NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
21 reportsClear category filter130,000 miles · May 23, 2014
Electrical SystemEngineSteering
THE IGNITION SWITCH STARTED TO FAIL WHILE DRIVING. FIRST THE HEATER FAN WOULD QUIT AND THE ABS LIGHT WOULD INSTANTLY TURN ON, AND THE CRUISE CONTROL WOULD FAIL TO OPERATE. WHEN THE ABS LIGHT WOULD BE ON THE ABS WOULD FAIL TO OPERATE. THEN SUDDENLY ALL OPERATIONS WOULD GO BACK TO NORMAL. IT WOULD BE UNPREDICTABLE WHEN THE HEATER …
Read full complaint
THE IGNITION SWITCH STARTED TO FAIL WHILE DRIVING. FIRST THE HEATER FAN WOULD QUIT AND THE ABS LIGHT WOULD INSTANTLY TURN ON, AND THE CRUISE CONTROL WOULD FAIL TO OPERATE. WHEN THE ABS LIGHT WOULD BE ON THE ABS WOULD FAIL TO OPERATE. THEN SUDDENLY ALL OPERATIONS WOULD GO BACK TO NORMAL. IT WOULD BE UNPREDICTABLE WHEN THE HEATER FAN AND THE ABS WOULD FAIL AND COME BACK. THEN YESTERDAY, THE SUBURBAN STARTED AND DIED 3 SECONDS AFTER STARTING. I RESTARTED THE SUBURBAN AND ALL SEEMED GOOD. I PUT THE SUBURBAN IN DRIVE AND ROLLED AT ABOUT 5 MPH AND THE TRUCK DIED. I STOPPED AND PUT THE SUBURBAN IN TO PARK AND RESTARTED. PLACED IT INTO DRIVE AND MADE IT HOME. WHEN I GOT HOME, I TURNED OFF THE SUBURBAN AND TRIED TO RESTART IT. IT WOULD CRANK BUT NOT FIRE THE ENGINE. THE RADIO AND HEATER AND ALL OTHER ELECTRONICS WOULD OPERATE AS NORMAL, BUT THE DASH LIGHTS WOULD NOT TURN ON I.E. THE "SERVICE ENGINE SOON", "BRAKE", "AIR BAG", "ABS". THE IGNITION SWITCH HAS FAILED ON IT AND NOW SITS IN MY DRIVEWAY. *TR
NHTSA ODI #10593726
95,600 miles · Mar 31, 2005
Electrical SystemFuel System, Gasoline
FUEL GAGE WAS ACTING ERRATIC WENT FULL THEN EMPTY WITH FULL TANK . A FEW DAYS LATER THE TRUCK WOULD NOT START. FOUND FUSE IN ENGINE COMPARTMENT BLOWN FOR FUEL PUMP. FUEL PUMP WIRING WAS MELTED IN FUEL TANK CAUSING SHORT. HAD TO REPLACE PUMP AND HARNESS WHICH WAS PART OF THE PUMP HOUSING. ALSO REPLACED FUEL FILTER DUE TO LACK OF …
Read full complaint
FUEL GAGE WAS ACTING ERRATIC WENT FULL THEN EMPTY WITH FULL TANK . A FEW DAYS LATER THE TRUCK WOULD NOT START. FOUND FUSE IN ENGINE COMPARTMENT BLOWN FOR FUEL PUMP. FUEL PUMP WIRING WAS MELTED IN FUEL TANK CAUSING SHORT. HAD TO REPLACE PUMP AND HARNESS WHICH WAS PART OF THE PUMP HOUSING. ALSO REPLACED FUEL FILTER DUE TO LACK OF FUEL FLOW (NO POWER) A WEEK LATER.
NHTSA ODI #10116159
60,000 miles · Jan 21, 2004
Electrical SystemEngine And Engine CoolingPower Train
1997 GMC SUBURBAN- MULTIPLE ENGINE & TRANSMISSION FAILURES. AT 60,000 MILES, VEHICLE BEGAN TO SHIFT HARD. RETURNED TO SHOP FOR DIAGNOSIS AND REPAIRS SEVERAL TIMES FOR WORK. FINALLY, WHILE DRIVING THE VEHICLE IN CITY TRAFFIC, THE TRANSMISSION FAILED COMPELETLY. REQUIRED VALVE COVER AND TRANSMISSION REBUILD @ COST OF $2,000. …
Read full complaint
1997 GMC SUBURBAN- MULTIPLE ENGINE & TRANSMISSION FAILURES. AT 60,000 MILES, VEHICLE BEGAN TO SHIFT HARD. RETURNED TO SHOP FOR DIAGNOSIS AND REPAIRS SEVERAL TIMES FOR WORK. FINALLY, WHILE DRIVING THE VEHICLE IN CITY TRAFFIC, THE TRANSMISSION FAILED COMPELETLY. REQUIRED VALVE COVER AND TRANSMISSION REBUILD @ COST OF $2,000. ON DECEMBER 27 '03, HAD TO REPLACE THE RADIATOR. ON JAN 17 '04, DISCOVERED THAT THERE WAS NO ANTIFREEZE IN NEW RADIATOR. RETURNED TO MECHANIC WHO REPLACED THE RADIATOR. SAID THE INTAKE MANIFOLD NEEDED TO BE REPLACED. COST: ~$600. TOOK TO ANOTHER MECHANIC FOR SECOND OPINION. SAME DIAGNOSIS. BOTH STATE THAT GM IS AWARE OF BOTH PROBLEMS, HOWEVER, THEY WILL NOT COVER THE COSTS OF REPAIRS OR REPLACEMENT. ADDITIONALLY- REPLACED ALTERNATOR TWO TIMES; REPLACED WATER PUMP TWO TIMES; REPLACED THE MASTER CYLINDER IN FALL 2003. *AK
NHTSA ODI #10054576
46,801 miles · Nov 18, 2003
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
WHILE DRIVING THE SERPENTINE BELT TENSIONER BROKE FROM ITS MOUNTING AND RESULTED IN LOSS OF POWER STEERING AND OTHER COMPONENTS INCLUDING CHARGING OF THE BATTERY. THE ALTERNATOR ALSO SHORTED OUT. THE MANUFACTURER AND THE DEALER WERE NOTIFIED. *AK THE CONSUMER WAS TOLD THAT THE WARRANTY NOT LONGER COVERED THE BELT. T…
Read full complaint
WHILE DRIVING THE SERPENTINE BELT TENSIONER BROKE FROM ITS MOUNTING AND RESULTED IN LOSS OF POWER STEERING AND OTHER COMPONENTS INCLUDING CHARGING OF THE BATTERY. THE ALTERNATOR ALSO SHORTED OUT. THE MANUFACTURER AND THE DEALER WERE NOTIFIED. *AK THE CONSUMER WAS TOLD THAT THE WARRANTY NOT LONGER COVERED THE BELT. THE BRAKES SHUTTERED WHILE BRAKING FROM 60 MPH. THE DEALER REPLACED THE FRONT BRAKE PADS AND RESURFACED THE ROTORS. *NLM
NHTSA ODI #10042591
Mileage unknown · Oct 1, 2003
Electrical SystemFire
THE VEHICLE CAUGHT ON FIRE. THE FIRE CHIEF STATED IT WAS POSSIBLE THERE WAS A SHORT IN THE STEERING COLUMN. *AK *JB
NHTSA ODI #10033604
Mileage unknown · Jan 17, 2002
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ONGOING PROBLEMS WITH THE FUEL INJECTION SYSTEM CAUSING THE ENGINE TO HESITATE AND EXHIBIT POOR ACCELERATION, DEALER REPLACED FUEL FILTER, FUEL PUMP DRIVER MODULE, FUEL INJECTION PUMP, AND ADDED FUEL CONDITIONER. *TT
NHTSA ODI #563531
Mileage unknown · Jan 13, 2001
Electrical System
BATTERY LEAKED SIGNIFICANT AMOUNT OF ACID, TERMINAL CAME LOOSE, UNABLE TO START, CORROSION TO CABLES AND COMPONENTS IN AREA OF THE BATTERY. *AK
NHTSA ODI #739300
