THE HEATING AND AC CONTROLS WERE REPLACED 2 TIMES IN 2007.AND ARE STILL NOT WORKING PROPERLY TODAY I WAS DRIVING HOME WITH THE AC ON BECAUSE IT'S 99 DEGREES IN LOS ANGELES COUNTY AND LIKE IT HAS BEEN DOING FOR YEARS IT STARTED BLOWING HOT AIR ON ITS OWN. I HAVE SEE OTHER GM VEHICLES WITH THE SAME ISSUE. SO I BELIEVE GM IS RESP…
Read full complaint
THE HEATING AND AC CONTROLS WERE REPLACED 2 TIMES IN 2007.AND ARE STILL NOT WORKING PROPERLY TODAY I WAS DRIVING HOME WITH THE AC ON BECAUSE IT'S 99 DEGREES IN LOS ANGELES COUNTY AND LIKE IT HAS BEEN DOING FOR YEARS IT STARTED BLOWING HOT AIR ON ITS OWN. I HAVE SEE OTHER GM VEHICLES WITH THE SAME ISSUE. SO I BELIEVE GM IS RESPONSIBLE FOR CORRECTING THIS ISSUE. *TR
NHTSA ODI #10633779
45,000 miles · Nov 18, 2011
Visibility
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THE VEHICLE WAS REPAIRED UNDER A POSSIBLE SILENT RECALL TO REPLACE THE SUN ROOF GLASS. AFTER THE VEHICLE WAS REPAIRED, THE CONTACT STATED THERE WAS A LEAK IN THE SUN ROOF. THE DEALER WAS NOTIFIED AND MADE AN OFFER TO THE CONTACT AND TOLD THE CONTACT TO SPEAK WITH THE DE…
Read full complaint
TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THE VEHICLE WAS REPAIRED UNDER A POSSIBLE SILENT RECALL TO REPLACE THE SUN ROOF GLASS. AFTER THE VEHICLE WAS REPAIRED, THE CONTACT STATED THERE WAS A LEAK IN THE SUN ROOF. THE DEALER WAS NOTIFIED AND MADE AN OFFER TO THE CONTACT AND TOLD THE CONTACT TO SPEAK WITH THE DEALER WHO SOLD HIM THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 45,065.
NHTSA ODI #10436353
44,500 miles · Mar 11, 2007
Visibility
WINDSHIELD WIPER MOTOR FAILURE. THE WIPERS KEPT OPERATING AT LOW SPEED WITH THE SWITCH POSITION BEING IRRELEVANT. ONLY 44500 MI. ON THE VEHICLE. SINCE, THE MOTOR CONTROL MODULE IS NOT AVAILABLE SEPARATELY THE COMPLETE MOTOR ASSEMBLY HAD TO BE REPLACED. *JB
NHTSA ODI #10184730
9,500 miles · Feb 22, 2005
Visibility
WHILE DRIVING THE SIDEVIEW MIRROR FOLDS INWARD . THE OWNER'S MANUAL STATED THAT THIS WAS A NORMAL PROCEDURE. *AK
NHTSA ODI #10112882
Mileage unknown · Jan 11, 2005
Electrical SystemPower TrainVisibility
THE WINDSHIELD IS LEAKING WATER DOWN INTO THE ELECTRICAL SYSTEM. THE WIRING IS SHORTING OUT. ALSO, THE LINKAGE HAS FALLEN OUT. YOU CAN SMELL BURNT WIRING AND SMOKE. THE CONSUMER HAS CONTACTED THE DEALER SEVERAL TIMES. THE DEALER CONTINUOUSLY TOLD THE CONSUMER THAT THE GENTLEMAN WAS NOT THERE THAT SHE NEEDED TO SEE. CONSUMER HAD …
Read full complaint
THE WINDSHIELD IS LEAKING WATER DOWN INTO THE ELECTRICAL SYSTEM. THE WIRING IS SHORTING OUT. ALSO, THE LINKAGE HAS FALLEN OUT. YOU CAN SMELL BURNT WIRING AND SMOKE. THE CONSUMER HAS CONTACTED THE DEALER SEVERAL TIMES. THE DEALER CONTINUOUSLY TOLD THE CONSUMER THAT THE GENTLEMAN WAS NOT THERE THAT SHE NEEDED TO SEE. CONSUMER HAD SOMEONE ELSE LOOK AT THE VEHICLE. AND WAS TOLD THE VIBRATION FROM DRIVING HAD JARRED THE THE PIN LOOSE. THE BLOWER, HEAT, AND THE TRANSMISSION FAILED. *AK
NHTSA ODI #10107195
Mileage unknown · Nov 18, 2004
Visibility
CONSUMER HAD DIFFICULTY SEEING WHILE DRIVING DUE TO A BLIND SPOT WHEN IT WAS IN REVERSE. PASSENGER'S SIDE MIRROR HAD TROUBLE TELESCOPING TO THE BACK.*AK
NHTSA ODI #10101259
Mileage unknown · Aug 27, 2004
Visibility
