NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
4 reportsClear category filterMileage unknown · Oct 18, 2001
Fuel System, Gasoline
JUST HAD DIESEL FUEL INJECTION PUMP NUMBER 4 INSTALLED ON MY TRUCK. LAST ONE RAN JUST OVER 25,000 MILES. THIS PUMP FAILS WITHOUT WARNING AND UNDER THE RIGHT CIRCUMSTANCES IT CAN LEAD TO A SERIOUS ACCIDENT. GM ISSUED AN EXTENDED WARRENTY FOR THESE PUMPS. IVE EXPERIENCED FAILURE WITH THEIR LATEST PUMP AND IT WAS REPLACED UNDE…
Read full complaint
JUST HAD DIESEL FUEL INJECTION PUMP NUMBER 4 INSTALLED ON MY TRUCK. LAST ONE RAN JUST OVER 25,000 MILES. THIS PUMP FAILS WITHOUT WARNING AND UNDER THE RIGHT CIRCUMSTANCES IT CAN LEAD TO A SERIOUS ACCIDENT. GM ISSUED AN EXTENDED WARRENTY FOR THESE PUMPS. IVE EXPERIENCED FAILURE WITH THEIR LATEST PUMP AND IT WAS REPLACED UNDER WARRANTY.. THE ENGINE WILL FAIL WITHOUT ANY WARNING WHATSOEVER AND ANY SPEED, INCLUDING HIGHWAY SPEEDS IN HEAVY TRAFFIC. IF THIS DOESNT WARRANT A SAFETY INVESTIGATION I DONT KNOW WHAT DOES.JUST HAD DIESEL FUEL INJECTION PUMP NUMBER 4 INSTALLED ON MY TRUCK. LAST ONE RAN JUST OVER 25,000 MILES. THIS PUMP FAILS WITHOUT WARNING AND UNDER THE RIGHT CIRCUMSTANCES IT CAN LEAD TO A SERIOUS ACCIDENT. GM ISSUED AN EXTENDED WARRENTY FOR THESE PUMPS. IVE EXPERIENCED FAILURE WITH THEIR LATEST PUMP AND IT WAS REPLACED UNDER WARRANTY.. THE ENGINE WILL FAIL WITHOUT ANY WARNING WHATSOEVER AND ANY SPEED, INCLUDING HIGHWAY SPEEDS IN HEAVY TRAFFIC. IF THIS DOESNT WARRANT A SAFETY INVESTIGATION I DONT KNOW WHAT DOES.*AK
NHTSA ODI #753381
Mileage unknown · Nov 1, 2000
Fuel System, Gasoline
ENGINE EXHIBITED SYMPTOMS OF STARTING HARD WHEN HOT OR STALLING WITH NO WARNING. THE SES LIGHT WOULD COME ON AND THE CODES 17, 18, 35 & 36 WERE STORED. DEALER WAS CONTACTED REGARDING THIS AND TRUCK WAS AT DEALER FOR 3 APPOINTMENTS BUT DID NOT RESOLVE PROBLEM. THESE CODES ALMOST ALWAYS INDICATE A FAILING FUEL INJECTION PUMP AN…
Read full complaint
ENGINE EXHIBITED SYMPTOMS OF STARTING HARD WHEN HOT OR STALLING WITH NO WARNING. THE SES LIGHT WOULD COME ON AND THE CODES 17, 18, 35 & 36 WERE STORED. DEALER WAS CONTACTED REGARDING THIS AND TRUCK WAS AT DEALER FOR 3 APPOINTMENTS BUT DID NOT RESOLVE PROBLEM. THESE CODES ALMOST ALWAYS INDICATE A FAILING FUEL INJECTION PUMP AND CALLS TO CUSTOMER RELATIONS LINE ASKING WHY NOTHING WAS BEING DONE TO CHANGE THE FUEL INJECTION PUMP DIDN'T GET ANYWHERE. A CASE NUMBER WAS ASSIGNED. ALL VISITS TO THE DEALER WERE DURING THE WARRANTY PERIOD. A TRIP FOLLOWING THE LAST VISIT TO THE DEALERSHIP NEARLY RESULTED IN A REAR END COLLISION ON AND INTERSTATE AS THE TRUCK STALLED IN HEAVY TRAFFIC. I PURCHASED A NEW GM FUEL INJECTION PUMP AND INSTALLED IT MYSELF AND RESOLVED THE PROBLEM COMPLETELY. GM HAS SINCE REINSTATED THE WARRANTY FOR THIS PROBLEM ON SEVERAL TRUCKS INCLUDING MINE. I AM SUBMITTING A REQUEST FOR A REFUND FOR MY LOSSES.*AK
NHTSA ODI #735602
Mileage unknown · Jan 21, 2000
Engine And Engine CoolingFuel System, GasolinePower Train
RE SEALS, DEALER SAID IT HAD MORE TO DO WITH WHERE I LIVED (EXTREMES IN TEMPERATURE) - RE REAR END, DEALER COULD WORK W/ US IF AUTO HAD LESS THAN 60,000. NO SAFETY DEFECT LISTED WITHIN SUMMARY. *AK
NHTSA ODI #717663
Mileage unknown · Oct 4, 1999
Fuel System, Gasoline
FUEL SENDER FAILED, CAUSING FUEL GUAGE TO BE INACCURATE. QUOTED REPAIR COST IS $341 FOR PART AND $200 FOR LABOR. I FIND THE PRICE FOR THE SIMPLE REPAIR PART TO BE VERY EXCESSIVE. HAS ANY ONE ELSE REPORTED SIMILIAR ESCESSIVE PARTS COST?
