NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
179 reports22,000 miles · Feb 17, 2026
Electrical SystemVisibility
The contact owns a 2022 GMC Yukon. The contact stated that while operating the vehicle, the computer system malfunctioned, causing the instrument cluster to turn off unintendedly. Additionally, the doors failed to immediately unlock, and the driver’s side mirror could not be adjusted. The vehicle was taken to the local dealer, w…
Read full complaint
The contact owns a 2022 GMC Yukon. The contact stated that while operating the vehicle, the computer system malfunctioned, causing the instrument cluster to turn off unintendedly. Additionally, the doors failed to immediately unlock, and the driver’s side mirror could not be adjusted. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The manufacturer was not contacted. The failure mileage was 22,000.
NHTSA ODI #11718407
Mileage unknown · Feb 12, 2026
Electrical SystemEnginePower Train
In 2023, the vehicle began exhibiting erratic transmission shifting behavior, including harsh and unpredictable shifts while driving. The vehicle was taken to a GMC dealer for diagnosis and repair. Recently, the vehicle developed additional drivetrain and engine control issues related to the crankshaft position sensor circuit. …
Read full complaint
In 2023, the vehicle began exhibiting erratic transmission shifting behavior, including harsh and unpredictable shifts while driving. The vehicle was taken to a GMC dealer for diagnosis and repair. Recently, the vehicle developed additional drivetrain and engine control issues related to the crankshaft position sensor circuit. The vehicle stalled while driving on a highway mountain overpass with multiple vehicles traveling behind me. When the stall occurred, the vehicle shifted into park and would not restart for several minutes. This created a hazardous situation due to loss of propulsion in active traffic at highway speed and limited shoulder space. Following diagnosis, the servicing dealer determined that the engine wiring harness requires full replacement due to internal wiring integrity issues affecting critical engine control signals. The crankshaft position sensor and related wiring are essential for engine timing and propulsion. Loss or corruption of this signal can result in reduced engine power, erratic transmission behavior, stalling, or no-start conditions. The earlier erratic shifting behavior appears consistent with conditions described in GM Technical Service Bulletin 21-NA-149, which identifies engine harness-related causes for drivetrain and shifting concerns. This issue appears to involve degradation or defect within the engine wiring harness affecting engine management and transmission operation. Given that this condition resulted in a highway stall and temporary inability to restart, I am reporting this for investigation as a potential safety-related defect involving loss of propulsion.
NHTSA ODI #11717445
Mileage unknown · Feb 10, 2026
Engine
Driving normally. Stopped at a red light when the car started to touch idle and proceeded to shut off. Tried to restart the car and when ignition button was pressed the screen and all electronics shut off and there was smoke coming from the engine bay. Police were called and the car was towed to the nearest gmc dealer. Was calle…
Read full complaint
Driving normally. Stopped at a red light when the car started to touch idle and proceeded to shut off. Tried to restart the car and when ignition button was pressed the screen and all electronics shut off and there was smoke coming from the engine bay. Police were called and the car was towed to the nearest gmc dealer. Was called today 2/10/2026 with the update that it was going to require a new motor.
NHTSA ODI #11717135
Mileage unknown · Feb 10, 2026
Unknown Or Other
On Star module quit working in our Yukon, which in turn makes it useless to have any of the safety features. On Star and GM know this is an ongoing problem, but no recall has been issued. Neither company will repair unless an $1100 fee is paid. Why install On Star if you know it will malfunction. Since there is a monthly ser…
Read full complaint
On Star module quit working in our Yukon, which in turn makes it useless to have any of the safety features. On Star and GM know this is an ongoing problem, but no recall has been issued. Neither company will repair unless an $1100 fee is paid. Why install On Star if you know it will malfunction. Since there is a monthly service fee I think they need to make sure the vehicle has the correct parts.