Mileage unknown · Jun 26, 2000
Electrical SystemEquipment
ACID WAS LEAKING FROM BATTERY TERMINAL. THUS FAR, DEALER HAD TO REPLACE A/C LINES AND BATTERY CABLE. CONSUMER WAS EXPERIENCING THE SAME PROBLEM AS MENTIONED IN PE99-073.*AK
NHTSA ODI #864233
Mileage unknown · Jun 21, 2000
Electrical System
BATTERY CABLE FAILED, CAUSING SUBURBAN TO STOP IN TRAFFIC. CONTROL OF VEHICLE BECAME DIFFICULT DUE TO LACK OF POWER. *AK
NHTSA ODI #724300
Mileage unknown · Jun 9, 2000
Electrical System
CONSUMER OPENED HOOD AND NOTICED BATTERY ACID WAS LEAKING ON A/C CABLE. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #863307
NHTSA investigations
5EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
DP00001 · Oem Hitch Receiver Platform Cracking
Opened Jan 31, 2000 · No close date supplied
Status: open (inferred from source dates) · Equipment
THE PETITION ALLEGES THAT CRACKS IN THE HITCH RECEIVER PLATFORM MAY LEAD TO SEPARATION OF THE TRAILER AND LOSS OF STEERING CONTROL
PE99073 · Battery Leaks Acid
Opened Dec 3, 1999 · Closed May 2, 2000
Status: closed (inferred from source dates) · Electrical System
ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT A LOSS OF BRAKE FLUID FROM DETERIORATION OF THE RIGHT FRONTBRAKE LINE AS A RESULT OF SULFURIC ACID CONTAMINATION.THE REMAINING 11 COMPLAINTS PERTAIN PRIMARILY TO SULFURIC ACID LEAKAGE FROM THE BATTERY CASE.AT LEAST ONE COMPLAINANT STATED THAT THE REPLACEMENT BATTERY ALSO FAILED.SEVERAL OF THE COMPLAINANTS NOTE THAT THE LEAKING ACID HAD COME IN CONTACT WITH A WIRE HARNESS AT THE FRAME IN THE VICINITY OF THE STEEL BRAKE LINE.A FIELD INSPECTION BY ODI INDICATES THAT THE DESCRIBED HARNESS IS THE ABS CONNECTION TO THE RIGHT FRONT WHEEL SPEED SENSOR.PRIOR TO THE BATTERY CASE FAILURE, THERE IS USUALLY NO WARNING (SHORT OF AN UNDERHOOD INSPECTION), AND THE ENSURING DAMAGE (SULFURIC ACID CONTAMINATION) IS PROGRESSIVE.OF THE KNOWN BATTERY FAILURES, THERE MAY BE A TEMPERATURE CORRELATION, AS 60% OF THE OWNER COMPLAINTS CAME FROM FOUR STATES; CALIFORNIA, FLORIDA, GEORGIA AND TEXAS.THERE IS ALSO A PRODUCT IMPROVEMENT PROGRAM AND ENGINEERING CHANGE NOTICE TO ADD 1% SILVER TO THE BATTERY'S POSITIVE SIDE TERMINALL, WITH THE EARLIEST IMPLEMENTATION DATE FOR THIS BEING FEB 2, 1998.THE EFFECT OF THIS DESIGN CHANGE IS AS YET UNKNOWN; FURTHER REVIEW IS WARRANTED.AN EA IS BEING OPENED TO GATHER FURTHER APPROPRIATE INFORMATION, CLARIFY ANY DEFECT TRENDS, AND TO ASSESS THE SAFETY IMPLICATIONS AND RISKS CONCERNING THESE FAILURES.
PE98060 · Erratic Steering Boost While Driving
Opened Nov 13, 1998 · Closed May 12, 1999
Status: closed (inferred from source dates) · Steering
ALLEGED THAT THE VARIABLE EFFORT STEERING UNIT INTERMITTENTLY PROVIDES FULL BOOST TOT HE POWER STEERING GEAR AT MODERATE TO HIGH SPEEDS.
EA95026 · Poor Brake Performance
Opened Sep 20, 1995 · Closed Sep 20, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
POOR PERFORMANCE OF ABS BRAKES
Illustration