NHTSA ODI #712778
Official recalls
6Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
Apr 4, 1996
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Jul 26, 1995
THE TRANSMISSION SHIFT-CABLE LOCK CLIP CAN BACK OUT OF ITS INSTALLED POSITION RESULTING IN A LOSS OF CABLE ADJUSTMENT. WHEN THE SHIFT LEVER IS PLACED IN THE "PARK" POSITION, THE "PARK" INDICATOR LIGHT MAY NOT ILLUMINATE.
Consequence & remedy
Consequence: THE VEHICLE CAN MOVE UNINTENTIONALLY IF THE DRIVER DOES NOT NOTICE THAT THE INDICATOR LIGHT IS NOT ON AND DOES NOT APPLY THE PARKING BRAKE.
Remedy: DEALERS WILL ADJUST THE SHIFT CABLE AND INSTALL A LOCK CLIP.
Jul 25, 1995
THE VEHICLES HAVE BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) LABEL AND AN ENGINE START LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABEL.
Remedy: THE ENGINE START LABEL WILL BE REMOVED FROM THE STOWED SIDE OF THE SUN VISOR AND A NEW ENGINE START LABEL WILL BE INSTALLED ON THE HEADLINER IN THE SUN VISOR DEPRESSION. OWNERS WILL RECEIVE THE NEW LABEL AND CAN INSTALL THE LABEL THEMSELVES OR HAVE A DEALER INSTALL IT.
Apr 24, 1995
VEHICLES FAIL TO CONFORM TO FMVSS NO. 210, "SEAT BELT ANCHORAGES." THE CENTER REAR SEAT LAP BELT WAS IMPROPERLY ROUTED.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE OCCUPANT OF THIS SEAT WILL NOT BE PROPERLY RESTRAINED IN THE EVENT OF A VEHICLE CRASH.
Remedy: INSTRUCTIONS FOR REROUTING THE CENTER REAR SEAT LAP BELT WILL BE SENT TO THE VEHICLE OWNERS. IF THE OWNER PREFERS, THEY CAN TAKE THEIR VEHICLE TO THEIR DEALER AND HAVE IT REROUTED FREE OF CHARGE BY THE DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA01018 · Seat Belt Anchorage Separation
Opened Dec 20, 2001 · Closed Dec 9, 2002
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
No summary supplied.
PE01023 · Seat Belt Anchorage Separation
Opened Jul 17, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED INJURY.GM HAS SUBSEQUENTLY CHANGED SEAT BELT ANCHORING DESIGN IN MY 2000. ODI HAS COMPLETED A PRELIMINARY INVESTIGATION AND HAS DETERMINED THAT FURTHER INFORMATION IS NEEDED TO DETERMINE WHETHER A SAFETY DEFECT EXISTS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
PE99073 · Battery Leaks Acid
Opened Dec 3, 1999 · Closed May 2, 2000
Status: closed (inferred from source dates) · Electrical System
ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT A LOSS OF BRAKE FLUID FROM DETERIORATION OF THE RIGHT FRONTBRAKE LINE AS A RESULT OF SULFURIC ACID CONTAMINATION.THE REMAINING 11 COMPLAINTS PERTAIN PRIMARILY TO SULFURIC ACID LEAKAGE FROM THE BATTERY CASE.AT LEAST ONE COMPLAINANT STATED THAT THE REPLACEMENT BATTERY ALSO FAILED.SEVERAL OF THE COMPLAINANTS NOTE THAT THE LEAKING ACID HAD COME IN CONTACT WITH A WIRE HARNESS AT THE FRAME IN THE VICINITY OF THE STEEL BRAKE LINE.A FIELD INSPECTION BY ODI INDICATES THAT THE DESCRIBED HARNESS IS THE ABS CONNECTION TO THE RIGHT FRONT WHEEL SPEED SENSOR.PRIOR TO THE BATTERY CASE FAILURE, THERE IS USUALLY NO WARNING (SHORT OF AN UNDERHOOD INSPECTION), AND THE ENSURING DAMAGE (SULFURIC ACID CONTAMINATION) IS PROGRESSIVE.OF THE KNOWN BATTERY FAILURES, THERE MAY BE A TEMPERATURE CORRELATION, AS 60% OF THE OWNER COMPLAINTS CAME FROM FOUR STATES; CALIFORNIA, FLORIDA, GEORGIA AND TEXAS.THERE IS ALSO A PRODUCT IMPROVEMENT PROGRAM AND ENGINEERING CHANGE NOTICE TO ADD 1% SILVER TO THE BATTERY'S POSITIVE SIDE TERMINALL, WITH THE EARLIEST IMPLEMENTATION DATE FOR THIS BEING FEB 2, 1998.THE EFFECT OF THIS DESIGN CHANGE IS AS YET UNKNOWN; FURTHER REVIEW IS WARRANTED.AN EA IS BEING OPENED TO GATHER FURTHER APPROPRIATE INFORMATION, CLARIFY ANY DEFECT TRENDS, AND TO ASSESS THE SAFETY IMPLICATIONS AND RISKS CONCERNING THESE FAILURES.
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
Illustration