NHTSA ODI #11717049
46,000 miles · Feb 10, 2026
EngineEngine And Engine Cooling
The contact owns a 2022 GMC Yukon. The contact stated that the vehicle was consuming an excessive amount of oil. The vehicle was taken to the dealer, where it was diagnosed, and metal shavings were found in the engine oil. The dealer replaced the camshaft and lifters; however, the failure worsened. The contact stated while drivi…
Read full complaint
The contact owns a 2022 GMC Yukon. The contact stated that the vehicle was consuming an excessive amount of oil. The vehicle was taken to the dealer, where it was diagnosed, and metal shavings were found in the engine oil. The dealer replaced the camshaft and lifters; however, the failure worsened. The contact stated while driving approximately 65-70 MPH, the vehicle stalled and lost power steering functionality. The contact's husband was able to pull over to the side of the road. There was no warning light illuminated. The vehicle failed to restart and was towed to the residence. The vehicle was then picked up and diagnosed by the dealer. The dealer determined that the engine had seized and needed to be replaced. The contact had opened a case with the manufacturer for buyback assistance due to safety concerns. The vehicle was not repaired. The failure mileage was approximately 46,000.
NHTSA ODI #11716959
Mileage unknown · Feb 9, 2026
Back Over PreventionForward Collision AvoidanceLane Departure
Unknown
NHTSA ODI #11716858
Mileage unknown · Feb 4, 2026
Visibility/wiper
Windshield wipers stopped working while driving. Once engine turned off, the wires began working again. Additionally, later in the day while driving home the wipers stopped working again. The wipers have not worked since.
NHTSA ODI #11715688
Mileage unknown · Feb 4, 2026
Engine
The engine threw a rod on January 23, 2026. The vehicle stranded me on the side of the road. We called the dealership which they came and towed back to the dealership. No dashboard warnings at all. Oil pressure was good. I heard a low tick to begin with then a slight squeaking noise. After the engine locked it was an abrup…
Read full complaint
The engine threw a rod on January 23, 2026. The vehicle stranded me on the side of the road. We called the dealership which they came and towed back to the dealership. No dashboard warnings at all. Oil pressure was good. I heard a low tick to begin with then a slight squeaking noise. After the engine locked it was an abrupt halt with the wheels locking up but didn't come to a complete stop. The noise was very loud after that and that's when I pulled off the highway. The dealership checked it out and did find that the motor needed to be replaced. We just had the SUV in the dealership on October 2025 and they found no need for a new motor, just a change in the oil viscosity.
NHTSA ODI #11715538
87,000 miles · Feb 3, 2026
EngineEngine And Engine Cooling
The contact owns a 2022 GMC Yukon. The contact stated that while the vehicle was parked, there was a dripping sound coming from the vehicle, and the low oil warning light was illuminated. The low oil warning light was illuminated approximately every 1,500 miles after an oil change. After each oil change, the level on the oil dip…
Read full complaint
The contact owns a 2022 GMC Yukon. The contact stated that while the vehicle was parked, there was a dripping sound coming from the vehicle, and the low oil warning light was illuminated. The low oil warning light was illuminated approximately every 1,500 miles after an oil change. After each oil change, the level on the oil dipstick was low. The vehicle was taken to an independent mechanic, where an oil consumption test was performed. The mechanic informed the contact that the vehicle was consuming approximately 25 percent of the engine oil. The vehicle was not repaired, and the contact was referred to a dealer for assistance. The vehicle was not diagnosed or repaired. The contact was informed that an additional oil consumption test was needed. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 87,000.
NHTSA ODI #11715224
Mileage unknown · Feb 2, 2026
Electrical System
I am writing to report a failure of the telematics module in our vehicle. The module stopped functioning without any warning or notification on the dashboard. Our vehicle has only 64,000 miles and has never been involved in an accident, so this failure is unexpected. This issue has resulted in the complete loss of OnStar connect…
Read full complaint
I am writing to report a failure of the telematics module in our vehicle. The module stopped functioning without any warning or notification on the dashboard. Our vehicle has only 64,000 miles and has never been involved in an accident, so this failure is unexpected. This issue has resulted in the complete loss of OnStar connectivity, meaning that automatic crash notification would not occur in the event of an accident. Additionally, we are no longer able to remotely unlock or access the vehicle through the app, as all communication capabilities are currently disabled.
NHTSA ODI #11714994
Official recalls
5Feb 13, 2026
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence & remedy
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module:software
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Power Train:automatic Transmission:fluid/lubricant:valves/valve Body
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.
Consequence: Rear wheels that lock up while driving increase the risk of a crash.
Remedy: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.
Sep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Remedy: Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Apr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Aug 11, 2022
General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.
Consequence & remedy
Consequence: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.
Remedy: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration