IllustrationTHE BRAKES FAILED AS I WAS APPROACHING A STOP SIGN. THE BRAKE LINES WERE BADLY RUSTED, MUCH WORSE THAN WOULD BE EXPECTED. THIS COULD HAVE BEEN VERY SERIOUS HAD IT HAPPENED AT A GREATER SPEED! *TR
2002 GMC Suburban
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Suburban years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 7 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
7 reportsDT*: THE CONTACT STATED THE VEHICLE HAD A POWER FAILURE WHILE DRIVING 5 MPH. THE IGNITION WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE SERVICE DEALER WHO DETERMINED THERE WAS AN IGNITION PROBLEM. ON THE SECOND VISIT, THE INDEPENDENT REPAIR SHOP DIAGNOSED THE VEHICLE WITH A FUEL PUMP PROBLEM. THE MANUFACTURER WAS NOTIFIED…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE HAD A POWER FAILURE WHILE DRIVING 5 MPH. THE IGNITION WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE SERVICE DEALER WHO DETERMINED THERE WAS AN IGNITION PROBLEM. ON THE SECOND VISIT, THE INDEPENDENT REPAIR SHOP DIAGNOSED THE VEHICLE WITH A FUEL PUMP PROBLEM. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE SERVICE DEALER.
DT: THE CONTACT STATED THE VEHICLE STALLED WHILE DRIVING. HE WAS ABLE TO RESTART THE VEHICLE AND DROVE IT TO THE DEALERSHIP. THE FUEL GAUGE WORKED IMPROPERLY. THE DEALERSHIP SAID THE STALLING PROBLEM WAS CAUSED BY A FUEL PUMP FAILURE. THE FUEL PUMP HAS BEEN REPLACED. *AK UPDATED 05/23/06. *JB
DT: CONTACT OWNS A 2002 GMC SUBURBAN. WHILE DRIVING AND CHANGING GEARS, AND WHEN PUTTING IT IN REVERSE IT SOUNDS LIKE THE ENGINE IS FALLING OUT. WHILE CHANGING GEARS ITS LIKE A BIG THUD. WHEN CHANGING FROM PARK TO REVERSE IT SOUNDS LIKE IT IS COMING APART. WHEN TURNING THE CAR INTO NEUTRAL RED LIGHT STAYS ON, AND THAT HA…
Read full complaint
DT: CONTACT OWNS A 2002 GMC SUBURBAN. WHILE DRIVING AND CHANGING GEARS, AND WHEN PUTTING IT IN REVERSE IT SOUNDS LIKE THE ENGINE IS FALLING OUT. WHILE CHANGING GEARS ITS LIKE A BIG THUD. WHEN CHANGING FROM PARK TO REVERSE IT SOUNDS LIKE IT IS COMING APART. WHEN TURNING THE CAR INTO NEUTRAL RED LIGHT STAYS ON, AND THAT HAS NEVER HAPPENED BEFORE. THE CONTACT WILL TAKE THE VEHICLE TO THE DEALERSHIP TO BE CHECKED. ALSO, THE CONTACT SMELLED A BURNING ODOR. *AK
THE AIRBAG FAILED TO DEPLOY WHEN THE CONSUMERS WIFE HIT A BUS AT 40 MPH. THIS RESULTED IN A CONCUSSION. *AK *SC *JB
WHILE TRAVELING AT ANY SPEED FRONT END VIBRATED. CONSUMER INSPECTED VEHICLE, AND DETERMINED FRONT TIRES WERE UNEVENLY WORN. *AK
WITH LESS THAN 24,000 MILES ON 2002 CHEVROLET SUBURBAN, THERE IS EXTREMELY ABNORMAL WEAR ON TREADS OF FRONT TIRES IN PARTICULAR. LARGE, DEEP AND UNEVEN INDENTATIONS ON THE TREAD, ESPECIALLY FRONT INSIDE OF TIRES. *AK
Official recalls
103V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP05009 · Parking Brake Failure
Opened Dec 20, 2005 · Closed May 31, 2006
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.