DESCRIBE BELOW IS EXACTLY WHAT HAS OCCURRED WITH MY VEHICLE. HOWEVER GM REPLACEMENT PART IS DEFECTIVE AND ISSUE IS UNDER RECALL IN CANADA???? NOT U.S.??? PART IS BEING REDESIGNED MAY BE A COUPLE OF MONTHS?? BEING TOLD WILL HAVE TO WAIT IN MEAN TIME I HAVE MANUALLY BRING HEAT UP FROM LOW AND MAY HAVE HEAT MAY HAVE TO SHUT DOWN VE…
Read full complaint
DESCRIBE BELOW IS EXACTLY WHAT HAS OCCURRED WITH MY VEHICLE. HOWEVER GM REPLACEMENT PART IS DEFECTIVE AND ISSUE IS UNDER RECALL IN CANADA???? NOT U.S.??? PART IS BEING REDESIGNED MAY BE A COUPLE OF MONTHS?? BEING TOLD WILL HAVE TO WAIT IN MEAN TIME I HAVE MANUALLY BRING HEAT UP FROM LOW AND MAY HAVE HEAT MAY HAVE TO SHUT DOWN VEHICLE AND START AT LOW. NOT VERY REASSURING WHEN TEMPS ARE -40F BELOW ZERO. UNTIL PART IS RE-DESIGNED OR ENGINEERED??? I AM SUPPOSE TO DRIVE THIS VEHICLE WHICH IS LISTED UNDER A SAFETY RECALL AND ENCOUNTER CONTINUED FAILURE AND POSSIBLE ENGINE FIRE???? NOT ACCEPTABLE! HTTP://WWWAPPS.TC.GC.CA/SAF-SEC-SUR/7/VRDB-BDRV/SEARCH/RECALLDETAIL.ASPX?RN=2011074&LANG=ENG RECALL DATE 2011/02/21 NOTIFICATION TYPE SAFETY TC MANUFACTURER RECALL NUMBER 11046 UNITS AFFECTED 190,310 CATEGORY LIGHT TRUCK & VAN, SUV RECALL DETAILS ON CERTAIN VEHICLES, THE INTERFACE BETWEEN THE ELECTRICAL TERMINALS OF THE HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) BLOWER RELAY RESISTOR MODULE AND THE WIRING CONNECTOR (WHICH POWERS THE MODULE) MAY BE INCAPABLE OF CONDUCTING HIGHER CURRENT LEVELS FOR SUSTAINED PERIODS OF OPERATION. IN ADDITION, MOISTURE AND OTHER CONTAMINANTS (SUCH AS ROAD DE-ICING MATERIALS) MAY ENTER THE FRESH AIR INTAKE PLENUM AND CONTACT THE INTERNAL CIRCUIT OF THE MODULE OR CORRODE THE TERMINALS. THESE CONDITIONS MAY CAUSE THE RELAY RESISTOR MODULE OR WIRING CONNECTOR TO OVERHEAT, CAUSING VARIOUS SYMPTOMS SUCH AS: THE HVAC BLOWER MAY NOT FUNCTION ON CERTAIN OR ALL BLOWER SPEED SETTINGS; A BURNING-PLASTIC SMELL OR SMOKE MAY BE PRESENT IN THE VEHICLE, OR; THE HVAC BLOWER MAY RUN CONTINUALLY WITH THE IGNITION IN THE OFF POSITION. THESE WARNING SIGNS COULD, IN CERTAIN INSTANCES, BE LEADING INDICATORS OF AN IMPENDING VEHICLE FIRE, WHICH COULD RESULT IN PROPERTY DAMAGE AND/OR PERSONAL INJURY. GMC SIERRA 2003 2004 2005 2006 2007. *TR
NHTSA ODI #10445450
Mileage unknown · Feb 17, 2009
Visibility
HEATER AND A/C BLOWER MALFUNCTION. WIRES AND CONNECTORS WERE HOT TO THE TOUCH AND AFTER A CLOSER LOOK WIRES PROTECTIVE WIRE COVER WERE EXPOSED AND CONNECTORS WERE MELTED THROUGH. THERE WAS ALSO SMOKE IN THE CAB. *TR
CERTAIN SPORT UTILITY VEHICLES AND TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES HAVE AN INCOMPLETE TIRE RIM DESIGNATION ON THE CERTIFICATION/TIRE LABEL LOCATED ON THE DRIVER'S DOOR EDGE. IN ADDITION, THE LABEL MAY ALSO BE MISSING THE TIRE LOAD RATING ON THE LABEL. ALTHOUGH THIS INFORMATION IS NOT REQUIRED BY THE STANDARD, IF A TIRE OF A LESSER LOAD RATING IS INSTALLED, THE TIRE MAY NOT BE ABLE TO SUSTAIN THE LOADS ENCOUNTERED DURING USE.
Consequence & remedy
Consequence: IF A CUSTOMER REPLACES A WHEEL AND ONLY RELIES ON THE RIM SIZE DESIGNATION THAT IS INDICATED ON THE LABEL, A WHEEL THAT IS OF A DIFFERENT RIM CONTOUR DESIGNATION MAY BE INSTALLED. IT MAY BE DIFFICULT OR IMPOSSIBLE TO MOUNT THE TIRE ON A WHEEL WITH THE WRONG CONTOUR. IF THE TIRE IS MOUNTED ON THE WHEEL WITH THE WRONG CONTOUR, THE WHEEL AND TIRE MAY NOT PERFORM AS INTENDED, WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: A LABEL THAT WILL CORRECT THE LABEL ORIGINALLY INSTALLED WILL BE MAILED TO CONSUMERS ALONG WITH INSTALLATION INSTRUCTIONS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL. THE RECALL BEGAON ON NOVEMBER 7, 2006. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239, CHEVROLET AT 1-800-630-2438, AND GMC TRUCKS AT 1-866-996-9463.
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2006 GMC Sierra Problems, Complaints & Recalls | Skip That Year
Illustration