THE RIGHT SIDE POWER EXTENDING CAMPER STYLE MIRRORS ON MY 2004 GMC SIERRA 2500HD PICKUP TRUCK HAS BLIND SPOTS THAT WILL NOT ALLOW YOU TO SEE CARS ON THE RIGHT SIDE OF THE TRUCK. YOU EITHER ADJUST THE MIRROR OUT AND POINTING DOWN TO SEE CARS ON THE RIGHT SIDE OR YOU POINT THE MIRROR TOWARDS THE REAR OF THE TRUCK TO SEE THE BACK C…
Read full complaint
THE RIGHT SIDE POWER EXTENDING CAMPER STYLE MIRRORS ON MY 2004 GMC SIERRA 2500HD PICKUP TRUCK HAS BLIND SPOTS THAT WILL NOT ALLOW YOU TO SEE CARS ON THE RIGHT SIDE OF THE TRUCK. YOU EITHER ADJUST THE MIRROR OUT AND POINTING DOWN TO SEE CARS ON THE RIGHT SIDE OR YOU POINT THE MIRROR TOWARDS THE REAR OF THE TRUCK TO SEE THE BACK CORNER OF THE TRUCK TO BACK UP TO THINGS. BUT YOU CAN NOT SEE BOTH AT ONCE.*AK
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Consequence & remedy
Consequence: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.
Consequence & remedy
Consequence: IF THE PARKING BRAKE DOES NOT HOLD, UNINTENDED VEHICLE MOVEMENT COULD OCCUR, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH A PBR PARKING BRAKE SYSTEM. ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM, DEALERS WILL INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY. THE RECALL BEGAN ON JULY 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
CERTAIN EXTENDED AND REGULAR CAB PICKUP TRUCKS AND CARGO VANS CONVERTED TO COMPRESSED NATURAL GAS (CNG) FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE ONE SEATING POSITION, THE CENTER REAR SEAT, EQUIPPED WITH CHILD RESTRAINT LOWER ANCHORAGES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES CHILD SEAT LOWER ANCHORAGES IN TWO SEATING POSITIONS FOR VEHICLES WITH THREE REAR SEATING POSITIONS. THE STANDARD CAB AND CARGO VAN VEHICLES, WHICH ONLY HAVE FRONT SEATING POSITIONS, HAVE AN AIR BAG OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE CHILD RESTRAINT LOWER ANCHORAGES IN THE PASSENGER SEAT. THE STANDARD REQUIRES PASSENGER SEAT CHILD SEAT LOWER ANCHORAGES IN VEHICLES WITH AN AIR BAG OFF SWITCH. HOWEVER, THE STANDARD DOES NOT REQUIRE VEHICLES WITH ONLY FRONT SEATING POSITIONS TO HAVE LOWER ANCHORAGE PROVISIONS IF THE VEHICLE IS NOT EQUIPPED WITH AN AIR BAG OFF SWITCH.
Remedy: TO BRING THE STANDARD CAB AND CARGO VAN VEHICLES INTO COMPLIANCE, DEALERS WILL INJECT EPOXY INTO THE AIR BAG OFF SWITCH TO PREVENT AIR BAG ACTIVATION, RELOCATE THE SWITCH BEHIND THE INSTRUMENT PANEL AND THEN INSTALL A COVER OVER THE RESULTING OPENING. THE SUN VISOR LABEL AND OWNER'S MANUAL WILL ALSO BE CHANGED. THE CORRECTION FOR THE EXTENDED CAB VEHICLE WILL CONSIST OF CHANGING THE FRONT PASSENGER SEAT TO A SEAT THAT HAS CHILD RESTRAINT LOWER ANCHORAGES. THE RECALL BEGAN ON SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Consequence & remedy
Consequence: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
Remedy: DEALERS WILL REPLACE THE CABLES. INTERIM OWNER NOTIFICATION BEGAN ON APRIL 7, 20004. THE RECALL BEGAN ON SEPTEMBER 24, 2004, WHEN REPLACEMENT PARTS WERE AVAILABLE, AND WILL CONTINUE THROUGH OCTOBER 29, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463, OR VISIT WWW.MYGMLINK.COM, AND ENTER YOUR VEHICLE IDENTIFICATION NUMBER.
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Consequence & remedy
Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 GMC Sierra Problems, Complaints & Recalls | Skip That Year
Illustration