED INTO. CALLED GD FOR HELP BUT NO RESULTS. THEY CLAIM THEY HAD PROBLEMS WITH DEXTER AXLES BUT NOT LIPPERT AXLES. I CALLED LIPPERT AND THEY PRETTY MUCH SAID THERE HAS BEEN ISSUES BUT THEY SEND GD WHAT THEY ASK FOR. *DT CONSUMER STATED FLAT SPRINGS WERE REPLACED.*JB